Parts List Serial Number Format Changes to Xerox products are made to accommodate improved components as they become available. It is important when ordering parts to include the following information: Component's part number Product type or model number Serial Number of the printer The serial number is found on a label located on the left-side frame near the Fuser.
J2 is attached to the other end that is plugged into P2. Note Only parts showing part numbers are available for ordering by support. Parts not showing part numbers are available on the parent assembly. Abbreviations Abbreviation Meaning C-ring E-ring K-clip Screw Phaser 6125/6130 Color Laser Printer Service Manual...
Parts List Print Engine Parts Parts List 1.1 Covers (P220) 7 (with 8-16) (J220) Front (P/J2200-P2900) s6130-038 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 5
Harness Assy A-OP (J2200-P2900) 962K60030 Shaft Pivot — Control Panel Assy PDL (6130) 848K09303 Control Panel Assy GDI (6125) 848K16161 Cover Side L 848E20081 — — Kit Shaft Pivot (with 18 × 2pcs) 675K54050 Phaser 6125/6130 Color Laser Printer Service Manual...
Parts List Parts List 2.1 Paper Tray 1 (with 2-19) Front s6130-039 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 7
RACK GUIDE SIDE SSI R — GUIDE SIDE SSI R — LATCH BOTTOM L — LATCH BOTTOM R — SPRING LEVER — TRAY ASSY EXTENSION — HOUSING CST 250 — HANDLE CST — Phaser 6125/6130 Color Laser Printer Service Manual...
Parts List Parts List 3.1 Paper Feeder (1 of 2) (J262) (J23) 14 (with 15,16) (J28) (J281) (P231) (J234) (J231) (J232) (J233) [Ref PL3.2.1] Front 3 (with 4-13,16-18,PL3.2.1,PL8.2.7,PL9.1.6) s6130-040 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 9
GEAR ASSY FEED (with 15,16) — GEAR FEED OUT — GEAR FEED IN — BEARING — HARN ASSY L SIDE (J23,J28-P231,J232,J233,J234,J281) 962K57541 KIT SOLENOID FEED (with 9-14) 675K54150 KIT CLUTCH ASSY DRV (with 1,2) 675K54230 Phaser 6125/6130 Color Laser Printer Service Manual...
Parts List Parts List 3.2 Paper Feeder (2 of 2) 1 (with 2-16,20-33) 32 (with 17-19) (P232) Registration Sensor Tray No Paper Sensor (P234) (P233) Manual Feed No Paper Sensor Front s6130-041 9-10 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 11
PLATE EARTH REGI — CHUTE UP — CHUTE LOW — BRACKET SNS — SPRING REGI L M — BEARING M — BEARING R — ACTUATOR ASSY NO PAPER (with 17-19) — PLATE WEIGHT — Phaser 6125/6130 Color Laser Printer Service Manual 9-11...
Parts List Parts List 4.1 Xerographics 99 (with 1,2 x2) (J41) (J40) (J411) (J412) 98 (with 4,5,6) x2 97 (with 4,5,7) x2 (P141) (P161) Front s6130-042 9-12 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 13
KIT BLOCK PHD RIGHT (with 4,5,7 × 2pcs) 675K54241 KIT BLOCK PHD LEFT (with 4,5,6 × 2pcs) 675K54251 KIT ROS (with 1,2 × 2pcs) (Laser Unit kit) 604K43050 a. Use PL4.1.99, Laser Unit kit, when ordering the Laser Unit. Phaser 6125/6130 Color Laser Printer Service Manual 9-13...
Parts List Parts List 6.1 Transfer & Fuser (P171) (J171) (J17) (J47) (P281) Front s6130-044 9-16 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 17
Harn Assy Fuser (J17,J47-P171) — Stopper Pivot — Pivot Trans L — Gear T4 — Shaft Assy Pivot — Transfer (Unit) Belt 848K03270 Cover Harness 2 — Kit Pivot (with 3-6) 675K54121 Phaser 6125/6130 Color Laser Printer Service Manual 9-17...
Parts List Parts List 7.1 Drive Front (P221) (P211) Color Mode Switching Sensor (P261) (J24) s6130-045 9-18 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 19
Parts List 7.1 Drive ID No. Name/Description Part Number Drive Assy Sub (Sub Drive Assembly) 007K94691 Drive Assy Main (Main Drive Assembly) 007K94685 Gear P2 807E15100 Drive Assy PH (Feed Drive Assembly) 007K94704 Phaser 6125/6130 Color Laser Printer Service Manual 9-19...
Page 20
Parts List Parts List 8.1 Electrical (1/2) (J503) Front 9 (with 10) (P101) (P111) (P401) (P29) s6130-046 9-20 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 21
Frame ESS (Image Processor Frame) — Plate IF — PWBA ESS Phaser 6130 (with 10) (I/P Board) 960K36163 PWBA ESS Phaser 6125 (with 10) (I/P Board) 960K38520 NVM ROM REF ONLY MULTI PROTOCOL CARD (OPTION) 097S03745 Phaser 6125/6130 Color Laser Printer Service Manual...
E-Ring, 4 mm (1) Packaging Kit Parts List Reference Description Part Number — Packaging Kit, 110V 100S64594 Packaging Kit, 220V 100S64595 — Packaging Kit, DMO 110V 100S64644 Packaging Kit, DMO 220V 100S64645 Phaser 6125/6130 Color Laser Printer Service Manual 9-27...
Page 28
Parts List 9-28 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 29
Plug/Jack and Wiring Diagrams In this chapter... Plug/Jack Diagrams and Designators Plug/Jack Locators Notations Used in the Wiring Diagrams Print Engine Wiring Diagrams Chapter...
Connects MCU Board and HUM Harness Assy J-157 Connects MCU Board and Main Motor Harness Assy J-157 Connects MCU Board and Sub Motor Harness Assy J-158 Connects MCU Board and L Side Harness Assy 10-2 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 31
Connects Dispenser Assy (M-Dispenser Motor Assy) and TNR Motor Harness Assy C-151 Connects Dispenser Assy (C-Dispenser Motor Assy) and TNR Motor Harness Assy C-150 Connects Dispenser Assy (K-Dispenser Motor Assy) and TNR Motor Harness Assy Phaser 6125/6130 Color Laser Printer Service Manual 10-3...
Page 32
D-123 Connects ROS ASSY and Laser Unit Video Harness Assy G-150 Connects Imaging Unit (Eeprom Imaging Unit) and Imaging Unit XPRO Harness Assy G-140 Connects GFI Breaker and Power Switch Harness Assy 10-4 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 33
2811 D-107 Connects ADC Sensor and ADC SNR2 Harness Assy (Transfer Belt) 5041 I-107 No Connection (Used in production process only) 2200/ H-111 Connects A-OP Harness Assy and B Harness Assy 2900 Phaser 6125/6130 Color Laser Printer Service Manual 10-5...
Map 1 - Transfer Unit, Control Panel, Imaging Unit, Dispenser, Fuser Map 2 - Laser Unit, Feeder Assembly Map 3 - LVPS, Drive Motors, I/P Board, AC Power Map 4 - Toner Dispenser Motors, HVPS, MCU General Diagram - Plug/Jack Locations s6130-057 10-6 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 35
Plug/Jack and Wiring Diagrams s6130-058 Phaser 6125/6130 Color Laser Printer Service Manual 10-7...
Plug/Jack and Wiring Diagrams Map 1 - Transfer Unit, Control Panel, Imaging Unit, Dispenser, Fuser 2811 5041 2200/2900 s6130-053 10-8 Phaser 6125/6130 Color Laser Printer Service Manual...
Denotes the parts. PL X.Y.Z implies the item “Z” of plate (PL) “X.Y” Fuser in Parts List. PL X.Y.Z s6180-471 Denotes functional parts attached with functional parts name. Heater s6180-472 10-12 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 41
The given voltage is for signal in high status. The arrow indicates the direction of signal. s6180-476 Denotes a connection between wires. s6180-477 Denotes a Clutch or Solenoid. s6180-464 Denotes a Motor. s6180-465 Phaser 6125/6130 Color Laser Printer Service Manual 10-13...
Page 42
Denotes an NPN Photo-transistor. s6180-483 I/L +24 VDC Denotes DC voltage when the Interlock Switch in MCU Board turns On. +5 VDC Denotes DC voltage. +3.3 VDC Denotes signal ground. Denotes analog ground. Denotes return. 10-14 Phaser 6125/6130 Color Laser Printer Service Manual...
Connections of CRUM Connector (Y) with MCU Board. Connections of CRUM Connector (M) with MCU Board. Connections of CRUM Connector (C) with MCU Board. Connections of CRUM Connector (K) with MCU Board. Phaser 6125/6130 Color Laser Printer Service Manual 10-15...
Page 44
Connections of Fuser with LVPS. Connections of MCU Board with LVPS. Controller Connections of Image Processor Board (ESS) with MCU Board. Connections of Control Panel with Image Processor Board. Connections of LVPS with Image Processor Board. 10-16 Phaser 6125/6130 Color Laser Printer Service Manual...
5 VDC and 3.3 VDC. Deep Sleep Mode (Power Saver) The output of the following power supply are stopped according to the signals. Signal +3.3 VDC +5 VDC +24 VDC Sleep Deep Sleep 10-18 Phaser 6125/6130 Color Laser Printer Service Manual...
Sensor (SSI No Paper Sensor). PAPER EMPTY SENSED Paper detect signal of the Paper Tray by the Photo (L) +3.3VDC Sensor (CST No Paper Sensor). REGI CL ON (L) +24VDC ON/OFF signal of the Drive Clutch. Phaser 6125/6130 Color Laser Printer Service Manual 10-19...
Page 48
MAIN MOT CW/CCW Interlock Sub Motor Harness +24VDC PL9.1.8 Sub Drive P/J22 P/J221 PL7.1.1 I/L +24VDC I/L +24VDC SUB MOTO ON SUB MOT ALARM SUB MOT CLK SUB MOT LOW SUB MOT BRAKE s6130-061 10-20 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 49
MAIN MOT ALARM MAIN MOT CLK MAIN MOT LOW MAIN MOT CW/CCW SUB MOT ON Drive control signal of the Sub Drive SUB MOT ALARM SUB MOT CLK SUB MOT LOW SUB MOT BRAKE Phaser 6125/6130 Color Laser Printer Service Manual 10-21...
V REF K +5VDC V REF C V REF M V REF Y +3.3V LD From Laser Video Harness Xerography PL4.1.23 P/J41 P/J412 DATA K DATA C DATA M DATA Y s6130-062 10-22 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 51
V REF Y LD ERR Error signal of the laser diode PCONT Power control signal of the laser diode DATA K Video signal of the laser diode. DATA C DATA M DATA Y Phaser 6125/6130 Color Laser Printer Service Manual 10-23...
Page 52
Erase LED ERASE Y/M/C ON (L) +3.3VDC PL4.1.8 ERASE K ON (L) +3.3VDC Transfer Assembly Left Side Harness PL6.1.7 PL3.1.18 P/J28 P/J281 P/J2811 +5VDC ADC SENSOR LED REM Sensor ADC V MONI s6130-063 10-24 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 53
ADC SENSOR Toner patch density data measured by the ADC Sensor (Analog value). LED REM Remote signal of the LED of the ADC Sensor. ADC V MONI Control signal of the ADC Sensor. Phaser 6125/6130 Color Laser Printer Service Manual 10-25...
+3.0V REF MAIN CLK I/L +24V Developer BTR : Bias Transfer Roll BCR : Bias Charge Roll s6130-064 Signal Line Name Description TR MON Controls signal of the HVPS. CF MON COLOR DATA 10-26 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 55
CLK M OUT CRUM (M) +3.3VDC PL5.1.14 P/J313 DATA C IN Connector CLK C OUT CRUM (C) +3.3VDC PL5.1.14 P/J314 DATA K IN Connector CLK K OUT CRUM (K) +3.3VDC PL5.1.14 s6130-065 Phaser 6125/6130 Color Laser Printer Service Manual 10-27...
Page 56
Controls signal of the CRUM Connector (M). CLK M OUT DATA C IN Controls signal of the CRUM Connector (C). CLK C Out DATA K IN Controls signal of the CRUM Connector (K). CLK K OUT 10-28 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 57
N HEAT1 P1712 LINE FUSER ON P1713 Thermostat P/J504 Used in production J5041 process only. RELAY TEST LOW RELAY TEST HIGH Relay Test Harness PL5.1.28 230V Spec. P/J171 N HEAT1 P/J47 LINE s6130-066 Phaser 6125/6130 Color Laser Printer Service Manual 10-29...
Page 58
Paper detects signal of the Fuser Exit by the Photo +3.3 VDC Sensor (Exit Sensor). FUSER ON Displays lighting signal of the Fuser Lamp. RELAY TEST LOW Tests signal of the LVPS (used in production process only) RELAY TEST HIGH 10-30 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 59
P/J401 P/J40 +3.3VDC +5VDC +3.3VDC +3.3VDC Control Panel B Harness Control Panel A Harness PL9.1.12 PL1.1.20 Control Panel PL1.1.18 P/J29 P/J2900 P/J220 +5VDC +5VDC DATA +5VDC WAKE UP LED ON +3.3VDC s6130-067 Phaser 6125/6130 Color Laser Printer Service Manual 10-31...
Page 60
VSYNC M VSYNC Y HSYNC Signal for data. DATA K Video data of four colors. DATA C DATA M DATA Y DATA Control signals of the Control Panel. BACK LIGHT BL +5 VDC 10-32 Phaser 6125/6130 Color Laser Printer Service Manual...
Page 61
Reference Contents... Phaser 6130 Menu Map Firmware Update Acronyms and Abbreviations Appendix...