Table of Contents
Advertisement
SERVICE MANUAL
MODEL
KV-28FX66B
KV-28FX66E
KV-28FX66U
COMMANDER
DEST
CHASSIS NO.
RM-937
FR
SCC-Q83H-A
RM-937
ESP
SCC-Q81K-A
RM-937
UK
SCC-Q84F-A
KV-28/32FX66
MODEL
KV-32FX66B
KV-32FX66E
KV-32FX66K
KV-32FX66U
- 1 -
AE-6B
CHASSIS
COMMANDER
DEST
CHASSIS NO.
RM-937
FR
SCC-Q83G-A
RM-937
ESP
SCC-Q81J-A
RM-937
OIRT
SCC-Q82E-A
RM-937
UK
SCC-Q84E-A
RM-937
Advertisement
Table of Contents
Related Manuals for Sony TrinitronKV-28FX66B
Summary of Contents for Sony TrinitronKV-28FX66B
-
Page 1: Service Manual
SERVICE MANUAL AE-6B CHASSIS MODEL MODEL COMMANDER DEST CHASSIS NO. COMMANDER DEST CHASSIS NO. KV-28FX66B KV-32FX66B RM-937 SCC-Q83H-A RM-937 SCC-Q83G-A KV-28FX66E KV-32FX66E RM-937 SCC-Q81K-A RM-937 SCC-Q81J-A KV-28FX66U KV-32FX66K RM-937 SCC-Q84F-A RM-937 OIRT SCC-Q82E-A KV-32FX66U RM-937 SCC-Q84E-A KV-28/32FX66 RM-937 - 1 -... -
Page 2: Table Of Contents
PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE TANCE CRITIQUE POUR LA SÈCURITÈ DU FONCTIONNEMENT, NE LES REMPLACER QUE PAR DES COMPSANTS SONY DONT THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN LE NUMÈRO DE PIÈCE EST INDIQUÈ... - Page 3 Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -...
- Page 4 l l a l l a . s l . s l . s l . s l . s l e i l . s l t c i n i l i n i y t i - 4 -...
- Page 5 21 pin connector Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A Standard level : 0.5V rms (left) Output impedence : Less than 1kohm*...
-
Page 6: Self Diagnostic Software
AE-6B SELF DIAGNOSTIC SOFTWARE The identification of errors within the AE-6B chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty. -
Page 7: General
SECTION 1 GENERAL - 7 -... - Page 8 - 8 -...
- Page 9 - 9 -...
- Page 10 - 10 -...
- Page 11 - 11 -...
-
Page 12: Disassembly
SECTION 2 DISASSEMBLY 2-1. Rear Cover Removal 2-2. Speaker Connector Disconnection => <= => <= => Remove the rear cover fixing screws indicated. Take care Before completely removing the rear cover disconnect the speaker connector which is located on the inside. when removing the rear cover not to damage the speaker cables [Disconnect the speaker connector] as speakers are fitted inside the rear cover. -
Page 13: Service Position
2-4. Service Position 2-5. G Board Removal Clips To remove the G Board release the clips circled and ease the Position the chassis as indicated to access the solder side. board gently away from the support bracket. To gain access to the underside of the boards follow the instructions on page 16. -
Page 14: Side Control Module Removal
2-8. Side Control Module Removal 2-9. H2 Board Removal Screws Clips Remove the two screws fixing the user control module to the To remove the H2 Board release the two clips circled and ease side of the set. The control module can then be removed by the board gently away from the support bracket. -
Page 15: Picture Tube Removal
2-12. Picture Tube Removal WARNING: BEFORE REMOVING THE ANODE CAP High voltage remains in the CRT even after the power is disconnected. To avoid electric shock, discharge CRT before attempting to remove the anode cap. Short between anode and CRT coated earth ground strap. - Page 16 - 16 -...
-
Page 17: Set-Up Adjustments
SECTION 3 SET-UP ADJUSTMENTS • When complete readjustment is necessary or a new picture tube Carry out the adjustments in the following order : is installed, carry out the following adjustments. 3-1. Beam Landing. • Unless there are specific instructions to the contrary, carry out 3-2. -
Page 18: Convergence
Fig.3-4 Align both Purity Purity magnets Purity control magnets magnets to the vertical position Align pips on each magnet 3-2. Convergence (1) Screen centre convergence [Static convergence] Input a dot pattern signal from the pattern generator. Normalize the picture setting. [Moving vertically], adjust the V.STAT magnet so that the vertical red, green and blue dots coincide at the centre of the screen. - Page 19 Correction for HMC [Horizontal mis-convergence] and VMC HTIL correction can be performed by adding a THL correction [Vertical mis-convergence] by using the BMC [Hexapole] assembly to the Deflection yoke. magnet. a). HMC correction by BMC [Hexapole] magnet and movement of the electron beam.
-
Page 20: Focus Adjustment
Layout of each control 3-3. Focus Adjustment Receive a television broadcast signal. Normalize the picture setting. Purity magnet Adjust the focus control located on the flyback transformer to BMC (Hexaploe) magnet obtain the best focus at the centre of the screen. V STAT convergence magnet Bring only the centre area of the screen into focus, the magenta- Y-splitting axis correction magnet... -
Page 21: Electrical Adjustments
SECTION 4 CIRCUIT ADJUSTMENTS 4-1. Electrical Adjustments Service adjustments to this model can be performed using the supplied remote Commander RM-937. Programming the Remote Commander for Operation in Service Mode Press the VCR/TV/DVD button until the TV LED lights. Press and hold the yellow button for approx. - Page 22 Sub Brightness Adjustment Input a Monoscope pattern. Program the Remote Commander for operation in Service Mode. [ See Page 21 ]. Press ‘VIDEO’ ‘VIDEO’ 13 on the Remote Commander. Adjust the ‘Sub-Brightness’ data so that there is barely a difference between the 0 IRE and 10 IRE signal levels. Sub Contrast Adjustment Input a video signal that contains a small 100% white area on a black background.
-
Page 23: Test Mode
Deflection System Adjustment 4-2. TEST MODE 2: Program the Remote Commander for operation in Service Mode. Test Mode 2 is available by rogramming the Remote Commander for [ See Page 21 ] and enter into the ‘Geometry’ service menu. operation in Service Mode [ As shown on Page 21 ] then pressing the Select and adjust each item in order to obtain the optimum image. - Page 24 Memo - 24 -...
-
Page 25: Block Diagrams
5-1. BLOCK DIAGRAMS (1) CN7444 D0993 CN0991 QP (-) POWER IC0991 STBY+5V CN7442 TO A BOARD QP (+) QP (-) CN6991 CN6992 SIRCS CN0103 TO A BOARD QP (-) QP (+) TO G BOARD VM AMPLIFIER CN7000 BUFFER Q7400 CN6001 QP (+) VM AMPLIFIER VM AMP... -
Page 26: Block Diagrams
5-1. BLOCK DIAGRAMS (2) TO A BOARD 6dB AMPLIFIER SHEET1 FOR THE SELECTABLE OUTPUT CVBS PART OF (3RD SCART) TO D BOARD OVERVOLTAGE FV (T6800) Q3202 PROTECTION Q5816 J7375 IC7300 CN6200 6dB AMPLIFIER VIDEO OUT (RED) CN7301 FOR THE TO G BOARD SELECTABLE V OUT 3 CN6008... -
Page 27: Block Diagrams
5-1. BLOCK DIAGRAMS (3) COMPARATOR IC8103 CN8810 V STAT TO A BOARD DY ASSY CN5002 H CENTRE CN8611 M PIN CONT V- DY+ CN8620 V- DY- V DY DF PARA MP PARA Q8201, H DY 8202,8118 H- DY- H LIN TO A BOARD H- DY+ Q8136,8137... -
Page 28: Block Diagrams
5-1. BLOCK DIAGRAMS (4) IC0006 5-2. CIRCUIT BOARD LOCATION Reference Information A(0) A(1) A(2) RESISTOR : METAL FILM A(3) : SOLID A(4) A(5) C Board FPRD : NON FLAMMABLE CARBON A(6) A(7) FUSE : NON FLAMMABLE FUSIBLE A(8) A(9) : NON FLAMMABLE METAL OXIDE L Board A(10) VM Board... - Page 29 A Schematic [ Video & Audio Processors, Audio Output, Vertical Deflection] page 1/2~ - 29 -...
- Page 30 ~ A Board Waveforms ~ 5ms/div 2ms/div 744 mVp-p (V) 53 Vp-p (V) 20us/div 10us/div 1.4 Vp-p (H) 688 mVp-p (H) 5ms/div 5ms/div 264 mVp-p (H) 272 mVp-p (H) ~ A Board Difference Table ~ A Schematic [ Video & Audio Processors, Audio Output, Vertical Deflection] page 2/2~ - 30 -...
- Page 31 ~ A Printed Wiring Board Conductor side A ~ - 31 -...
- Page 32 ~ A Printed Wiring Board Conductor side B ~ - 32 -...
- Page 33 VM Printed Wiring Board Conductor side ~ ~ VM Board Waveforms ~ ~ VM Board Voltage Table ~ 5ms/div 5ms/div 5ms/div 1.54 Vp-p (H) 1.4 Vp-p (H) 20 Vp-p (H) ~ A Board Location Table (A Side) ~ ~ A Board Location Table (B Side) ~ - 33 -...
- Page 34 ~ A Board Semiconductor Voltage Table ~ ~ A Board IC Voltage Table ~ - 34 -...
-
Page 35: Vm Board Schematic
~ H2 Board Schematic Diagram [ Front AV & Headphone ] ~ ~ F4 Board Schematic Diagram [ Power Switch & Fuse ] ~ ~ H1 Board Schematic Diagram [ LED & IR Receiver ] ~ ~ VM Board Schematic Diagram [ Velocity Modulation ] ~ - 35 -... - Page 36 ~ G Board Semiconductor Location Table ~ ~ G Printed Wiring Board Conductor side ~ ~ H1 Printed Wiring Board Conductor side ~ ~ H2 Printed Wiring Board Conductor side ~ Note : Portions of the circuit contained within the marked areas as shown have high voltages present.
-
Page 37: G Board Schematic
~ G Board Schematic Diagram [ Power Supply ] ~ - 37 -... -
Page 38: C Board Schematic
~ C Board Schematic Diagram [ R-G-B Out ] ~ - 38 -... - Page 39 ~ C Printed Wiring Board Conductor side ~ ~ M2 Printed Wiring Board Conductor side A ~ ~ C Board Waveforms ~ 10us/div 10us/div 2.16 Vp-p (H) 2.0 Vp-p (H) 10us/div 10us/div ~ M2 Printed Wiring Board Conductor side B ~ 1.9 Vp-p (H) 6.8 Vp-p (H) 10us/div...
-
Page 40: M2 Board Schematic
~ M2 Board Schematic Diagram [ Micro• Processor ] ~ - 40 -... - Page 41 ~ D Printed Wiring Board Conductor side ~ ~ D Board Waveforms ~ ~ D Board IC Voltage Table ~ ~ D Board Semiconductor Voltage Table ~ 10us/div 10us/div 10us/div 10us/div 10us/div 2.44 Vp-p (V) 148 Vp-p (V) 2.36 Vp-p (H) 152 Vp-p (H) 1.12 kVp-p (H) 10us/div...
-
Page 42: D Board Schematic
~ D Board Schematic Diagram [ Deflection ] ~ - 42 -... -
Page 43: D2 Board Schematic
~ D2 Board Schematic Diagram [ Dynamic Picture Stabilising Circuit ] ~ ~ L Board Schematic Diagram [ Locator ] ~ - 43 -... -
Page 44: Semiconductors
~ D Board Difference Table ~ ~ L Printed Wiring Board Conductor side ~ 5-4. SEMICONDUCTORS CXAB070AP PST573IMT LM318P MCZ3001D LM358N LM393DT LM393N M24C16-MN6T(A) ~ D2 Board Difference Table ~ CXA1875AM-T4 SAA5665HL/M1D/0358 LM78L05ACZ ( TOP VIEW ) CXA2100AQ-TL MSP3411G-QA-B10 SBX3081-51(30) ~ D2 Printed Wiring Board Conductor side ~ (TOP VIEW) ( TOP VIEW ) - Page 45 DTA144EK SE135N-LF4 DTC144TKA-T146 2SA1162-G SENSE 2 COLLECTOR 3 GND TDA6111Q/N4 DTA144ESA 2SA933AS-QT 2SC2785-HFE 2SA1837(LBS2S0N) TDA7497 L7809CV/LSY STP5NB40FP STP5NB40(030Y) 2SC5698-CA 2SB734-34 2S5696-SONY-CA VPS9402-A32GEG 2SC2688(5)-LK MSB709-RT1 MSD601-RST1 M1MA152WA-T1 UN2111 UN213 2SK2036(TE85L) (TOP VIEW) BA12T BAO33T BAS216 IRF614-005 RB705D IRF620 SPA07N60C2 2SA2005 2SC5511...
- Page 46 BAS316-115 FBIU4D7MA-B MMDL914T1 RBV-406B UDZSTE-176.2B S1VB40 ANODE CATHODE BYV98-200-RAS 15/12 CATHODE GS1B460/45 ANODE D1NL20U EGP20G EL1Z GP08D UF4005PKG23 CATHODE TLHK5190 ANODE CATHODE ANODE D2S4MTA1 ERA38-06 MTZJ-T-77-22 ERA85-009 RD15ES-B2 HZS9.1NB2 RD39ES-B2 MTZJ-13B RD5.6ESB2 MTZJ-33B 1SS119-25 MTZJ-3.6A 1SS133T-77 MTZJ-4.7C CATHODE ANODE - 46 -...
-
Page 47: Ic Block Diagrams
5-5 IC BLOCK DIAGRAMS A BOARD IC6202/IC6205 BA033T/BA12T REFERENCE VOLTAGE A BOARD IC2500 TDA7497 VOLUME OP AMP MUTE/STBY PROTECTIONS VOLUME OP AMP G BOARD IC6001 MCZ3001D Remote DVLD Internal Driver ref 5v Sel=34v 15v/8v Reg. 10v Level Shift Vsense Control Logic Latch Centre... - Page 48 A BOARD IC2000 MSP3411G SBUS Interface I2C Interface DEMODULATOR IDENT SCART Switching Facilities G BOARD IC6003 SE135N-LF4 A BOARD IC5301/IC5302 LA6393DLL A BOARD IC5400 STV9379 A BOARD IC5300 LM358N FLYBACK GENERATOR POWER AMPLIFIER THERMAL PROTECTION - 48 -...
-
Page 49: Exploded Views
SECTION 6 EXPLODED VIEWS NOTE : Items with no part number and no description are not Items marked “*” are not stocked stocked because they are seldom required for routine since they are seldom required for service. routine service. Some delay should The construction parts of an assembled part are indicated be anticipated when ordering these with a collation number in the remarks column. - Page 50 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK *A-1300-530-A D2 BOARD, COMPLETE (KV-28FX66) 1-529-417-11 SPEAKER (8CM) (KV-28FX66) *A-1300-514-A D2 BOARD, COMPLETE (KV-32FX66) 1-529-408-11 SPEAKER (4.2x24CM) (KV-32FX66) *A-1300-168-A D BOARD, COMPLETE (KV-28FX66) 4-039-358-01 SCREW (4x16), (+) BV TAPPING (KV-28FX66) *A-1300-174-A D BOARD, COMPLETE (KV-32FX66) 7-685-663-71 SCREW +BVTP 4x16 TYPE 2 IT-3 (KV-32FX66) *4-087-469-11 BRACKET, D2 (KV-28FX66) *4-204-775-21 BAFFLE WOOFER (KV-28FX66)
-
Page 51: Picture Tube
6-2. PICTURE TUBE REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK *X-4040-352-1 BEZNET ASSY (KV-28FX66) 52-56 *X-4040-335-1 BEZNET ASSY (KV-32FX66) 4-205-699-03 POWER BUTTON (KV-28FX66) 4-205-720-02 POWER BUTTON (KV-32FX66) 4-202-964-11 SPRING (KV-28FX66) 4-204-426-01 SPRING (KV-32FX66) 4-205-698-02 GUIDE, LIGHT 4-088-950-01 BUTTON LOCATOR 4-088-949-01 GUIDE LIGHT, LOCATOR 4-205-696-31 DOOR (KV-28FX66) 4-206-541-11 DOOR (KV-32FX66) - Page 52 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK 4-203-658-01 SPACER, DY (KV-28FX66) 4-308-870-00 CLIP, LEAD WIRE 3-704-495-01 SPACER, DY (KV-32FX66) 1-452-094-00 MAGNET, ROTATABLE DISK; 15MM £ 8-735-099-05 PICTURE TUBE (W66LLX060X)(KV-28FX66) 1-452-032-00 MAGNET, DISK; 10MM £ 8-735-079-05 PICTURE TUBE (W76LLZ060X)(KV-32FX66) X-4387-214-1 PERMALLOY ASSY, CORRECTION 4-036-188-01 SCREW SELF TAPPING 3-701-007-00 BAND, BINDING 4-046-765-12 SCREW, TAPPING 7+CROWN WASHER (KV-32FX66)
-
Page 53: Electrical Parts List
SECTION 7 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page D BOARD COMMON Parts List : Parts common to all models listed in this manual ..54 D BOARD VARIANT Parts List : Parts that belong only to the model specified Model KV-28FX66 .................. - Page 54 H6 D REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C8820 1-125-893-11 FILM 680PF 3.00% 1.5KV *A-1300-168-A D Board, Complete (KV-28FX66) *A-1300-174-A D Board, Complete (KV-32FX66) C8824 1-107-846-11 FILM 0.1UF 5.00% 400V C8827 1-107-846-11 FILM 0.1UF 5.00% 400V 4-382-854-01 SCREW (M3X8), P, SW (+) C8828 1-127-681-11 FILM 10000PF...
- Page 55 DESCRIPTION REMARK D8859 8-719-081-97 DIODE MMDL914T1 Q8801 8-729-048-47 TRANSISTOR 2SC2688(5)-LK Q8802 8-729-048-47 TRANSISTOR 2SC2688(5)-LK < FERRITE BEAD > Q8803 8-729-056-16 TRANSISTOR 2SC5698-SONY-CA Q8804 8-729-056-17 TRANSISTOR 2SC5696-SONY-CA FB8807 1-410-397-21 FERRITE 1.1UH Q8805 8-729-050-48 TRANSISTOR IRF614-005 < IC > Q8806 8-729-047-59 TRANSISTOR STP5NB40FP...
- Page 56 B1 D REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8145 1-216-825-11 RES-CHIP 2.2K 5% 1/10W R8835 1-260-288-11 CARBON 0.47 5% 1/2W R8146 1-208-790-11 METAL CHIP 2.2K 0.5% 1/10W R8842 1-260-328-11 CARBON 1/2W R8153 1-216-295-91 SHORT CHIP R8844 1-216-838-11 RES-CHIP 1/10W R8160 1-216-295-91 SHORT CHIP...
- Page 57 F4 D REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8216 1-216-841-11 RES-CHIP 1/10W C6007 1-126-964-11 ELECT 10UF 20.00% 50V R8810 1-215-896-00 METAL OXIDE 4.7K 5% C6008 1-126-963-11 ELECT 4.7UF 20.00% 50V R8897 1-215-485-00 METAL 470K 1% 1/4W C6010 1-136-165-00 FILM 0.1UF 5.00% 50V C6011...
- Page 58 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < DIODE > < TRANSISTOR > D6001 6-500-067-01 DIODE GSIB460L/45 Q6003 8-729-010-29 TRANSISTOR MSD601-RST1 D6002 8-719-982-26 DIODE MTZJ-33B Q6005 8-729-029-56 TRANSISTOR DTA144ESA D6004 8-719-979-64 DIODE UF4005PKG23 Q6006 6-550-146-01 TRANSISTOR SPA07N60C2-E8152 D6006 8-719-081-97 DIODE MMDL914T1 Q6007 6-550-146-01 TRANSISTOR SPA07N60C2-E8152 D6007...
- Page 59 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6054 1-216-615-11 METAL CHIP 0.5% 1/10W C2001 1-162-968-11 CERAMIC CHIP 0.0047UF 10.00% 50V R6056 1-216-295-91 SHORT CHIP C2006 1-162-962-11 CERAMIC CHIP 470PF 10.00% 50V R6101 1-216-821-11 RES-CHIP 1/10W C2007 1-163-021-91 CERAMIC CHIP 0.01UF 10.00% 50V R6102 1-216-829-11 RES-CHIP...
- Page 60 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C2065 1-162-966-11 CERAMIC CHIP 0.0022UF 10.00% 50V C3209 1-163-235-11 CERAMIC CHIP 22PF 5.00% 50V C2066 1-162-966-11 CERAMIC CHIP 0.0022UF 10.00% 50V C3210 1-126-964-11 ELECT 10UF 20.00% 50V C2069 1-127-715-91 CERAMIC CHIP 0.22UF C3211 1-126-964-11 ELECT 10UF...
- Page 61 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C5120 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C5889 1-126-964-11 ELECT 10UF 20.00% 50V C5121 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C5890 1-164-227-11 CERAMIC CHIP 0.022UF 10.00% 25V C5122 1-164-156-11 CERAMIC CHIP 0.1UF C5891 1-137-581-11 FILM 0.1UF...
- Page 62 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C7059 1-126-933-11 ELECT 100UF 20.00% 16V D3001 8-719-929-15 DIODE HZS9.1NB2 C7060 1-164-222-91 CERAMIC CHIP 0.22UF D3003 8-719-929-15 DIODE HZS9.1NB2 C7061 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V D3005 8-719-929-15 DIODE HZS9.1NB2 C7062 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V D3007 8-719-109-89 DIODE RD5.6ESB2...
- Page 63 H5 D2 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < FILTER > L3008 1-216-295-91 SHORT CHIP L3009 1-216-295-91 SHORT CHIP FL2000 1-239-803-11 FILTER, EMI L3010 1-216-295-91 SHORT CHIP L3011 1-216-295-91 SHORT CHIP < IC > L3012 1-216-295-91 SHORT CHIP IC2000 6-701-031-01 IC MSP3411G-QA-B10 L3200...
- Page 64 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q3302 8-729-010-05 TRANSISTOR MSB709-RT1 R1004 1-216-809-11 RES-CHIP 1/10W Q3500 8-729-028-28 TRANSISTOR 2SK2036(TE85L) R1005 1-216-049-11 RES-CHIP 1/10W Q3501 8-729-028-28 TRANSISTOR 2SK2036(TE85L) R1006 1-216-051-00 RES-CHIP 1.2K 5% 1/10W Q5100 8-729-010-05 TRANSISTOR MSB709-RT1 R1007 1-412-987-31 INDUCTOR 4.7UH Q5101 8-729-010-29 TRANSISTOR MSD601-RST1...
- Page 65 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2065 1-216-837-11 RES-CHIP 1/10W R2921 1-216-295-91 SHORT CHIP R2066 1-216-829-11 RES-CHIP 4.7K 5% 1/10W R2924 1-216-295-91 SHORT CHIP R2067 1-216-829-11 RES-CHIP 4.7K 5% 1/10W R2927 1-216-295-91 SHORT CHIP R2068 1-216-049-11 RES-CHIP 1/10W R2930 1-216-295-91 SHORT CHIP R2069...
- Page 66 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3234 1-216-821-11 RES-CHIP 1/10W R5157 1-216-829-11 RES-CHIP 4.7K 5% 1/10W R3235 1-216-822-11 RES-CHIP 1.2K 5% 1/10W R5300 1-208-806-11 METAL CHIP 0.5% 1/10W R3236 1-216-822-11 RES-CHIP 1.2K 5% 1/10W R5301 1-216-829-11 RES-CHIP 4.7K 5% 1/10W R3237 1-216-797-11 RES-CHIP...
- Page 67 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R5402 1-216-081-00 RES-CHIP 1/10W R7035 1-216-025-11 RES-CHIP 1/10W R5403 1-216-829-11 RES-CHIP 4.7K 5% 1/10W R7048 1-216-025-11 RES-CHIP 1/10W R5404 1-216-829-11 RES-CHIP 4.7K 5% 1/10W R7050 1-216-833-11 RES-CHIP 1/10W R5405 1-216-829-11 RES-CHIP 4.7K 5% 1/10W R7051 1-216-025-11 RES-CHIP...
- Page 68 A D2 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C1017 1-163-247-91 CERAMIC CHIP 68PF 5.00% 50V A Board, Variant Parts KV-28FX66U/32FX66U < COIL > < CAPACITOR > L1004 1-412-751-11 INDUCTOR 18UH C1011 NOT FITTED C1012 NOT FITTED < TRANSISTOR > C1016 NOT FITTED C1017...
- Page 69 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C6816 1-126-964-11 ELECT 10UF 20.00% 50V D6823 8-719-911-19 DIODE 1SS119-25 C6820 1-130-495-00 MYLAR 0.1UF 5.00% 50V D6824 8-719-911-19 DIODE 1SS119-25 C6821 1-126-964-11 ELECT 10UF 20.00% 50V D6825 8-719-911-19 DIODE 1SS119-25 C6822 1-126-966-11 ELECT 33UF 20.00% 50V D6831...
- Page 70 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6811 1-202-933-61 FUSIBLE 1/2W R6896 1-216-839-11 RES-CHIP 1/10W R6812 1-218-869-11 METAL CHIP 8.2K 0.5% 1/10W R6897 1-216-853-11 RES-CHIP 470K 5% 1/10W R6813 1-249-393-11 CARBON 1/4W R8949 1-216-486-21 METAL OXIDE 8.2K 5% R6814 1-249-393-11 CARBON 1/4W R8951...
- Page 71 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D7378 8-719-109-89 DIODE RD5.6ESB2 *A-1300-578-A C Board, Complete D7379 8-719-109-89 DIODE RD5.6ESB2 4-382-854-01 SCREW (M3X8), P, SW (+) < IC > < CAPACITOR > IC7300 8-759-360-83 IC TDA6111Q/N4 C7303 1-162-909-11 CERAMIC CHIP 4PF 0.25PF 50V IC7325 8-759-360-83 IC TDA6111Q/N4...
- Page 72 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R7374 1-216-819-11 RES-CHIP 1/10W C0023 8-719-109-89 DIODE RD5.6ESB2 R7375 1-249-435-11 CARBON 1/4W C0024 8-719-109-89 DIODE RD5.6ESB2 R7376 1-249-429-11 CARBON 1/4W C0025 1-162-962-11 CERAMIC CHIP 470PF 10.00% 50V R7377 1-249-430-11 CARBON 1/4W C0026 1-162-962-11 CERAMIC CHIP 470PF 10.00% 50V R7379...
- Page 73 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK IC0008 8-759-392-01 IC TC7SH86FU-TE85R R0048 1-216-809-11 RES-CHIP 1/10W IC0010 8-759-523-81 IC TC74VHC08FT(EL) R0049 1-216-833-11 RES-CHIP 1/10W R0050 1-216-810-11 RES-CHIP 1/10W < TRANSISTOR > R0051 1-216-835-11 RES-CHIP 1/10W R0052 1-216-810-11 RES-CHIP 1/10W Q0002 8-729-424-08 TRANSISTOR UN2111 Q0003 8-729-424-08 TRANSISTOR UN2111...
- Page 74 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK *A-1400-969-A L Board, Complete *A-1300-627-A VM Board, Complete < CAPACITOR > 4-382-854-01 SCREW (M3X8), P, SW (+) C0701 1-162-913-11 CERAMIC CHIP 8PF 0.50PF 50V < CAPACITOR > C0702 1-164-227-11 CERAMIC CHIP 0.022UF 10.00% 25V C0703 1-162-908-11 CERAMIC CHIP 3PF...
- Page 75 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q7403 8-729-119-78 TRANSISTOR 2SC2785-HFE CN6993 1-695-915-11 TAB (CONTACT) Q7404 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q7405 8-729-026-39 TRANSISTOR 2SA933AS-QT < FUSE > Q7406 8-729-045-05 TRANSISTOR 2SA2005 Q7407 8-729-045-04 TRANSISTOR 2SC5511 F6991 £ 1-576-232-11 FUSE (H.B.C.) 5A/250V £...
- Page 76 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK CN2908 1-564-521-11 PLUG, CONNECTOR 6P < SOCKET > J2900 1-750-264-11 JACK < COIL > L0904 1-535-143-61 LEAD, JUMPER (5.0MM) L2900 1-535-143-61 LEAD, JUMPER (5.0MM) L2901 1-535-143-61 LEAD, JUMPER (5.0MM) L2902 1-535-143-61 LEAD, JUMPER (5.0MM) L2903 1-535-143-61 LEAD, JUMPER (5.0MM) <...
- Page 77 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK 4-088-479-41 INSTRUCTION MANUAL (KV-28FX66E) MISCELLANEOUS (GERMAN/GREEK/TURKISH) £ 1-571-433-21 SWITCH, PUSH (AC POWER) 4-088-479-11 INSTRUCTION MANUAL (KV-28FX66U)(ENGLISH) £ 1-823-853-11 CORD, POWER (KV-28FX66B/28FX66E/32FX66B/ 4-088-952-21 INSTRUCTION MANUAL (KV-32FX66B) KV-32FX66E/32FX66K) (GERMAN/FRENCH/ITALIAN/DUTCH) £ 1-776-860-12 POWER CORD, FILTER (UK) (KV-28FX66U/32FX66U) 4-088-952-31 INSTRUCTION MANUAL (KV-32FX66B) (ENGLISH)
- Page 78 • User programmable Functional Check through Infrared • Fast and documented Test Mode setting of all Sony TV chassis Additional features such as Adjustments and Troubleshooting are available in chassis-dependent software modules. Please contact your local Sony Service organisation for the latest information.