Drain Hose Installation - Samsung AFPCC052CA0 Installation Manual
Cooling only system air conditioner
Hide thumbs
Also See for AFPCC052CA0:
- Owner's instructions manual (36 pages) ,
- Service manual (49 pages)
Table of Contents
Advertisement
Drain Hose Installation
Care must be taken when installing the drain hose for the indoor unit
to ensure that any condensate water is correctly drained outside.
1
Insert the flexible hose to the drain hose port.
N N
o o
t t
e e
N N
o o
t t
e e
Attach the drain hose to the drain hose port with an adhesive for
PVC and tape to prevent water leaks, then secure the hose with
a band etc..(The band is not supplied with the air conditioner.)
2
Install the drain hose so that its length can be as short as possible.
Internal diameter of the drain hose should be the same or slightly bigger
than the external diameter of the drain hose port.
Inner diameter of the drain hose
32mm/
N N
N N
o o
o o
t t
t t
e e
e e
Give a slightly slant to the drain hose for proper drainage of
condensate.
Secure the drain hose with an adhesive for PVC and tape
not to be separated from the unit.
3
Wrap the drain hose with the insulation drain as shown in figure and secure it.
C C
A A
U U
T T
I I
O O
N N
C C
A A
U U
T T
I I
O O
N N
Check that the indoor unit is level with the ceiling by using the leveler.
Install air ventilation to drain condensate water
smoothly.
Air ventilation
Do not give the hose and upward gradient
after the connection port.
This will cause water to flow backwards when
the unit is stopped, resulting in water leaks.
Upward gradient
1
"(Outer diameter)
1
4
If it is necessary to increase the height of the drain hose
somewhat, the portion directly after 30cm/
raised higher than 55cm/
Ceiling
Do not apply force to the piping on the unit side when
connecting the drain hose. The hose should not be
allowed to hang loose from its connection to the unit.
Fasten the hose to a wall, frame or other support as
close to the unit as possible.
Ceiling
Indoor
Unit
Adhesives
Must fit tightly against
body without any gap.
5
21
", there can be water leaks.
8
3
300mm/
11
" or less
4
Band joint
Flexible hose
Ceiling
Support pieces
1~1.5m/3~5ft.
1/100 or more
Drain hose
port
Insulation drain sub
Band(Not supplied)
Insulation drain hose
Insulation cover drain
C C
C C
A A
A A
U U
U U
T T
T T
I I
I I
O O
O O
N N
N N
No gap
3
11
". If it is
4
Ceiling
13
E-
Advertisement
Chapters
Table of Contents
Troubleshooting
