Periodic Maintenance Procedures; After Initial 50 Hours Of Operation - Yanmar 2TNV70 Operation Manual

PERIODIC MAINTENANCE
PROCEDURES

After Initial 50 Hours of Operation

Perform the following maintenance after the initial
50 hours of operation.
• Replace Engine Oil and Engine Oil Filter
• Check and Adjust Cooling Fan V-belt
Replace Engine Oil and Engine Oil
Filter
A
WARNING
BURN HAZARD!
• If you must drain the engine oil while it
is still hot, stay clear of the hot engine
oil to avoid being scalded. Make sure
you wear eye protection.
• Failure to comply could result in death
or serious injury.
A
WARNING
SUDDEN MOVEMENT HAZARD!
• Allow the engine to warm-up for at
least 5 minutes to allow the engine idle
speed to return to normal before
engaging the transmission or any PTO
attachments. Engaging the
transmission or PTO at an elevated
engine speed could result in an
unexpected movement of the
equipment.
• Failure to comply could result in death
or serious injury.
TNV Operation Manual
• Only use the engine oil specified.
Other engine oils may affect warranty
coverage, cause internal engine
components to seize, or shorten
engine life.
• Prevent dirt and debris from
contaminating engine oil. Carefully
clean the oil cap / dipstick and the
surrounding area before you remove
the cap.
• NEVER mix different types of engine
oil. This may adversely affect the
lubricating properties of the engine oil.
• NEVER overfill. Overfilling may result
in white exhaust smoke, engine
overspeed or internal damage.
Be responsible to the environment.
Follow these procedures for hazardous
waste disposal. Failure to follow these
0000011en
procedures may seriously harm the
environment.
• Follow the guidelines of the EPA or
other governmental agency for the
proper disposal of hazardous
materials such as engine oil, diesel
fuel and engine coolant. Consult the
local authorities or reclamation facility.
• NEVER dispose of hazardous
materials irresponsibly by dumping
them into a sewer, on the ground or
into ground water or waterways.
0000006en
PERIODIC MAINTENANCE
CAUTION
CAUTION
0000005en
0000013en
75