Related Manuals for Munchkin Gas-fired Hot Water Boiler
Summary of Contents for Munchkin Gas-fired Hot Water Boiler
- Page 1 User Manual...
-
Page 2: Table Of Contents
Product and Safety Information ..........2,3 Service and Maintenance Munchkin Operation Primary Water Section I –... -
Page 3: Product And Safety Information
User Manual GAS-FIRED BOILER PRODUCT AND SAFETY INFORMATION SPECIAL ATTENTION BOXES The following defined terms are used throughout this manual to bring attention to the presence of hazards of various risk levels or to important information concerning the product. DEFINITIONS DANGER CAUTION DANGER indicates an imminently hazardous... -
Page 4: Primary Water
User Manual GAS-FIRED BOILER PRODUCT AND SAFETY INFORMATION (CONT’D) PRIMARY WATER WARNING • If you have an old system with cast iron User — Have this boiler serviced/inspected by radiators, thoroughly flush the system a qualified service technician annually. (without boiler connected) to remove sediment. -
Page 5: Section I - Combustion Air - Prevention Of Contamination
SECTION I – COMBUSTION AIR – PREVENTION OF CONTAMINATION AREAS LIKELY TO FIND THESE PRODUCTS WARNING Products to avoid If the Munchkin combustion air inlet is located in any area likely to cause or contain Spray cans containing fluorocarbons contamination, or if products, which would... -
Page 6: Section Ii – Maintenance Schedule
• Check the temperature/pressure gauge service and maintenance or follow the Monthly: directions in this manual could result in damage to the Munchkin or in system components, • Check vent piping. resulting in severe personal injury, death or • Check combustion air inlet piping. -
Page 7: Monthly Maintenance
User Manual GAS-FIRED BOILER SECTION III – MAINTENANCE PROCEDURES (CONT’D) be removed immediately or the combustion Check Pressure Relief Valve air intake must be relocated to another area. 1. Visually inspect the primary pressure relief Check Combustion Air Inlets valve and the relief valve discharge pipe for signs of weeping or leakage. -
Page 8: Month Maintenance
This discharge line must be installed by a qualified service technician or heating/plumbing installer in accordance with the Munchkin installation manual. The discharge line must be terminated so as to eliminate possibility of severe burns or property damage should the valve discharges. -
Page 9: Section Iv - Start-Up Procedure
User Manual GAS-FIRED BOILER SECTION IV – OPERATIONS INSTRUCTIONS... - Page 12 © 2008 Heat Transfer Products, Inc. www.HTproducts.com LP-182 REV. 9/10/08...