HUSTLER FasTrak 36 Manual page 23

Cap screw
FasTrak 36/42 shown
Figure 4-8
600643 02/06
Upper
control
lever
Verify safety start interlock system
Visually inspect unit for loose hardware
Lower control
and/or damaged parts
lever
Visually inspect tires
Check oil level, engine (1)
Clean air intake screen (4)
Clean foam element (4)
Check fuel level
Blades - sharpen & securely fastened
Discharge chute - securely in place &
in lowest position
Grease deck height pivots
Grease gauge wheel bearings
Change engine oil & filter (1) (3)
Clean cylinder and head fins (a)
Check battery connections
Check tire pressure with a gauge
Clean engine exterior (a)
Replace air cleaner paper element (4)
Clean and regap spark plugs (a)
Check pump and deck belt tension
& condition (5)
Check fuel and hydraulic lines (6)
Check fuel valve and grommet (6)
Tighten lug nuts on wheels (2)
Change fuel filter
Replace spark plugs
Change pump/motor
transmission oil & filter (7)
NOTES:
1.
2.
3.
4.
5.
6.
7.
REFERENCES:
a — Refer to Engine Owner's Manual
NOTE: After completing maintenance cycle (100 hours), repeat cycle.
23
FasTrak Maintenance Schedule
Refer to Fig. 4-9 & Fig. 4-10
WEEKLY OR
SERVICE AT
INTERVALS INDICATED
Prior to each use or every 4 hrs.
Prior to each use or every 4 hrs.
Prior to each use or every 4 hrs.
Initial oil change is after 5 hours of operation. Thereafter,
change oil after every 40 hours operation. Change more often
under dusty or dirty conditions and during hot weather periods.
Torque initially and after first 2 hours of operation.
Change engine oil filter per the engine manufacturer's
recommendations. Refer to Engine Owner's Manual for
recommendations and other maintenance items.
Service more often under dusty or dirty conditions.
Pump drive belt only - Inspect every 6 months or 100
hours and replace if worn or cracking is noticed. Otherwise,
replace every 200 hours or 2 years whichever comes first.
Check fuel line hoses, fuel valve and grommet for any cracks
or leaks
C-IZT only - Change the filter and oil using 20W50 motor oil.
ANNUALLY OR
50 100
HOURS HOURS
Prior to each use
Prior to each use
Prior to each use
Prior to each use
Prior to each use
Prior to each use
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
Every 200 hours or 2 years