® TECHNICAL GUIDE Description R-410A ® These York Affinity™ packaged cooling/heating air conditioners are designed for outdoor installation. Only utility AFFINITY™ SERIES and duct connections are required at the point of installation. The single or two stage gas-fired heaters have aluminized steel DNX, DNY, DNZ MODELS tubular heat exchangers and spark to pilot ignition.
333491-YTG-C-1108 Nomenclature Cooling/Gas Unit Product Category Voltage Code D = Single Package Air Conditioner 06 = 208/230-1-60 25 = 208/230-3-60 46 = 460-3-60 Product Generation 1 = 1st Generation Nominal Gas Heating Output Capacity 2 = 2nd Generation (Nominal Low Gas Heat Output Capacity) 3 = 3rd Generation Factory Installed Gas Heat 036 = 36,000 BTUH...
Page 4
333491-YTG-C-1108 corners with water drip edges add to the attractive operation. The unique blow-through design also assures appearance. The cabinet panels have a non-fibrous that condensate does not collect in humid areas when in insulation that will not release insulation fibers into the cooling cycle.
Units shall be manufactured by Unitary Products in an ISO enthalpy sensor. Sensor senses both the return air 9001 certified facility. YORK’s Affinity™ package units give you temperature dry bulb and humidity in conjunction with the the flexibility and choices you need in today’s market. These single enthalpy to determine the most economical mix.
Page 6
333491-YTG-C-1108 rails shall be removable, when required, to lower unit height. Coils: Filters shall be furnished and be accessible through a a. Evaporator and condenser coils shall have aluminum removable access door, sealed airtight. Units vertical discharge plate fins mechanically bonded to seamless internally and return duct configuration shall be designed to fit between enhanced copper tubes with all joints brazed.
333491-YTG-C-1108 Physical Data DNZ024-060 Single Stage Gas Heat Models Component DNZ024 DNZ030 DNZ036 DNZ042 DNZ048 DNZ060 Nominal Tonnage ARI COOLING PERFORMANCE Gross Capacity @ ARI A point (Btu) 26.1 30.4 37.3 42.6 50.3 58.2 ARI net capacity (Btu) 22.8 29.8 35.6 41.5 47.5...
Page 8
333491-YTG-C-1108 DNZ024-060 Two Stage Gas Heat Models Component DNZ024 DNZ030 DNZ036 DNZ042 DNZ048 DNZ060 Nominal Tonnage ARI COOLING PERFORMANCE Gross Capacity @ ARI A point (Btu) 26.1 30.4 37.3 42.6 50.3 58.2 ARI net capacity (Btu) 22.8 29.8 35.6 41.5 47.5 56.0 11.2...
Page 9
333491-YTG-C-1108 DNY024-060 Single Stage Gas Heat Models Component DNY024 DNY036 DNY048 DNY060 Nominal Tonnage ARI COOLING PERFORMANCE Gross Capacity @ ARI A point (Btu) 24.3 35.6 50.0 59.6 ARI net capacity (Btu) 23.8 34.6 48.0 56.5 11.1 11.0 11.0 10.6 SEER 14.0 14.0...
Page 10
333491-YTG-C-1108 DNY024-060 Two Stage Gas Heat Models Component DNY024 DNY036 DNY048 DNY060 Nominal Tonnage ARI COOLING PERFORMANCE Gross Capacity @ ARI A point (Btu) 24.3 35.6 50.0 59.6 ARI net capacity (Btu) 23.8 34.6 48.0 56.5 11.1 11.0 11.0 10.6 SEER 14.0 14.0...
Page 11
333491-YTG-C-1108 DNX024-048 Single Stage Gas Heat Models Component DNX024 DNX036 DNX048 Nominal Tonnage ARI COOLING PERFORMANCE Gross Capacity @ ARI A point (Btu) 24.6 38.4 50.0 ARI net capacity (Btu) 24.0 37.0 48.0 11.5 12.3 11.2 SEER 15.0 16.5 15.0 Nominal CFM 1275 1550...
Page 12
333491-YTG-C-1108 DNX024-048 Two Stage Gas Heat Models Component DNX024 DNX036 DNX048 Nominal Tonnage ARI COOLING PERFORMANCE Gross Capacity @ ARI A point (Btu) 24.6 38.4 50.0 ARI net capacity (Btu) 24.0 37.0 48.0 11.5 12.3 11.2 SEER 15.0 16.5 15.0 Nominal CFM 1275 1550...
Page 13
333491-YTG-C-1108 DNZ, DNY and DNX Unit Limitations Unit Limitations Size Model Unit Voltage Applied Voltage Outdoor DB Temp (Tons) Max (°F) 208/230-1-60 (2.0) 208/230-1-60 208/230-1-60 208/230-3-60 (2.5) 460-3-60 208/230-1-60 208/230-3-60 460-3-60 (3.0) 208/230-1-60 208/230-3-60 460-3-60 208/230-1-60 208/230-3-60 (3.5) 460-3-60 208/230-1-60 208/230-3-60 460-3-60 (4.0)
333491-YTG-C-1108 Indoor Blower Specifications Motor Size Model (Tons) Eff. Frame Variable (2.0) Variable (2.5) Variable (3.0) Variable Variable (3.5) Variable (4.0) Variable (5.0) Electric Heat Multipliers Voltage kW Capacity Multipliers Nominal Applied 0.75 0.92 0.92 0.92 1. Electric heaters are rated at nominal voltage. Use this table to determine the electric heat capacity for heaters applied at lower voltages.
333491-YTG-C-1108 Electrical Data DNZ024-060 Gas Heat OD Fan Supply Compressors Motors Blower Fuse Size (each) Volt (each) Motor Breaker (Tons) (Amps) Size RLA LRA MCC (Amps) 208/230-1-60 12.8 21.3 (2.0) 208/230-1-60 14.7 25.6 208/230-3-60 10.4 20.2 (2.5) 460-3-60 208/230-1-60 15.4 26.5 208/230-3-60 11.5 21.6...
Page 43
333491-YTG-C-1108 Typical DNX/DNY/DNZ024-060 Wiring Diagrams Typical DNZ024-060 Cooling Unit with Single Stage Gas Heat 208/230-1-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 44
333491-YTG-C-1108 Typical DNZ024-060 Cooling Unit with Two Stage Gas Heat 208/230-1-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 45
333491-YTG-C-1108 Typical DNX024/DNY024-048 Cooling Unit with Single Stage Gas Heat 208/230-1-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 46
333491-YTG-C-1108 Typical DNX024/DNY024-048 Cooling Unit with Two Stage Gas Heat 208/230-1-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 47
333491-YTG-C-1108 Typical DNX036-048/DNY060 Cooling Unit with Single Stage Gas Heat 208/230-1-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 48
333491-YTG-C-1108 Typical DNX036-048/DNY060 Cooling Unit with Two Stage Gas Heat 208/230-1-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 49
333491-YTG-C-1108 Typical DNZ030-060 Cooling Unit with Single Stage Gas Heat 208/230-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 50
333491-YTG-C-1108 Typical DNZ030-060 Cooling Unit with Two Stage Gas Heat 208/230-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 51
333491-YTG-C-1108 Typical DNY036-048 Cooling Unit with Single Stage Gas Heat 208/230-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 52
333491-YTG-C-1108 Typical DNY036-048 Cooling Unit with Two Stage Gas Heat 208/230-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 53
333491-YTG-C-1108 Typical DNX036-048/DNY060 Cooling Unit with Single Stage Gas Heat 208/230-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 54
333491-YTG-C-1108 Typical DNX036-048/DNY060 Cooling Unit with Two Stage Gas Heat 208/230-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 55
333491-YTG-C-1108 Typical DNZ030-060 Cooling Unit with Single Stage Gas Heat 460-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 56
333491-YTG-C-1108 Typical DNZ030-060 Cooling Unit with Two Stage Gas Heat 460-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 57
333491-YTG-C-1108 Typical DNX036-048/DNY060 Cooling Unit with Single Stage Gas Heat 460-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 58
333491-YTG-C-1108 Typical DNX036-048/DNY060 Cooling Unit with Two Stage Gas Heat 460-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 59
333491-YTG-C-1108 Typical DNY036-048 Cooling Unit with Single Stage Gas Heat 460-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
Page 60
333491-YTG-C-1108 Typical DNY036-048 Cooling Unit with Two Stage Gas Heat 460-3-60 volt Wiring Diagram Johnson Controls Unitary Products...
333491-YTG-C-1108 Weights and Dimensions DNX, DNY and DNZ Unit Weights Unit 4 Point Load Weight "D" CENTER OF FRONT GRAVITY UNIT "C" "A" 49-1/8 "B" 47-1/4 Weight (lbs.) Center of Gravity 4 Point Load Location (lbs.) Size Model (Tons) Shipping Operating 24.5 (2.0) 24.5...
Page 62
333491-YTG-C-1108 Gas Unit Dimensions VENT AIR OUTLET HOOD BLOWER SERVICE ACCESS GAS SUPPLY CONDENSER COIL COMPARTMENT PANEL 1-1/4" DIAMETER HOLE (1/2" NPTF CONNECTION) UNIT CONDENSATE CONNECTION 3/4" NPTF (TRAP RECOMMENDED) 2-3/8 HIGH VOLTAGE CONN. 1-3/8" DIA. 3-3/4 KNOCKOUT REFRIGERANT CONNECTIONS 2-1/2 COMBUSTION AIR GAS SUPPLY...
Page 63
333491-YTG-C-1108 Unit Dimensions Front and Bottom 19-1/4 11-7/8 HIGH VOLTAGE 8-7/8 CONN. 1-3/32" FRONT DIA. KNOCKOUT GAS SUPPLY 1-5/8" DIA. KNOCKOUT (1/2" NPTF CONNECTION) LOW VOLTAGE CONN. 7/8" DIA. LOW VOLTAGE KNOCKOUT CONN. 7/8" DIA. KNOCKOUT HIGH VOLTAGE CONN. 1-31/32" x 7/8" KNOCKOUT 4-5/8 CONDENSATE...
Page 64
333491-YTG-C-1108 Unit Typical Duct Applications ROOF CURB INSTALLATION REAR DUCT ROOF CURB INSTALLATION BOTTOM DUCT SLAB ON GROUND INSTALLATION Unit Typical Slab on Ground Installation (Gas Model Shown) TO POWER SUPPLY FIELD SUPPLIED CONTROL WIRING TO DISCONNECT SWITCH INDOOR THERMOSTAT LOCATED TO REAR OF UNIT RETURN AIR DUCT...
Page 65
333491-YTG-C-1108 Unit Typical Roof Curb Installation (Gas Model Shown) MANUAL GAS SHUT-OFF VALVE FIELD SUPPLIED DISCONNECT SWITCH MOUNTED ON UNIT TO POWER SUPPLY TO GAS SUPPLY LINE CONTROL WIRING TO INDOOR THERMOSTAT RETURN AIR DUCT SUPPLY AIR DUCT Unit Accessory Dimensions Roof Curb RECOMMENDED DUCT SIZE...
Page 66
333491-YTG-C-1108 Roof Curb Cross Section 1" 3/4" x 1" WIDE GASKETING FOR CURB FRAME AND ALL DUCT SUPPORT SURFACES UNIT BASE UNIT BASE RAIL WOOD NAILER COUNTERFLASHING 8" MIN. ABOVE FINISHED ROOF 14" CANT STRIP CURB FRAME INSULATION AND ROOFING MATERIAL INSULATION ROOF DECK AND ROOFING MATERIAL Johnson Controls Unitary Products...
Page 67
333491-YTG-C-1108 Johnson Controls Unitary Products...