Samsung HCM653W Service Manual page 91

Electrical Parts List
7-2 HCM653WX/XAC
Loc. No. Code No. Description ; Specification
ASSY CHASSIS
1 * AA91-04375A ASSY CHASSIS;HCM653WX/XAC,P54A,
..2 PM+HC 6003-001023 SCREW-TAPTITE;RWH,+,B,M3,L10,ZPC(YEL),SW
..2 PP+HC 6003-001023 SCREW-TAPTITE;RWH,+,B,M3,L10,ZPC(YEL),SW
..2 PS+HC 6003-001023 SCREW-TAPTITE;RWH,+,B,M3,L10,ZPC(YEL),SW
..2 AA95-01847E ASSY SUB-PCB,SUB AMP;SVP-47W3HR,P54A,KOR
...3 CNSW60 AA39-20020D LEAD CONNECTOR-ASSY;,5P,67096-005,S,600,
...3 CNSW60 AA39-20608A LEAD CONNECTOR-ASSY;,3(2)P,SMP250-02,670
...3 CS603 2401-000737 C-AL;2200uF,20%,50V,GP,TP,18x35.5,7
...3 ICS601 AA96-50367A ASSY H/S;-,-,AA62-30181D,TDA7265,-
....4 0205-000129 GREASE-SILICON;SC102,JAPAN
....4 1201-001026 IC-POWER AMP;7265,ZIP,11P,19.6MIL,DUAL,1
....4 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
....4 AA62-30181D HEAT SINK-ES;-,AL6063 EXTR.,2,WHT,70MM,-
...3 AA97-05521A ASSY AUTO-SUB;SVP-47W3HR,P54A,KOREA
....4 CNS602 3711-002644 CONNECTOR-HEADER;BOX,5P,1R,2.5mm,STRAIGH
....4 CNS603 3711-002642 CONNECTOR-HEADER;BOX,3P,1R,2.5mm,STRAIGH
....4 CNS604 3711-002643 CONNECTOR-HEADER;BOX,4P,1R,2.5mm,STRAIGH
....4 CS602 2401-000192 C-AL;1000uF,20%,50V,GP,TP,16x25,7.5
....4 CS605 2401-000832 C-AL;220uF,20%,25V,GP,TP,8x11.5,5
....4 CS606 2401-001914 C-AL;1uF,20%,50V,BP,TP,5x11,5
....4 CS608 2401-000027 C-AL;4.7uF,20%,50V,GP,TP,5x11,5
....4 CS611 2305-000665 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m
....4 CS612 2305-000665 C-FILM,MPEF;100nF,5%,63V,TP,7.5x4.0x5.0m
....4 CS614 2301-000192 C-FILM,PEF;1nF,5%,50V,TP,5.3x10mm,5mm
....4 DS601 0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41,T
....4 EL01 AA60-40011A EYELET;ID2.0,OD2.8,-,-,BST,-
....4 EL02 AA60-40011A EYELET;ID2.0,OD2.8,-,-,BST,-
....4 EL03 AA60-40011A EYELET;ID2.0,OD2.8,-,-,BST,-
....4 EL04 AA60-40011A EYELET;ID2.0,OD2.8,-,-,BST,-
....4 LS601 2901-000297 FILTER-EMI ON BOARD;-,3A,-,-,3.5x5,TP,-
....4 PCB AA41-00459A PCB-SUB AMP;SP43T6HF,FR-1,1L,A,1.6T,245X
....4 QS602 0501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,T
....4 RS603 2001-001146 R-CARBON(S);4.7OHM,5%,1/2W,AA,TP,2.4X6.4
....4 RS605 2001-001108 R-CARBON(S);22KOHM,5%,1/2W,AA,TP,2.4X6.4
....4 RS606 2001-001093 R-CARBON(S);2.2KOHM,5%,1/2W,AA,TP,2.4X6.
....4 RS607 2001-001093 R-CARBON(S);2.2KOHM,5%,1/2W,AA,TP,2.4X6.
....4 RS611 2001-001088 R-CARBON(S);1KOHM,5%,1/2W,AA,TP,2.4X6.4M
....4 RS612 2001-001050 R-CARBON(S);1.5KOHM,5%,1/2W,AA,TP,2.4X6.
....4 RS614 2001-000723 R-CARBON;4.3KOHM,5%,1/8W,AA,TP,1.8X3.2MM
....4 RS616 2001-000660 R-CARBON;33KOHM,5%,1/8W,AA,TP,1.8X3.2MM
....4 RS618 2001-000020 R-CARBON(S);22OHM,5%,1/2W,AA,TP,2.4X6.4M
....4 RS619 2001-001093 R-CARBON(S);2.2KOHM,5%,1/2W,AA,TP,2.4X6.
....4 RS621 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
....4 RS622 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
....4 RS623 2001-000066 R-CARBON(S);10KOHM,5%,1/2W,AA,TP,2.4X6.4
....4 RS626 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
...3 3301-001201 CORE-FERRITE;AE,21x11x32mm,1500,280G
..2 AA95-01846D ASSY SUB-PCB,SUB;PCL545R,P54A,AA95-00705
...3 C432 2306-000267 C-FILM,MPPF;8.2nF,5%,1.6KV,TP,28.5x18.5x
...3 C438 2306-000267 C-FILM,MPPF;8.2nF,5%,1.6KV,TP,28.5x18.5x
...3 C491 2306-000322 C-FILM,MPPF;12nF,5%,1.6KV,TP,29x20.5x13,
...3 C876 2401-000787 C-AL;220uF,20%,160V,GP,TP,16x31.5mm
...3 CN202 AA39-00116A LEAD CONNECTOR-ASSY;,12P,YBNH250-12,3515
...3 CN801 AA39-00180A LEAD CONNECTOR-ASSY;,14P,YBNH250-14,3515
...3 CN802 3711-003974 CONNECTOR-HEADER;BOX,12P,1R,2.5mm,STRAIG
...3 CN803 3711-003974 CONNECTOR-HEADER;BOX,12P,1R,2.5mm,STRAIG
...3 CNW801 AA39-20061G LEAD CONNECTOR-ASSY;,3P,YFH800-03,S,100M
...3 CNZ02 AA39-00115A LEAD CONNECTOR-ASSY;,10P,YBNH250-10,3515
...3 CR430S 2301-001343 C-FILM,MPPF;3.9nF,5%,2kV,TP,29x9.5x16mm,
...3 CR431S 2301-001343 C-FILM,MPPF;3.9nF,5%,2kV,TP,29x9.5x16mm,
...3 CR436S 2306-000235 C-FILM,MPPF;560nF,5%,400V,TP,26*22.5*14,
...3 CR471S 2301-001091 C-FILM,MPPF;470nF,5%,400V,TP,26x21.5x14.
...3 CR473S 2306-000322 C-FILM,MPPF;12nF,5%,1.6KV,TP,29x20.5x13,
...3 CR474S 2306-000326 C-FILM,MPPF;4.7nF,5%,1.6KV,TP,28.5x16x9m
...3 CS803 2401-003370 C-AL;47uF,20%,450V,GP,BK,16X35.5,7.
...3 CY811S 2201-000446 C-CERAMIC,DISC;3.3nF,20%,400V,Y5U,TP,15x
...3 CY812S 2201-000446 C-CERAMIC,DISC;3.3nF,20%,400V,Y5U,TP,15x
...3 D464 0402-000562 DIODE-RECTIFIER;UF5406,600V,3A,DO-201AD,
...3 D811S 0402-000102 DIODE-BRIDGE;D2SB60,600V,1.5A,-
...3 IC301 AA96-50406A ASSY H/S;-,-,AA62-30180K,LA7845,-
7-22
Remark Loc. No. Code No.
....4 0205-000129 GREASE-SILICON;SC102,JAPAN
....4 1204-000517 IC-VERTICAL DEF.;LA7845,SIP,7P,-,PLASTIC
....4 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
S.N.A
....4 AA62-30180K HEAT SINK-ES;-,A6063 EXTR,-,WHT,50/13,-,
...3 IC421 1203-000165 IC-POSI.ADJUST REG.;78R12,TO-220,4P,-,PL
S.N.A
...3 IC430 1203-000162 IC-POSI.ADJUST REG.;317,TO-220,3P,-,PLAS
S.N.A
...3 IC431 1201-000191 IC-OP AMP;4558,DIP,8P,300MIL,DUAL,20V/mV
S.N.A
...3 IC471 1203-000610 IC-PWM CONTROLLER;494,DIP,16P,300MIL,PLA
...3 ICS801 AA13-00024A IC HYBRID;-,TNY253P,-,8PIN,-,-
...3 ICS807 AA96-00111P ASSY H/S;-,MAIN,AA62-30013L,KA278RA05,FA
....4 1203-001978 IC-VOLTAGE REGULATOR;KA278RA05,TO-220F,4
....4 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
S.N.A
....4 AA62-30013L HEAT SINK-ES;-,-,-,-,44/22,-,WHT,-,-,-,-
S.N.A
...3 ICZ103 AA96-00891A ASSY H/S;-,CONVERGENCE,AA62-30173L,STK39
....4 0205-000129 GREASE-SILICON;SC102,JAPAN
S.N.A
....4 1201-001225 IC-VIDEO AMP;392,SIP,22P,-,TRIPLE,-,PLAS
S.N.A
....4 6003-001021 SCREW-TAPTITE;RH,+,B,M3,L15,ZPC(YEL),SWR
S.N.A
....4 AA62-30173L HEAT SINK;PJT,A6063,T2.0,H130,CG MODULE
...3 ICZ104 AA96-00891A ASSY H/S;-,CONVERGENCE,AA62-30173L,STK39
...3 L432 AA27-00095A COIL HORIZ. WIDTH;-,600uH,YL9N 15x27.5 C
...3 L434 AA27-00221A COIL HORIZ. WIDTH;600UH,600UH,SB5S OS6X2
...3 L435 AA27-10001C COIL CHOKE;-,100uH,K,-,5.0A,ST,700UH-K(R
...3 L854 AA27-10001C COIL CHOKE;-,100uH,K,-,5.0A,ST,700UH-K(R
...3 L860 AA27-10001C COIL CHOKE;-,100uH,K,-,5.0A,ST,700UH-K(R
...3 L862 AA27-10001C COIL CHOKE;-,100uH,K,-,5.0A,ST,700UH-K(R
...3 L872 AA27-10001C COIL CHOKE;-,100uH,K,-,5.0A,ST,700UH-K(R
...3 L874 AA27-10002L COIL CHOKE;-,24uH,K,-,2A,-,24UH-K,10x10m
...3 LC431S AA27-30003M COIL LINEARITY;-,5uH,OWA14x15,USRC0.1x60
...3 PC811S 0604-001032 PHOTO-COUPLER;TR,170-260%,300mW,DIP-4,ST
S.N.A
...3 Q353 0502-000442 TR-POWER;2SC4636RB,NPN,2W,TO-220,ST,10-
S.N.A
...3 Q431 AA96-00033E ASSY H/S;-,H-OUT,AA62-30173C,2SC5446, FM
S.N.A
....4 AA62-30173C HEAT SINK-ES;-,-,T1.0,WHITE,SCREW-HOLE(2
S.N.A
....4 AA60-30001A WASHER-PLATE;M3,ID3.5,15X8.5,T1.0,-,SBHG
....4 AA02-00007A SUB ETC-MICA;DPM-04,MICA,22x29x0.15mm
S.N.A
....4 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
....4 0502-001175 TR-POWER;2SC5446,NPN,200000mW,TO-3PL,BK,
....4 0402-001296 DIODE-RECTIFIER;FMP-3FU,1.5KV,5A,TO-3PF,
....4 0205-000129 GREASE-SILICON;SC102,JAPAN
...3 Q433 AA96-50407A ASSY H/S;-,-,AA62-30154G,KSD73Y,-
....4 0205-000129 GREASE-SILICON;SC102,JAPAN
....4 0502-000298 TR-POWER;KSD73,NPN,30000mW,TO-220,TP,120
....4 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
....4 AA62-30154G HEAT SINK-ES;-,A6063 EXTR,-,WHT,50/16,-,
...3 Q441 AA96-50383F ASSY H/S;-,-,AA62-30180D,2SD921,-
....4 0205-000129 GREASE-SILICON;SC102,JAPAN
....4 0502-001104 TR-POWER;2SD921,NPN,80W,TO-3P,BK,700-
....4 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
....4 AA62-30180D HEAT SINK-ES;-,A6063 EXTR.,2,WHT,50mm,-,
...3 Q473 AA96-00037A ASSY H/S;-,-,AA62-30181N,2SC4125, IRFS64
....4 AA62-30181N HEAT SINK-ES;-,-,T1.0,WHITE,SCREW-HOLE(2
....4 AA60-30001A WASHER-PLATE;M3,ID3.5,15X8.5,T1.0,-,SBHG
....4 6003-000333 SCREW-TAPTITE;RH,+,2S,M3,L10,ZPC(YEL),SW
....4 0505-001202 FET-SILICON;IRFS640A,N,200V,9.8A,0.18ohm
....4 0502-001100 TR-POWER;2SC4125,NPN,70W,TO-3PML,BK,8-
....4 0205-000129 GREASE-SILICON;SC102,JAPAN
...3 RL811S 3501-001053 RELAY-POWER;5Vdc,530mW,10A,1FormA,15mS,5
...3 RL812S 3501-001040 RELAY-POWER;12VDC,500mW,10A,1FormA,15mS,
...3 T431 AA26-50001U TRANS-HORIZ.DRIVE;-,-,-,28mH,-,-,105uH,-
...3 T432 AA26-00012A TRANS-DUMMY;-,-,-,-,-,-,-,-,-,-,-,-,EER4
...3 T433 AA26-00011A TRANS-DUMMY;-,-,-,-,-,-,-,-,-,-,-,-,EE28
...3 T444S AA26-00100A TRANS FBT;FFA97513L,CT29A7DR,0.3mH,-,-,-
...3 T461 AA26-50001V TRANS-HORIZ.DRIVE;-,-,-,6.0mH,-,-,113uH,
...3 T481 AA26-00091A TRANS-HV-STORAGE;4mH,-,14P,830uH,180V,10
...3 TS811S AA26-00055B TRANS SWITCHING;,HLK436W,AC80V,AC80~280V
...3 3301-001201 CORE-FERRITE;AE,21x11x32mm,1500,280G
...3 AA97-05175A ASSY AUTO-SUB;PCL545R,P54A
....4 C301 2305-000427 C-FILM,MPEF;47nF,5%,100V,TP,7.5x12.5x3.5
....4 C302 2201-000292 C-CERAMIC,DISC;1nF,10%,50V,Y5P,TP,5x3.5,
....4 C303 2305-000427 C-FILM,MPEF;47nF,5%,100V,TP,7.5x12.5x3.5
....4 C304 2201-000292 C-CERAMIC,DISC;1nF,10%,50V,Y5P,TP,5x3.5,
....4 C305 2201-002022 C-CERAMIC,DISC;0.005nF,0.25pF,500V,NP0,T
....4 C307 2401-000365 C-AL;100uF,20%,50V,WT,TP,10x12.5mm,
....4 C308 2401-000365 C-AL;100uF,20%,50V,WT,TP,10x12.5mm,
S.N.A
Description ; Specification
Samsung Electronics
Remark
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A
S.N.A