Repair Parts - Rheem PVG Installation, Operation And Service Manual

REPAIR PARTS

The following parts may be ordered through your plumber or the local
distributor. Parts will be shipped at prevailing prices and billed accordingly.
When ordering repair parts always give the following information:
1. Model ,serial and product number
2. Type of gas
3. Item number
4.
Parts description
IMPORTANT: PARTS ARE NOT FIELD REPAIRABLE.
DEFECTIVE PARTS MUST BE REPLACED WITH THE
ORIGINAL FACTORY REPLACEMENT PARTS.
REFER TO THE PARTS ILLUSTRATION ON THE
FOLLOWING PAGE.
LEGEND
Special anode rod (see page 21)
Temperature and Pressure Relief Valve is required, but may not be
factory installed.
It is imperative the replacement main burner, orifice, manifold, pilot
burner, and the thermostat be ordered for the proper gas type. Natural
gas thermostat will be marked "FOR NATURAL GAS ONLY". Propane
gas thermostats will be marked "FOR L.P. GAS ONLY".
26
REPAIR PARTS LIST
ITEM
NO. PARTS DESCRIPTION
1 BLOWER MOTOR ASSEMBLY
2 BLOWER OUTLET ADAPTER
3 BAFFLE ASSEMBLY
4 HEAT TRAP (COLD) - SOME MODELS
5 HEAT TRAP (HOT) - SOME MODELS
6 COLD WATER DIP TUBE
7 ANODE ROD
8 TEMPERATURE & PRESSURE RELIEF VALVE (LOCATED TOP
OR SIDE)
9 DRAIN VALVE
10 THERMOSTAT
11 MANIFOLD
12 ORIFICE
13 MAIN BURNER
13A BURNER NATURAL LOW NOx
14 PILOT ASSEMBLY
15 PILOT TUBE
16 THERMOCOUPLE
17 SCREW 8-32 X .375 RH PH TYPE F
18 SCREW 8-32 X .250 SELF TAPPING
19 INNER DOOR
20 OUTER DOOR
21 ALTERNATE OUTER DOOR- SOME MODELS
22 PILOT SHIELD - SOME MODELS
23 AIR SHUTTER - L.P. MODELS ONLY
24 BLEED TUBE
25 TRANSFORMER
26 AIR PRESSURE SWITCH
27 AIR HOSE
28 BLOWER RELAY
29 GAS PRESSURE SWITCH
30 GAS VALVE SOLENOID
31 MANIFOLD EXTENSION
32 SCREW 8-32 X .750 PH RH MS
33 HEX NUT KEPS