Page 1
INSTALLATION OPERATING INSTRUCTIONS X’Vert Model: VERTICAL CONTACT BUN GRILL TOASTER INTENDED FOR OTHER THAN HOUSEHOLD USE RETAIN THIS MANUAL FOR FUTURE REFERENCE TOASTER MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
The user places both buns into the top of the toaster and two perfectly caramelized, warm buns (4 halves) will slide out of the bun chute. The VSX will toast two buns in 8, 20 or 30 seconds (depending on your model).
Failure to replace a damaged cord will void the warranty. Overall Dimensions: Electrical Ratings: VSX: 24”H x 19”W x 11” D VSX: 208V - 2570W, 12.5 Amps 60HZ (61 cm x 48 cm x 28 cm) VSX: 240V - 3420W, 14.5 Amps 60HZ...
Bun Thickness Dials to achieve desired brownness and temperature. Bun Thickness Adjustment The VSX is designed to accommodate a variety of different products. Adjust for product thickness by setting the Bun Thickness Dials on the side of the toaster to the appropriate setting.
Page 5
HEEL IN CROWN BACK IN FRONT DISCHARGE VSX-10 Temperature Control (See Figure 6) NO HEAT: When the knob is pointed here, all heat is cut off from the platen. The conveyors will run, but the platen will not heat. PILOT: Illuminated when power is being applied to heater.
Page 6
Cleaning Instructions Toaster is for DRY BUNS ONLY. the toaster. Note: To save time at closing (it will take 15 minutes for toaster to cool down), you might want to have the day shift clean the toaster. Turn off (7) Main Power Switch (See Fig. 7). Allow toaster to cool down. Remove (6) Bun Slide and (1) Top Cover (See Fig.
6. TROUBLESHOOTING GUIDE Always ask and check the following: Service Hotline (800) 733-2203...
Page 8
Problem Possible Cause Corrective Action (See page 9)
Page 9
Problem Corrective Action Possible Cause Manual Reset Thermostat The manual reset is a device that provides thermal protection for the platen. In the event that the main controller or power relay fails to regulate the heat on the platen, the manual reset thermostat will break the electrical connection to the platen.
7. PREVENTATIVE MAINTENANCE SCHEDULE Tools required: Daily: Heat Resistant Gloves, Standard Cleaner, Standard Sanitizer, Cleaning Pad. Weekly: Lubricant 3-6 Months : Needle Nose Pliers, Standard Cleaner, Standard Sanitizer, Cleaning Pad Yearly: Phillips Screwdriver, Standard Lubricating Oil, Needle Nose Pliers 1) Preventative Maintenance - WARNING! Toaster may be hot.
Page 11
PROPER LONG TERM PERFORMANCE. PREVENTATIVE MAINTENANCE OF THE INTERNAL COMPONENTS IS A RECOMMENDED PROCEDURE THAT MUST BE COMPLETED BY A KNOWLEDGEABLE TECHNICIAN, SUCH AS AN APW WYOTT AUTHORIZED SERVICE TECHNICIAN. PREVENTATIVE MAINTENANCE IS THE RESPONSIBILITY OF THE OWNER, AND IS NOT COVERED UNDER THE WARRANTY AGREEMENT PROVIDED WITH THE TOASTER.
Page 12
IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment. For Warranty Service and/or Parts, this information is required. Model Number Serial Number Date Purchased Notes...
FIGURE 9: WIRING DIAGRAM - VSX-10 TOASTER PILOT LIGHT THERMOSTAT TOP VIEW FRONT SWITCH MAIN POWER WHITE OR BLUE WIRE FROM CORD BLACK OR BROWN WIRE GREEN WIRE FROM CORD FIGURE 10: WIRING DIAGRAM - VSX-20 TOASTER MANUAL RELAY LIMIT SW...