Polaris ATP 330 4x4 2005 Owner's Manual page 79

MAINTENANCE AND LUBRICATION
Periodic Maintenance Chart
Item
Fuel system
J
E
Fuel filter
J
E
Radiator
"
(if applicable)
Cooling hoses
"
(if applicable)
Engine mounts
"
Exhaust muffler/
pipe
Spark plug
J
E
Ignition Timing
J
E
Wiring
"
Clutches (drive
J
and driven)
Front wheel
J
bearings
Brake fluid
J
Spark arrestor
E Idle speed
Toe adjustment
J
Auxiliary brake
"
J
Headlight aim
Perform these procedures more often for vehicles subjected to severe use.
"
E Emission Control System Service (California)
Have an authorized Polaris dealer perform these services.
J
76
Maintenance Interval
(whichever comes first)
Hours Calendar
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
100 H 12 M
200 H 24 M
300 H 36 M
- -
- -
- -
- -
Miles
(Km)
620 (1000) Check for leaks at tank cap,
lines, fuel valve, filter, pump,
carburetor; replace lines
every two years
620 (1000) Replace yearly
620 (1000) Inspect; clean external
surfaces
620 (1000) Inspect for leaks
620 (1000) Inspect
620 (1000) Inspect
620 (1000) Inspect; replace as needed
620 (1000) Inspect
620 (1000) Inspect for wear, routing,
security; apply dielectric
grease to connectors
subjected to water, mud, etc.
620 (1000) Inspect; clean; replace worn
parts
1000 (1600) Inspect; replace as needed
1240 (2000) Change every two years
1860 (3000) Clean out
Adjust as needed
Inspect periodically; adjust
when parts are replaced
Inspect daily; adjust as
needed
Adjust as needed
Remarks