Main Section - Sony DCR-SX73E Service Manual

2-1-3. MAIN SECTION

#11
109
8-2
8
108
B
C
7
106
105
(Note 2)
#3
CX110/CX110E/CX115E/
104
CX116E/CX150/CX150E
A
/CX155E/CX170
103
101
7-2
#3
102
#3
Ref. No. Part No. Description
* 101 4-172-026-01 HEAT SINK VC
102 4-177-120-01 SHEET (VC), SHIELD
* 103 4-165-732-01 LABEL, FUSE REPLACEMENT CAUTION
104 4-174-979-01 SHEET (AN), RADIATION (CX110/CX110E/CX115E/
CX116E/CX150/CX150E/CX155E/CX170)
* 105 4-172-028-01 SHEET VC, RADIATION
106 A-1757-118-A VC-590 BOARD, COMPLETE (SERVICE)
(CX110/CX110E/CX150/CX150E/CX170)(Note 2)
106 A-1757-119-A VC-590 BOARD, COMPLETE (SERVICE)
(SX83/SX83E)(Note 2)
106 A-1757-122-A VC-590 BOARD, COMPLETE (SERVICE)
(CX115E/CX116E/CX155E)(Note 2)
106 A-1757-123-A VC-590 BOARD, COMPLETE (SERVICE)
(SX73E)(Note 2)
107 1-880-345-11 FP-1185 FLEXIBLE BOARD
DCR-SX73E/SX83/SX83E, HDR-CX110/CX110E/CX115E/CX116E/CX150/CX150E/CX155E/CX170_L2
112
(including CP002 (CMOS imager))
(Note 1)
111
#172
110
115
118
113
7-1
(Note 3)
114
116
8-1
107
105
#3
117 B
#3
C
A
Ref. No. Part No. Description
108 8-848-865-01 DEVICE, LENS LSV-1181A
* 109 4-172-024-01 MAIN FRAME
110 1-856-061-21 OPTICAL FILTERBLOCK (OFB-06-12)
111 4-163-258-01 RUBBER (1181), SEAL
112 A-1756-539-A CM-114 BOARD, COMPLETE (including CP002
(CMOS imager)) (Note 1)
113 1-880-344-11 FP-1184 FLEXIBLE BOARD
114 4-172-039-01 SHEET (CM), SHIELD
115 4-172-029-01 SHEET CM, RADIATION (Note 3)
* 116 4-172-025-01 HEAT SINK LE
117 4-182-848-01 INSULATING SHEET (LE)
118 4-177-119-01 SHEET (MF), SHIELD
#2 2-635-562-31 SCREW (M1.7)
#3 2-660-401-01 SCREW (M1.7), NEW TRU-STAR, P2
#11 3-078-890-11 SCREW, TAPPING
#172 2-178-410-01 TITE (UB TITE) 1.4
DISASSEMBLY
1. Remove to numerical order (
#3 X 1 → #2 X 1
6
Top View
Radiation Sheet CM (7-1) → #3 X 2 → Heat Sink VC (7-2) → #3 X 1
7
Bottom View
6
LCD Section
#3
(See page 2-6)
#3 X 1 → Heat Sink LE (8-1) → #11 X 2 → Main Frame (8-2)
8
Bottom View
#3
Screw
#2: M1.7 X 4.0
#2 (Black)
2-635-562-31
1.7
4.0
Note
Note 1: Be sure to read "Precautions for Replacement of Imager"
on page 6-1 when changing the imager.
Note 2: When replacing the VC-590 board, start the Adjust
Manual in the Adjust Station and refer to the "INTERNAL
MEMORY ADJUSTMENTS".
Note 3: The Radiation Sheet CM when peeling off once, so that
it cannot be reused.
2-5
to ) in the left figure.
6 8
Right View
#3
#2
Left View
#11
#3: M1.7 X 2.5 #11: M1.7 X 4.0 (Tapping)
(Red) (Silver)
2-660-401-01 3-078-890-11
1.7 1.7
2.5 4.0
Note 1: イメージャの交換時は6-1ページの"イメージャ交換時の
注意"を必ずお読みください。
Note 2: V C - 5 9 0 基 板 を 交 換 の 際 は ， A d j u s t S t a t i o n か ら
Adjust Manualを起動させて「INTERNAL MEMORY
ADJUSTMENTS」を参照してください。
Note 3: Radiation Sheet CMは一度剥がすと粘着力が弱くなるた
め、再利用はしないでください。
#172: M1.4 X 4.0 (Tapping)
(Black)
2-178-410-01
1.4
4.0