Bodywork Finish; Interior And Chrome Cleaning - Fiat 500L Workshop Manual

12:1

Bodywork finish

12:2

Interior and chrome cleaning

12:3
Door trim and accessories
12:4
Door handles and locks
12:5
Removing regulator and door glass
12:6
Removing windshield glass
12:7
Removing rear side windows
12:1 Bodywork finish
Large scale repairs to body panels are best left to
expert panel beaters. Even small dents can be tricky, as too
much hammering will stretch the metal and make things
worse instead of better. Filling minor dents and scratches
is probably the best method of restoring the surface. The
touching up of paintwork is well within the powers of
most car owners, particularly as self-spraying cans of
paint in the correct colours are now readily available. It
must be remembered, however, that paint changes colour
with age and it is better to spray a whole wing rather than
try to touch up a small area.
Before spraying it is essential to remove all traces of
wax polish with white spirit. More drastic treatment is
required if silicone polishes have been applied. Use a
primer surfacer or paste stopper according to the amount
of filling required, and when it is dry, rub it down with
400 grade Wet or Dry paper until the surface is smooth
and flush with the surrounding area. Spend time on
getting the best finish as this will control the final effect.
Apply the retouching paint, keeping it wet in the centre
and light and dry round the edges. After a few hours of
drying, use a cutting compound to remove the dry spray
and finish with liquid polish.
F500
CHAPTER 12
THE BODYWORK
12:8
12:9
12:10
12:11
12:12
12:13
12:14
12:2 Interior and chrome cleaning
compartment lining must be regularly cleaned to ensure
long life and preserve its attractive appearance. Any dust
or dirt that is blown into the car will settle on the uphol-
stery and will tend to wear the cloth causing an unsightly
appearance. It is recommended that the dust is wiped off
using either a vacuum cleaner or a stiff brush. To remove
ordinary soiling of the upholstery cloth proceed as
follows:
1 Using luke warm water and a neutral soap and a piece
2 Repeat the operation using a clean damp cloth and
3 Allow the upholstery cloth to dry, use a stiff brush
soon as possible otherwise as time passes they will
become more difficult, if not impossible to remove.
Certain stains require specific solvents and the instruc-
tions must be strictly adhered to.
Removing rear window glass
Front compartment lid
Engine compartment lid
Folding top
Sun roof
Seats
Interior heater
The cloth upholstery of the seating and the rear
of clean cloth wipe over the upholstery in the direction
of the nap.
warm water but no soap.
against the direction of the upholstery nap to restore
its original fluffy look.
To obtain best results, any stains must be removed as
127