Page 1
Series I Reach-Ins with Aluminum Interior Service, Installation and Care Manual Please read this manual completely before attempting to install or operate this equipment! Notify carrier of damage! Inspect all components immediately. See page 3. June 2010...
Page 2
McCall Series I Reach-In Manual Important Warning And Safety Information WARNING Read this manual thoroughly before operating, installing, or performing maintenance on the equipment. FAILURE TO FOLLOW INSTRUCTIONS IN THIS MANUAL CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH. DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.
McCall Introduction McCall reach-in models have an aluminum interior and exterior Dual Temperature Refrigeration/Freezer with a stainless steel front and shroud. Door gaskets are magnetic Each compartment has its own separate refrigeration system. and mount to the door, snapping in place and are removable Condensing units are located on top of the cabinet, outside the without tools.
McCall Series I Reach-In Manual Specifications Reach-In Refrigerators - Hinged Doors - Standard Width & Depth Storage Shelf No. Of R-404A Shipping NEMA Energy Model Voltage Amps Capacity Capacity H.P. BTU/HR Shelves Charge Oz. Weight Plug (KWH) MCCR1-S,SH,G,GH 24.96 12.81 2092 12.5...
Page 7
McCall Specifications, continued Pass-Thru Refrigerators - Hinged Doors - Standard Width Storage Shelf No. Of R-404A Shipping NEMA Energy Model Voltage Amps Capacity Capacity H.P. BTU/HR Shelves Charge Oz. Weight Plug (KWH) MCCRPT1-S,SH 26.64 12.81 2092 12.5 455lbs/ 5-15P 3.14...
McCall Series I Reach-In Manual Installation Location Cabinets represented in this manual are intended for indoor use only. Be sure the location chosen has a floor strong enough to support the total weight of the cabinet, 1000 pounds (450 kg) per door section.
McCall Installation, continued Electrical Connection Refer to the amperage data list in the SPECIFICATIONS or the serial tag data and your local code or the National Electrical Code to be McCall sure the unit is connected to the proper power source.
Whenever the display has on the door opening, flip the energy saver switch to the ON or “-” an error read-out, McCall Service should be contacted. position, (red portion of the rocker switch will be visible).
McCall Heated Cabinet Operation The Heated units have a POWER ON/OFF switch located behind the The unit surface is very hot! Avoid direct contact flip up shroud at the front top of the unit for controlling power to with skin; use appropriate protective apparel, such the unit and an electronic thermostat for setting the temperature.
McCall Series I Reach-In Manual Maintenance Door Gasket Maintenance NEVER USE STEEL PADS, WIRE BRUSHES OR SCRAPERS! Door gaskets require regular cleaning to prevent mold and mildew build up and also to retain the elasticity of the gasket. Cleaning solutions need to be alkaline based or non-chloride Gasket cleaning can be done with the use of warm soapy water.
McCall Maintenance, continued Do not place hot pans on/against the grey ABS door liner. Do not throw items into the storage area. Failure to follow these recommendations could result in damage to the interior of the cabinet or to the blower coil.
Page 18
McCall Series I Reach-In Manual Freezer Wiring Diagrams MCCF2 - Solid Doors MCCF2, MCCF3 - Glass Doors PDF created with pdfFactory trial version www.pdffactory.com...
McCall Series I Reach-In Manual Replacement Parts, continued MCCF3 - Glass Doors All Heated Models Part Number Description Part Number Description 3517390 Blade, Fan, 5.56, CW, Lexan 2162516 Blower, Hi-Temp, Reach-In 3516204A Breaker, Vacuum 2194377 Control Knob 3516305 Coil, Evap, R-404A...
McCall Standard Labor Guidelines To Repair Or Replace Parts On McCall Equipment Advice and recommendations given by McCall Service Technicians do not constitute or guarantee any special coverage. • A maximum of 1-hour is allowed to diagnose a defective component.
Unit or any exhaust system. is subject to the following limitations: A maximum of 1-hour is allowed to McCall shall not be liable in any manner for any default or delay in diagnose a defective component; A maximum of 1-hour is allowed for performance hereunder caused by or resulting from any contingency retrieval of parts not in stock;...
General Conditions In addition to the Standard One Year Warranty on the Motor- McCall shall not be liable in any manner for any default or Compressor contained in the above listed McCall product (the delay in performance hereunder caused by or resulting from “Unit”), McCall also agrees to repair, or exchange with similar...