1. Manuals
  2. Brands
  3. Holland Manuals
  4. Automobile Parts
  5. FW3110
  6. Operating manual

Holland FW3110 Operating Manual

Holland fifth wheel operating manual
Hide thumbs
1
2
3
4
5
6
7
8
Table of Contents

Advertisement

Quick Links

XL-FW1114-01
FW351 0

Table of Contents

1.1
Identification of component parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
1.2
Important specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
2.1
Pre-service inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
2.2
Trailer coupling procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4
2.3
Trailer uncoupling procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
3. Routine Inspection and Maintenance
3.1
As Needed Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
3.2
Required Inspections and Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-8
3.2.1 General fifth wheel inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
3.2.2 Inspection of locking mechanism . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
3.2.3 Lock adjustment procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
FW3510/FW3410 &
FW3110 FIFTH WHEEL
OPERATING MANUAL
You must read and understand
the instructions in this
manual before operating
your
WARNING
Failure to follow all of the
important operating procedures
contained in these instructions
may result in a hazardous
condition or cause a hazardous
condition to develop.
These instructions apply to the
proper operation of your fifth
wheel only. There are other
important checks, inspections,
and procedures not listed here
that are necessary, prudent,
and/or required by law.
fifth wheel.
1

Advertisement

Table of Contents
loading

Related Manuals for Holland FW3110

Summary of Contents for Holland FW3110

  • Page 1: Table Of Contents

    3. Routine Inspection and Maintenance XL-FW1114-01 FW3510/FW3410 & FW3110 FIFTH WHEEL OPERATING MANUAL WARNING Identification of component parts ........2 Important specifications .

  • Page 2: Component Part Identification And Specifications

    * Fifth Wheel Height "H" Does Not Include Mounting Plate Thickness. ** For the low lube version replace the "35" with "34" (i.e. FW3410-150); for the no lube version replace the "35" with "31" (i.e. FW3110-150). 15° min. Fifth Wheel Model No.

  • Page 3: Operating Instructions

    Set trailer brakes XL-FW1114-01 Rev. A Lubricate the fifth wheel-to-trailer contact surface with grease (not required for the FW3310 & FW3110). Tilt the ramps down. If the locks are closed: • Grip handle; • Pull “trigger”; • Slide back/left (to disengage the lock);...

  • Page 4: Trailer Coupling Procedures

    2. Operating Instructions 2.2 Trailer Coupling Procedures Adjust trailer height so the fifth wheel will lift the trailer. The Trailer should contact the fifth wheel 100 – 150 mm behind the fifth wheel bracket pin. SLOWLY back into trailer. « The coupling procedure is not complete without a visual inspection.

  • Page 5: Trailer Uncoupling Procedures

    2. Operating Instructions 2.2 Trailer Coupling Procedures Retract landing gear until pads come off the ground. Re-check brake lines and light cord. Remove chocks, continue with pre-trip inspection. 2.3 Trailer Uncoupling Procedure Position tractor and trailer on firm, level ground — clear of obstacles and persons. Set trailer brakes.

  • Page 6: As Needed Lubrication

    Note: Maintain adequate lubrication on the following surfaces by inspecting and re-lubricating at regular intervals. Grease the trailer contact surface area* *not required for the FW3310 & FW3110 models. Use water-resistant lithium-base grease Lock jaws and front lock (Kingpin contact areas) 3.2 Required Inspections and Adjustments...

  • Page 7: Inspection Of Locking Mechanism

    3.2.2 Inspection of Locking Mechanism Verify the proper operation of the fifth wheel by locking and unlocking the fifth wheel locks using a Holland Kingpin Lock Tester TF-TLN-1000 or TF-TLN-5001. Set tool on the fifth wheel and rotate the handle.
  • Page 8 United States Fax: +49 (0) 5207-895656 Phone: (616) 396-6501 Fax: (616) 396-1511 Copyright © September 2005 • The Holland Group, Inc. Holland Hitch (Aust.) Pty. Ltd. Melton, Victoria, Australia Holland Eurohitch Ltd. Phone: Hoo Farm Industrial Estate Fax: Worcester Road...

This manual is also suitable for:

Fw3410Fw3510

Table of Contents