Related Manuals for Toyota CHASER JZX90
Summary of Contents for Toyota CHASER JZX90
- Page 1 JZX90 / JZX100 OYOTA WNERS ANDBOOK Prepared with the help of the JZX World community http://www.jzx100.com Version 0.1 alpha- 10 April 2011...
-
Page 2: Table Of Contents
JZX90 / JZX100 NEW OWNERS HANDBOOK Version 1.01 CONTENTS General Maintenance Items ............................3 Oil System ..................................3 Cooling System ................................3 Various Fluids and Their Capacities ..........................3 Misc Items ..................................4 Spark Plugs .................................4 Spark Plug Gap ...............................4 Spark Plug Heatrange .............................5 Brakes ..................................5 Light Bulb Sizes ................................5... -
Page 3: General Maintenance Items
For example, a 0W-40 oil should be just fine, as should a 5W-30 etc. COOLING SYSTEM If you are planning to use an aftermarket coolant, make sure it is compatible with Toyota Red as other coolant types may eat away at the alloy cylinder heads. -
Page 4: Misc Items
JZX90 / JZX100 NEW OWNERS HANDBOOK Version 1.01 MISC ITEMS · Fuel Filter: Ryco Part# Z373 Gasket Turbine Outlet: 17279-88410 (gasket that goes between dump and back out the turbo) · Front Wheel Studs: NS312 (from Repco) · · Panel Air Filter: OEM 17801-46060 – K&N 33-2504 ·... -
Page 5: Spark Plug Heatrange
JZX90 / JZX100 NEW OWNERS HANDBOOK Version 1.01 SPARK PLUG HEATRANGE When increasing boost pressure it is generally recommended to change to a colder range spark plug. In the case of NGK spark plugs, if you were using a heat range 6 plug, you would go to a heat range 7 (colder) plug. -
Page 6: Mark Ii And Cresta Jzx100
· T10 for indicators · G14 is the room light · T20 for rear tail lights · T10 are dash lights Should be same for JZX90 cars though unconfirmed WHEEL ALIGNMENT JZX90 ALIGNMENT SPECS Anyone have JZX90 alignment specs? www.jzx100.com... -
Page 7: Jzx100 Alignment Specs
JZX90 / JZX100 NEW OWNERS HANDBOOK Version 1.01 JZX100 ALIGNMENT SPECS FRONT · Caster - left = 6degree 25' right = 5degree 57' · Camber - left = -2degree 10' right = -2degree 11' · Toe - left = 0.9 right = 0.1 REAR ·... -
Page 8: 100K Service Requirements
JZX90 / JZX100 NEW OWNERS HANDBOOK Version 1.01 100K SERVICE REQUIREMENTS · Engine Oil 10w-30sj VVTi: 08880-81704 · Diff Oil 85W-90: 08885-80924 · Brake Fluid: 08823-80080 · Oil filter: 90915-YZZD2 · V-belt: 90916-A2007 · Spark Plugs: PK20TR11 · Transmission Fluid: 08886-81120 ·... -
Page 9: Toyota Error Codes
JZX90 / JZX100 NEW OWNERS HANDBOOK Version 1.01 TOYOTA ERROR CODES 1 or NONE · SYSTEM NORMAL · LOSS OF POWER SUPPLY TO ECU · IGNITION SWITCH/CIRCUIT · MAIN RELAY/CIRCUIT · 6 or 12 · RPM SIGNAL-NO SIGNAL TO ECU FROM DISTRIBUTOR ("Ne" OR "G") AFTER ENGINE HAS BEEN CRANKED ·... - Page 10 JZX90 / JZX100 NEW OWNERS HANDBOOK Version 1.01 8 or 24 · INTAKE AIR TEMPERATURE SENSOR SIGNAL · OPEN OR SHORT IN INTAKE AIR TEMP. SIGNAL · INTAKE AIR TEMPERATURE CIRCUIT · INTAKE AIR TEMPERATURE SENSOR · · AIR/FUEL RATIO LEAN INDICATOR ·...
- Page 11 JZX90 / JZX100 NEW OWNERS HANDBOOK Version 1.01 14 or 34 · TURBOCHARGER PRESSURE · ABNORMAL TURBOCHARGER PRESSURE · TURBO CHARGER · AIRFLOW METER/MANIFOLD/TURBOCHARGER PRESSURE SENSOR · INTERCOOLER SYSTEM · · TURBOCHARGER PRESSURE SENSOR SIGNAL · TURBOCHARGER PRESSURE SENSOR ·...
- Page 12 JZX90 / JZX100 NEW OWNERS HANDBOOK Version 1.01 12 or 52 · KNOCK SENSOR SIGNAL--OPEN OR SHORT IN KNOCK SENSOR SIGNAL · KNOCK SENSOR/CIRCUIT · 13 or 53 · KNOCK CONTROL SIGNAL IN ECU · · EGR VALVE MALFUNCTION--EXHAUST GAS TEMPEATURE BELOW SPEC. FOR EGR CONTROL ·...