GAS-FIRED BOILER PRODUCT AND SAFETY INFORMATION SPECIAL ATTENTION BOXES The following defined terms are used throughout this manual to bring attention to the presence of hazards of various risk levels or to important information concerning the product. DEFINITIONS DANGER DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.
• Do not use this boiler if any part has been under water. Immediately call a qualified service technician to inspect the boiler and to replace any part of the control system and any gas control that has been under water.
GAS-FIRED BOILER SECTION I – COMBUSTION AIR – PREVENTION OF CONTAMINATION WARNING If the Munchkin combustion air inlet is located in any area likely to cause or contain contamination, or if products, which would contaminate the air cannot be removed, the combustion air must be re -piped and terminated to another location.
Check combustion air inlet piping. SECTION III – MAINTENANCE PROCEDURES WARNING The Munchkin must be inspected and serviced annually, preferably at the start of the heating season, by a qualified service technician. In addition, the maintenance and care of the boiler...
T fitting on the assembly until water appears at the end of the drain line. WARNING You must make sure the condensate hose is securely fastened before restarting boiler. Do a final check to assure proper flow.
This discharge line must be installed by a qualified service technician or heating/plumbing installer in accordance with the Munchkin installation manual. The discharge line must be terminated so as to eliminate possibility of severe burns or property damage should the valve discharges.
GAS-FIRED BOILER SECTION IV – OPERATIONS INSTRUCTIONS .FOR YOUR SAFETY READ BEFORE WARNING: If you do not follow these instructions exactly, a fire or explosion may result, causing property damage, personal injury or loss of life. A. This appliance does not have a pilot. It is equipped with an ignition device which automatically lights the burner.