Download
Share
Print this page
Traxxas S-Maxx 5109 Owner's Manual
  1. Manuals
  2. Brands
  3. Traxxas Manuals
  4. Motorized Toy Car
  5. S-Maxx 5109
  6. Owner's manual
Traxxas S-Maxx 5109 Owner's Manual

Traxxas S-Maxx 5109 Owner's Manual

Hide thumbs

Advertisement

Quick Links

Download this manual
'
OWNER
S MANUAL
MODEL 5109

Advertisement

loading

Related Manuals for Traxxas S-Maxx 5109

Summary of Contents for Traxxas S-Maxx 5109

  • Page 1 ’ OWNER S MANUAL MODEL 5109...
  • Page 2 Phone: 44-117-956-1002 Internet www.Traxxas.com E-mail: support@Traxxas.com Entire contents ©2004 Traxxas. Traxxas, S-Maxx, TRX 2.5, TQ-3, Top Fuel, EZ-Start, Ready-To-Race, Ready-To-Win and ProGraphix are trademarks or registered trademarks of Traxxas. Other brand names and marks are the property of their respective holders and are used only for purposes of identification.
  • Page 3 Introduction Before You Proceed Thank you for purchasing a Traxxas S-Maxx (Stadium Maxx) nitro Obviously, there’s much going on between the wheels of your monster truck. Traxxas engineers focused on the essentials of S-Maxx. In this manual, we’ll take you step-by-step through all...
  • Page 4 Traxxas service needs. Maintenance and replacement hints, identified by the icons below. Be sure to read them! parts may be purchased directly from Traxxas, or you can save shipping and handling costs by purchasing them from your local hobby dealer.

  • Page 5: Safety Precautions

    Safety Precautions All of us at Traxxas want you to safely enjoy your new S-Maxx. Never operate your S-Maxx in crowds of people or busy All instructions and Operate your S-Maxx sensibly and with care, and it will be pedestrian areas. The S-Maxx is large and fast, and may cause precautions exciting, safe, and fun for you and those around you.
  • Page 6 Supplied Tools 10% gallon - #5060 • 20% gallon- #5070 Your S-Maxx comes with these specialty metric tools: A peak-detecting 1.5mm hex wrench Fuel dispensing bottle (Traxxas part #5001) charger is recommended for 2.0mm hex wrench best performance and longest battery life. For...
  • Page 7 Anatomy of the S-Maxx Fuel Tank Chassis Steering Battery Servo Slipper Clutch On/Off Fuel Switch Suspension Tank Spur Arm (upper) Pressure Line Gear Bumper (Front) EZ-Start Motor Shock Fuel Line Tower Skid Plate EZ-Start (front) Plug Cross-brace Bumper Mount Body Mount Pipe Bulkhead...
  • Page 8 S-Maxx. interference from outside sources. Get the right fuel • See page 26 Use Traxxas Top Fuel™ or consult with Traxxas 12. Fill the fuel tank • See page 26 before using other fuels. Use your fuel-dispensing bottle to fill the tank.
  • Page 9 Gluing The Tires The tires on your S-Maxx must be glued to the rims using CA 4. Reinstall the wheels, making Always wear safety glasses to prevent glue tire glue to prevent the rims from spinning inside the tires. You sure none of the axle pins from splattering into can glue the tires without removing the wheels from the truck.
  • Page 10 Decorating Your S-Maxx Applying The Decals The main decals have already been applied to your Revo. The extra decals provided are die-cut for easy removal. Use a hobby knife to lift the corner of a decal and remove it from the backing.
  • Page 11 The Traxxas TQ-3 Radio System Your S-Maxx (model 5109) is equipped with the TQ-3 Radio S-Maxx Wiring Your S-Maxx can be Diagram System. The TQ-3 is a 3-channel system that provides high-power outfitted with full Positive output up to a quarter mile and control for up to three servos.
  • Page 12 Of those two crystals, the one marked with the lower number (.455 MHz lower) must be inserted into the receiver. Frequency band - The radio frequency used by the transmitter to send signals to your S-Maxx. All Traxxas RTR models operate on a 27 MHz frequency band.

  • Page 13: Installing Transmitter Batteries

    The Traxxas TQ-3 Radio System Use the Right Batteries Installing Transmitter Batteries Your transmitter and receiver Your TQ-3 transmitter uses 8 AA batteries. The battery use AA batteries. Use new compartment is located at the base of the transmitter. alkaline batteries, or...
  • Page 14 The Traxxas TQ-3 Radio System Installing Receiver Batteries Direct the battery wires through the slot in the The radio receiver in your S-Maxx uses 4 AA batteries. The battery battery cover. If the holder for the receiver batteries is located underneath the battery wires are not properly cover.
  • Page 15 The Traxxas TQ-3 Radio System Setting Up the Antenna Spray a little window cleaner on the antenna You must install the antenna mast (tube) before you operate Antenna Tip wire to make it easier your S-Maxx. You’ll find the plastic antenna tube and tip in the to push through the bag with your manuals and documentation.
  • Page 16 The Traxxas TQ-3 Radio System Other TQ-3 Radio System Adjustments TQ-3 Radio System Controls In addition to the electronic throttle and steering trim controls, your radio system features throttle neutral adjustment and servo reversing switches. Throttle Neutral Adjustment The throttle neutral adjustment is located on the transmitter face and controls the forward/brake travel of the throttle trigger.
  • Page 17 The Traxxas TQ-3 Radio System will roll freely). Do not use the throttle trim to raise or lower the engine idle speed. Make the idle speed adjustment on the carburetor. Electronic Steering Trim The electronic steering trim located on the face of the transmitter adjusts the neutral (center) point of the steering servo when the servo is at rest.
  • Page 18 The Traxxas TQ-3 Radio System TQ-3 Radio System Rules Remember, always turn the TQ-3 Always use new or freshly charged batteries for the radio Each time you prepare to run your transmitter on first Channel 1 system. Weak batteries will limit the range of the radio signal...
  • Page 19 The Traxxas TQ-3 Radio System 6. Operate the throttle trigger on the transmitter and check for Using the TQ-3 Radio System When the engine is rapid operation of the throttle servo. When the throttle running, don’t use The TQ-3 Radio System was pre-adjusted at the factory. The the throttle trim on trigger is pulled back, the carburetor should open.
  • Page 20 The Traxxas TQ-3 Radio System Range-Testing the TQ-3 Radio System Don’t attempt to operate your Before each running session with your S-Maxx, you should range- S-Maxx if there are test your radio system to ensure that it operates properly. any problems with your radio system or radio 1.
  • Page 21 The TRX 2.5 Racing Engine Traxxas strongly Introduction discourages changing There’s nothing like the TRX 2.5 Racing Engine in your new or modifying any part S-Maxx. The TRX 2.5 Racing Engine is vastly superior to typical of the TRX 2.5 Racing R/C engines and belongs in the category of specialty high- Engine.
  • Page 22 The TRX 2.5 Racing Engine TRX 2.5 Illustrated Head Protector Filter Idle Speed Head (Cylinder head) Screw EZ-Start Drive Unit High-Speed Needle Fuel Intake Air Intake Carburetor Flywheel EZ-Start Clutch Motor Bell Engine Crankshaft Throttle Low-Speed Mount Needle Crankcase Ground EZ-Start Wire EZ-Start...
  • Page 23 RPM range. Follow the Traxxas directions for break-in exactly. EZ-Start - Second generation Traxxas on-board electric starting Carb - Abbreviation for carburetor. system. The system consists of a hand held starter control unit...
  • Page 24 Fuel - (10% 20%) The TRX 2.5 must have model engine fuel to Leaning the mixture - Turning either the high speed and/or run. Traxxas Top Fuel is recommended. Fuel is sold in quarts low-speed needle(s) clockwise to decrease the amount of fuel and gallons from hobby dealers.
  • Page 25 This is sometimes necessary after the engine has been sitting for a long period of time and all the fuel has drained back to the tank. On a Traxxas model this is done by holding your finger over the exhaust tip for one or two seconds while the engine is starting.
  • Page 26 Top Fuel is the only fuel which is 100% certified for use in in this manual. Traxxas engines. Traxxas Top Fuel is made with just the right balance of the Filling the Fuel Tank highest grade natural and synthetic lubricants to allow...
  • Page 27 Never run the engine without a properly You must clean the filter after every hour of runtime, even if the oiled filter! Apply 30 drops of the Traxxas filter oil evenly to the top, bottom and sides of the filter element (30 total drops filter looks clean.
  • Page 28 The TRX 2.5 Racing Engine See page 35 for The Carburetor the correct air/fuel ratio. Warmer air is less dense (fewer air more information on molecules) and therefore needs less fuel to maintain the correct Understanding the Carburetor adjustments how air density air/fuel ratio.
  • Page 29 The TRX 2.5 Racing Engine Slightly lean fuel mixtures deliver stronger, more efficient See Tuning the TRX 2.5 for Best Performance Water Valve combustion and more power, but with less lubrication. on page 34 for (Controls Overall Flow) complete information on High Speed Needle Slightly rich fuel mixtures deliver cooler running and more adjusting the air/fuel...
  • Page 30 Use the The EZ-Start system requires a fully charged 7.2-volt NiCad Right Charger The Traxxas EZ-Start brings the convenience of push-button The most convenient battery pack (not included). Use a charger (not included) electric engine starting to your S-Maxx. The EZ-Start consists of type of charger is an AC peak- designed for 7.2-volt battery packs.
  • Page 31 The TRX 2.5 Racing Engine Using the EZ-Start Protection Mode When the EZ-Start Your EZ-Start controller plugs into a 4-prong receptacle in the The EZ-Start uses Smart Start ™ technology to monitor the controller is in protection mode, wait at least three center of the pickup bed on your S-Maxx.
  • Page 32 5 for other piston/sleeve construction.This type of engine design relies on a Keep extra glow plugs handy (Traxxas part #3231).The break-in precautions. very precise running fit between the piston and sleeve for cylinder process can cause deposits to form on the plug leading to plug sealing.
  • Page 33 3-second count. Then gently apply the brake to Traxxas break-in procedure. 3. Look for thick blue smoke exiting the exhaust outlet. If there is stop. Count the three seconds out while accelerating: one...
  • Page 34 The TRX 2.5 Racing Engine Tuning the TRX 2.5 for Best Performance If any one of the following conditions occurs, the fuel mixture When adjusting the is already past the maximum safe lean setting: low-speed fuel mixture, The engine’s performance depends on the fuel mixture. Turn the it is very important to mixture needles clockwise to lean the fuel mixture and 1.
  • Page 35 The TRX 2.5 Racing Engine Low-Speed Fuel Mixture Adjustment 2. If necessary, remove the air filter to gain access to the idle The low-speed mixture is always set after the high-speed needle adjustment screw. is correctly adjusted. The low-speed mixture will be set using the 3.
  • Page 36 270°F when measured at the glow plug. If tuning for maximum or on-board temperature gauge performance results in engine temperature exceeding 270°F, (Traxxas on-board digital try to increase airflow to the engine by cutting out the rear temperature gauge, part#4090).
  • Page 37 Driving the S-Maxx Driving Tips Introduction Monster trucks by design have a high center of gravity that Your TRX 2.5 Racing Engine is broken in, the fuel mixture is requires a different driving technique. To prevent rollovers, balanced, and the idle is set…now it’s time to have some fun! slow down as you approach turns and then apply strong This section contains instructions on driving and making throttle through the turns.
  • Page 38 Adjusting Your S-Maxx Once you become familiar with driving your S-Maxx, you might Adjusting the Camber Factory toe-in settings need to make adjustments for better driving performance. Two pivot balls are accessible through can be achieved by the spokes of each of the wheels on installing the rod ends Adjusting the Slipper Clutch your S-Maxx.
  • Page 39 The caster progression and the soft, plush feel that’s characteristic of a angle can be increased to 10-degrees by removing the front Traxxas Maxx Truck. shim and inserting it next to the rear shim.
  • Page 40 Adjusting Your S-Maxx For easier access to the Spring rate (at the wheel) increases as the lower shock Spring rate (at the wheel), increases as the upper shock rear-most shock mounting position is moved from position (1) to position (4). mounting position is moved from position (A) to position (B).
  • Page 41 Adjusting Your S-Maxx Adjusting the Two-Speed Transmission 6. Turn the adjustment screw 1/8 The S-Maxx comes equipped with a two-speed transmission. turn clockwise to raise the shift When the shift point on the transmission is adjusted correctly, it point (later shifts). Be careful not will maximize acceleration and improve drivability.
  • Page 42 If you can’t find a solution for your S-Maxx here, then should automatically reset. visit our Web site at www.Traxxas.com and click on the Customer Check to make sure the wires are connected to the EZ-Start Support menu.There you will find a much more extensive and motor in the S-Maxx.The red wire should connect to the...
  • Page 43 Try new, fresh, Traxxas Top Fuel plug LED does not light, make sure the blue glow plug wire is Try a new Traxxas 3231 glow plug. Sometimes a glow plug tightly connected and is not damaged in any way. If the wire will work well enough to start the engine but not be able to is good, then replace the glow plug.
  • Page 44 27. We cannot stress enough the the Traxxas Lifetime Engine when throttle is suddenly closed to idle. value of cleaning your air filter at the scheduled intervals.
  • Page 45 Maintaining and Storing Your S-Maxx After-run Procedure You must perform after-run maintenance on your Traxxas 5. Open the throttle fully and spray a one-second burst of Denatured alcohol engine whenever the model will be stored for longer than a few...
  • Page 46 27 Traxxas Top Fueler, 26 Air Intake, 22 Air temperature, 36, 42 barrel, 23 detonation, 34 Traxxas Top Fuel, 24, 26, 42 Air/fuel mixture, 28 fine-tuning, 35 failure, 27, 43 unburned, 44 Air/fuel ratio, 28, 29, 32 slide, 25...
  • Page 47 43 power indicator, 11, 13 ProGraphix, 10 Lubrication, 29 Punch, 25 Smoke, 34 Traxxas Lifetime Engine Maintenance, 43 Quick Start, 8, 9, 10, 13, 14, 15, 18, Spring rate, 40 Replacement Plan, 43 Maintenance schedule, 21 19, 20, 26, 30, 31, 32, 34, 37, 43...
  • Page 48 1 100 Klein Road, Plano Texas 75074 1-888-TRAXXAS...

This manual is also suitable for:

S-maxx