Aquacal TropiCal T115 Owner's Manual And Installation Manual page 33

START
START
If the heater is turning on and
If the heater is turning on and
off every 5 minutes:
off every 5 minutes:
Make sure all water valves are
Make sure all water valves are
in the correct position, allowing
in the correct position, allowing water to flow through the
water to flow through the
heater. Be sure filters and
heater. Be sure filters and
pump skimmer baskets are
pump skimmer baskets are
clean. Check to be sure the
clean. Check to be sure the
water level in the pool is not
water level in the pool is not
below the skimmer.
below the skimmer.
Yes
Yes
Yes
Inspect the fan motor/capacitor
Inspect the fan motor/capacitor
*
See DANGER Statement
*
See DANGER Statement
Problem Solved.
Problem Solved.
Heater Short Cycling
Analog Controls - 12/22/03
Is the flow light on
Is the flow light on
and heater
operating correctly? and heater
operating correctly?
Is the flow light on
and the heater Is the flow light on
and the heater
operating correctly?
operating correctly?
Heater
Heater
operating correctly?
operating correctly?
No
Is the fan operating?
Is the fan operating?
as needed.
as needed.
No
Heater
Yes
Heater
operating correctly?
operating correctly?
Inspect water pressure switch for
Inspect water pressure switch for normal operation; adjust
normal operation; adjust
No
sensitivity if necessary .
sensitivity if necessary .
*
See DANGER statement.
*
See DANGER statement.
Re-confirm that water is flowing
No through the heater...Check for Re-confirm that water is flowing
through the heater...Check for
flow at Pool/Spa returns.
flow at Pool/Spa returns.
Be sure the evaporator is clean
Be sure the evaporator is clean
Yes and free of air restricting
Call AquaCal for Assistance:
Call AquaCal for Assistance:
No
*
Any operation described in this
flow chart, requiring the heater
access panel be removed,
MUST be performed only by
authorized service personnel.
and free of air restricting
obstructions.
obstructions.
800-786-7751
800-786-7751
33