Page 1
SBR-USER Rev B User’s Information Manual Models: 45,000 - 260,000 Btu/hr WARNING If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. This appliance MUST NOT be installed in any location where gasoline or flammable vapors are likely to be present.
User’s Information Manual Please read before proceeding Improper installation, adjustment, alteration, This is a gas appliance and should be WARNING NOTICE service or maintenance can result in severe installed by a licensed electrician and/or certified gas supplier. Service must be personal injury, death, or substantial property damage.
Page 4
User’s Information Manual Please read before proceeding To minimize the possibility of serious WARNING personal injury, fire, or damage to your appliance, never violate the following safety rules: 1. Boilers are heat producing appliances. To avoid damage or injury, do not store materials against the appliance or the vent-air intake system.
User’s Information Manual Maintenance schedule Service technician Owner maintenance (see the Solution Installation and Service (see pages 6 - 7 for detailed instructions) Manual) General: • Check appliance area • Address reported problems Daily • Check pressure/temperature • Inspect interior; clean and vacuum if gauge necessary •...
User’s Information Manual Maintenance schedule Maintenance procedures Combustible/flammable materials -- Do not store combustible materials, gasoline or any other flammable Appliance must be serviced and maintained vapors or liquids near the appliance. Remove immediately if found. Follow the service and maintenance WARNING Air contaminants -- Products containing chlorine or procedures given throughout this manual...
User’s Information Manual Maintenance schedule (continued) Check appliance piping (gas and water) Shut appliance down (unless boiler is used for Domestic Water) Access appliance perform leak inspection per steps 1 through 7 of the Operating Follow “To Turn Off Gas to Appliance” on page 9 of this Instructions on page 8.
User’s Information Manual Operating instructions Lighting Instructions for Spark Ignition Operating Instructions Pilot Models STOP! Read the safety information first. FOR YOUR SAFETY READ BEFORE Remove the control panel door. OPERATING Set the thermostat to the lowest setting (OFF). WARNING If you do not follow these instructions Turn off all electrical power to the appliance.
User’s Information Manual Operating instructions (continued) Intermittent Pilot Spark Ignition To Turn Off Gas to Appliance System Set the thermostat to the OFF position. The ignition module is not repairable. Turn off all electric power to the appliance if service is to WARNING Any mod i fi ca tion or repairs will invalidate be performed.
Revision Notes: Revision A (ECO C03746) initial release. Revision B (ECO C12077) reflects the update of ignition timing information on page 9. SBR-USER Rev B 01/13...