Table Of Contents - Heatilator ECLIPSE-32 Installation Manual

Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Installation Standard Work Checklist . . . . . . . . . . . . . . . . . . . . 3
1 Product Specifi c and Important Safety Information
A. Appliance Certifi cation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
B. Glass Specifi cations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
C. BTU Specifi cations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 4
E. Non-Combustible Materials Specifi cation. . . . . . . . . . . . . . 4
F. Combustible Materials Specifi cation . . . . . . . . . . . . . . . . . 4
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
H. Requirements for the Commonwealth of Massachusetts . . 5
2 Getting Started
A. Design and Installation Considerations . . . . . . . . . . . . . . . 6
B. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . . 6
C. Inspect Appliance and Components . . . . . . . . . . . . . . . . . . 6
3 Framing and Clearances
A. Appliance/Decorative Front Dimension Diagrams . . . . . . . 7
B. Clearances to Combustibles . . . . . . . . . . . . . . . . . . . . . . . 9
C. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 10
D. Floor Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
4 Termination Location and Vent Information
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 11
B. Chimney Diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
C. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
D. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
E. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
F. Use of Flex Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

G. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
5 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 28
B. Wall Penetration Framing/Firestops . . . . . . . . . . . . . . . . . 28
C. Ceiling Firestop/Floor Penetration Framing . . . . . . . . . . . 29
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 29
6 Appliance Preparation
A. Vent Collar Preparation - Top or Rear . . . . . . . . . . . . . . . 30
B. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 32
2

Table of Contents

Heatilator • ECLIPSE-32, ECLIPSE-36 Installation Manual • 2297-984 Rev. B • 6/15
7 Venting and Chimneys
A. Assemble Vent Sections (DVP Pipe) . . . . . . . . . . . . . . . . 33
B. Assemble Vent Sections (SLP Pipe) . . . . . . . . . . . . . . . . 34
C. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 34
D. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 35
E. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 35
F. Vertical Termination Requirements . . . . . . . . . . . . . . . . . . 36
G. Horizontal Termination Requirements . . . . . . . . . . . . . . . 37
8 Electrical Information
A. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
B. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
9 Gas Information
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
C. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 42
E. Air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
10 Finishing
A. Facing and Finishing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
B. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 45
11 Appliance Setup
A. Remove Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . 46
B. Remove the Shipping Materials . . . . . . . . . . . . . . . . . . . . 46
C. Clean the Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
D. Install the Stones and Lava Rock . . . . . . . . . . . . . . . . . . . 47
E. Install Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . 48
F. Install Decorative Front . . . . . . . . . . . . . . . . . . . . . . . . . . 48
12 Reference Materials
A. Vent Components Diagrams . . . . . . . . . . . . . . . . . . . . . . 49
B. Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
 = Contains updated information.
