Table of Contents
Advertisement
Y
OU MUST READ THIS
BEFORE OPERATING YOUR GAS GRILL
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
WARNING
1. Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2. Do not store or use gasoline or other
flammable liquids or vapors within
25 feet (8m) of this appliance.
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if
the barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
WARNING: Do not try to light this
appliance without reading the "Lighting"
Instructions section of this manual
G E N E S I S
O
G
WNERS
UIDE
DANGER
®
LP Gas Grill Owners Guide
#
A218_LP.c
Ba202.d
B204_LP.b
C202_LP.d
D202_LP.c
E201.c
55253 05/07/02
LP
US English
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Weber LP Gas Grill
Summary of Contents for Weber LP Gas Grill
- Page 1 ® G E N E S I S LP Gas Grill Owners Guide OU MUST READ THIS WNERS UIDE BEFORE OPERATING YOUR GAS GRILL DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames.
-
Page 2: Danger & Warnings
Dangers & Warnings DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. -
Page 3: Table Of Contents
Contents Danger & Warnings ..................A-2 Warranty ....................A-4 General Instructions .................A-5 Cooking ....................A-6 Cleaning ....................A-6 Exploded View ..................A-7 Parts List ....................A-9 Unpacking ....................A-10 Assembly Instructions ................B-a Gas Instructions ..................C-1 Leak Checking ..................C-3 Refilling the LP Cylinder ................C-4 Safe handling tips for LP Gas ..............C-5 Operating ....................D-1... -
Page 4: Warranty
Warranty Weber-Stephen Products Co. (Weber) hereby warrants to There are no other express warrants except as set forth ® herein and any applicable implied warranties of the ORIGINAL PURCHASER of this Weber gas grill that merchantability and fitness are limited in duration to the it will be free of defects in material and workmanship from period of coverage of this express written Limited Warranty. -
Page 5: General Instructions
General Instructions Your Weber ® gas barbecue is a portable outdoor cooking Storage and/or Nonuse ® appliance. With the Weber gas barbecue you can grill, • The gas must be turned off at the liquid propane cylinder barbecue, roast and bake with results that are difficult to ®... -
Page 6: Cooking
General Instructions Cooking Cleaning ® ® WARNING: Do not move the Weber gas barbecue WARNING: Turn your Weber gas barbecue OFF and when operating or while barbecue is hot. wait for it to cool before cleaning. You can adjust the FRONT and BACK burners as desired. CAUTION: Do not clean your Flavorizer ®... -
Page 7: Exploded View
Exploded View ® Genesis Gold-C LP 111301... -
Page 8: Exploded View List
Exploded View List Hinge Pin Right Endcap Left Endcap Thermometer Shroud Handle Hardware Handle Control Panel Knobs ™ Warm-Up Basket Control Panel Warming Rack Control Panel Hardware Cooking Grates Crossover ® Ignition Button ® ® Flavorizer Bars Crossover tube Cooking Box Front / Rear Burner 1/4-20 keps nut Center Burner... -
Page 9: Parts List
Parts List Cooking Box Assembly - 1 Side Burner - 1 Flavorizer ® Bars - 5 Warm-Up ™ Basket - 1 Warming Rack - 1 Cooking Grate - 2 Caster Frame - 1 Bottom Tray - 1 Catch-Pan Holder - 1 Wheel Frame - 1 Catch-Pan - 1 Disposable Drip Pans - 2... -
Page 10: Unpacking
Unpacking A-10... - Page 11 • Arrow sticker to the front. • Push down firmly until Bottom Rack Lock, "locks" under the rail. Ba202.d...
- Page 12 • Push down firmly on both sides to ensure bottom rack is locked under the rails. WARNING: Do not go to next step if bottom rack is not locked in place...
- Page 13 • Install bolts at indicated locations. Use supplied tool to tighten. Finish tightening bolt with metal wrench provided or a 7/16” wrench.
- Page 14 B204_LP.b...
-
Page 21: Gas Instructions
Gas Instructions Fill liquid propane cylinder Please make sure your filling station fills your LP cylinder Note - The liquid propane cylinder manufacturer is by weight or volume. Ask your filling station to read purging responsible for the materials, workmanship and and filling instructions on the LP cylinder before attempting performance of the cylinder. - Page 22 Gas Instructions Pass regulator through left hole in support panel. Note: This is a new type of connection. It tightens clockwise and will not allow gas to flow unless the connection is tight. The connection requires tightening by hand only. WARNING: Do not use a wrench to tighten the connection.
-
Page 23: Leak Checking
Gas Instructions Check for gas leaks Remove control panel and burner control knobs You will need: Phillips screwdriver. DANGER 1) Remove control knobs. Do not use an open flame to check for gas Unhook side burner from Cookbox Frame. leaks. Be sure there are no sparks or open Remove screws with a Phillips screwdriver 4) Pull up igniter button until it sticks in the up position and flames in the area while you check for leaks. -
Page 24: Refilling The Liquid Propane Cylinder
Gas Instructions Liquid Propane Cylinder Check: The liquid propane cylinder manufacturer is responsible for 1) Hose to manifold connection. the materials, workmanship and performance of the tank. If WARNING: If there is a leak at connection (1), the tank has a defect malfunctions, or you have a question retighten the fitting with a wrench and recheck for regarding the tank, call the tank manufacturer’s customer leaks with soap and water solution. -
Page 25: Safe Handling Tips For Liquid Propane Gas Cylinders
Gas Instructions Liquid Propane (LP) Cylinder(s) Safe handling tips for Liquid Propane The joint where the hose connects to the LP cylinder must be leak tested each time the LP cylinder is Gas Cylinders reconnected. For example, test each time the LP Liquid Propane (LP) gas is a petroleum product as are cylinder is refilled. -
Page 26: Operating
Operating Instructions Lighting DANGER: Summary lighting instructions are on the control panel. When the “excess gas flow control” feature is activated, a small amount of gas I still flowing to the DANGER burners. After turning OFF the cylinder knobs, wait at Failure to open the lid while igniting the least 5 minutes for the gas to clear before attempting barbecue’s burners, or not waiting 5 minutes... -
Page 27: Manual Lighting
Operating Instructions Manual Lighting 3) Turn the cylinder on by turning the cylinder valve counterclockwise. 4) Strike a match and put the flame into the matchlight DANGER hole in the front of the cooking box. Failure to open the lid while igniting the WARNING: Do not lean over open barbecue. -
Page 28: Lighting The Side Burner
Operating Instructions The side burner has a separate ignition system from the Lighting the side burner if the main burners are lit. main cooking box. 1) Open the side burner lid. DANGER 2) Push down and turn the side burner control to HI. 3) Press the side burner igniter button several times so it Failure to open the lid while igniting the side clicks each time. -
Page 29: Troubleshooting
Troubleshooting Problem Check Cure ® Burners burn with a yellow or Inspect Weber ® Insect / Spider Clean Weber Insect / Spider orange flame, in conjunction with screens for possible instructions. screens. (See Section “Annual the smell of gas. (Blockage of holes.) Maintenance”) Burners do not light. -
Page 30: Side Burner Troubleshooting
Side Burner Troubleshooting Problem Check Cure Side Burner does not light. Is gas supply off? Turn supply on. Flame is low in HIGH position. Is the fuel hose bent or kinked? Straighten hose. Inspect the Weber ® Insect / Spider Clean Weber ®... -
Page 31: Maintenance
If the spider/insect screen becomes damaged or cannot be can nest in the venturi section(1) of the burner tubes. This cleaned, call Weber-Stephen Products Customer Service blocks the normal gas flow, and can cause the gas to flow for replacement parts. -
Page 32: Replacing Main Burners
Maintenance CAUTION: The burner openings(1) must be Replacing Main Burners positioned properly over the valve orifices(2). 1) Your Weber ® gas barbecue must be OFF and cool. Check proper assembly before fastening manifold in place. 2) Turn gas OFF at source. 3) To remove control panel: take off the burner control knobs.