Advertisement
if thegrill fallsto light propeNy:
1. Turngasoffatsource andturnthecontrol knobto
OFF.Waitatleast f iveminutes f orgastoclear,
thenretry.
2. Checkgassupplyandconnections.
3. Repeat l ightingprocedure. I f yourgrill stillfails
to operateproperly, t urn thegasoff atsource,
turnthe control k nobsto OFF,thencheckthe
following:
,, Misaiignment
ofburner tubes over o dfices
Correction: Reposition burner t ubes o verorifices.
" Obstruction ingasline
Correction: Remove f uelline from grill.Donot
smoke! Open gassupply f oronesecond toclear
anyobstruction fromfuelline. C lose offgassupply
atsource andreconnect fuellinetogrill.
" Plugged o rifice
Correction: R emove b urners f romgrill b ypulling
cotter p in(beneath b urner) u sing a screwdriver or
pliers. C arefully l ifteachburner u pandaway from
gasvalve orifice. R emove t heorifice fromgas
valveandgently clearanyobstruction withafine
wire.Thenreinstall a[[orifices, burners, cotter
pinsandcooking components.
ifanobstruction i ssuspected i ngasvalves or
gasvalve bracket, please call f orrepair s ervice at
1-800-4-MY-HOME.
" Misalignment ofignitor o nburner
Correction: C heck forproper p osition ofthe
electrode tipasshown in Figure13.The gap
between t heSpark Electrode T ipandSpark
Receiver should beapproximately 3/16". A djust i f
necessary. Withthegassupply closed andall
control knobs settoOFFpresstheelectric
ignitor c apandcheck forthepresence o fa spark
attheelectrode.
', Disconnected ignition Wires
Correction: I nspect thebnitorjunction boxfound
behind t heControl Panel. Connect loose ignitor
wires tojunction boxandtrytolightthegrill.
,, Weak AAbattery
Correction:Unscrew theignitor C apand
replace thebattery.
.
if the gdH still does not light you may need
to purge air from the gas line or reset the
regulator excess gas flow device.
Note: This
procedure should be done every time a new
LP gas tank is connected
to your grill.
To purge
air from
your
gas
line and/or
reset the regulator
excess gas flow device:
" Turn the control knobs to the OFF position.
" Turn off the gas at the tank valve.
" Disconnect
regulator
from LP gas tank.
" Let unit stand for 5 minutes.
" Reconnect
regulator
to the LP gas tank.
" Turn the tank valve on slowly until 1/4 to
1/2 open.
" Open the Grill Lid or Side Burner Lid.
" Set control knobs to OFF and open the LP
gas tank valve.
" To light grill push and turn the LEFT
control knob to HIGH. To light the Side
Burner turn its control knob to HIGH.
5. if all checks or corrections have been made and
you still have questions about operating your gas
grill, ca[[ the Manufacturer's Customer Service
Help[ine 8am z 8pm CST, Monday through Friday at
1-888-317W642.
Should
a "FLASH-BACK"
fire occur
in/or
around
the burner
tubes,
follow
the
instructions
below.
Failure to comply
with
these
instructions could
result
in a fire or
expbsion
that could
cause serious
bodily
injury,
death,
or property
damage.
, Shut off gas supply to the gas grill.
, Turn the control knobs to OFF position.
, Put out any flame with a fire extinguisher.
, Open grill Hd.
, Once the grill has cooled down, dean
the burner tubes and burners according
to the cleaning instructions
found on
page 19 in this manual
17
Advertisement
