Potential hazards associated with this vibratory roller operation injury. will be referenced with Hazard Symbols which appear throughout this manual, and will be referenced in conjunction with Safety Message Alert Symbols. PAGE 6 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
ALWAYS wear approved eye and hearing protection. This vibratory roller, other NOTE property, or the surrounding environment could damaged if you do not follow instructions. MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03) — PAGE 7...
. Rotating parts can cause injury if contacted. ■ DO NOT leave vibratory roller with engine running. Use chock blocks if parking vibratory roller on a grade. PAGE 8 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
■ DO NOT use food or plastic containers to dispose of hazardous waste. ■ DO NOT pour waste, oil or fuel directly onto the ground, down a drain or into any water source. MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03) — PAGE 9...
Figure 1 displays the operation and safety decals as they appear on the vibratory roller. Should any of these decals become damaged or unreadable, contact the Multiquip Parts Department for a replacement set. Figure 1. Operation and Safety Decals PAGE 10 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
Convenient tie-downs, front and rear. Scraper Bar. Drum sprinkler system. Handle folds to 90 degrees for storage and transport.. Figure 3. Lifting The Roller PAGE 14 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
NEVER! operate the roller on side NOTE slopes . The roller may tip over causing injury to personnel and Figure 4. Recommended Slope severe damage to the equipment MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03) — PAGE 15...
If the v-belt cover is not installed, the possibility exist that your hand may get caught between the v-belt and clutch, thus causing serious injury and bodily harm. PAGE 16 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
Page 17
Muffler – Used to reduce noise and emissions. engine. Recoil Starter (pull rope) – Type of engine starting method. Alternate type would be electric start (ignition key). MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03) — PAGE 17...
. If fuel spillage occurs, wipe up the spilled fuel completely to prevent fire hazards. NEVER! smoke around or near the roller. Figure 8. Oil Dipstick PAGE 18 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
CHECKING BOLTS, NUTS, AND SCREWS Check bolts, nuts, and screws on various parts of the machine, including the engine, for proper tightness. Figure 16. Open Fuel Cock PAGE 20 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
I f t h e e n g i n e d o e s n o t s t a r t , r e p e a t s t e p s 2 through 4. MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03) — PAGE 21...
Page 22
If any trouble is found, correct the problem before attempting to operate the roller again. Figure 23. Water Valves PAGE 22 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
Page 23
Doing so will damage the hydraulic system. NEVER perform unloading procedure on a slope. This may cause roller to roll down if parking brake or blocking is deficient. MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03) — PAGE 23...
Check the levers, cables and linkage. intervals based on the number hours vibratory Check engine oil. roller is in use, and particular working conditions. PAGE 24 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
2. Check the chain tension and if loose, adjust the chain tension with the tightener (Figure 27). Chain tension should be adjusted every 50 hours of operation. Figure 29. Clutch Adjustment MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03) — PAGE 25...
Page 26
Do not use objects do not enter tank. It is recommended to automobile-type oil filters. filter the oil through a cloth. PAGE 26 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
Page 27
1. Stop the engine and set the travel lever in the neutral position. Figure 36. Adjusting the Turn-Buckle 2. Unscrew the two lock nuts on the sides of the cable (Figures 34 and 35). MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03) — PAGE 27...
Page 28
Warm the battery to 15 degrees F or battery Figure 38. Battery Connection may explode. Replace the battery with the same or similar capacity battery or battery may explode. PAGE 28 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
. e k f l a i t c c e j . l a MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03) — PAGE 29...
Page 30
. e k f l a i t c c e j . l a PAGE 30 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
Page 31
. r o l i o r o t y l h h t i l e v v i s y l e MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03) — PAGE 31...
<, belong to the same assembly or kit If more than one of the same NOTE reference number is listed, the last one listed indicates newest (or latest) part available. PAGE 32 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
Page 84
YANMAR L100EE-DEVMK2 — STARTING MOTOR AND DYNAMO ASSY. STARTING MOTOR AND DYNAMO ASSY. PAGE 84 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
Multiquip’s designated receiving point. at the time of any price change. PAGE 88 — MQ-MIKASA MDR-9DYE VIBRATORY ROLLER — PARTS & OPERATION MANUAL — REV. #0 (12/19/03)
OPERATION AND PARTS MANUAL HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING MULTIQUIP’S MAIN PHONE NUMBERS 800-421-1244 FAX: 310-537-3927 310-537-3700 PARTS DEPARTMENT 800-427-1244 FAX: 800-672-7877 310-537-3700 FAX: 310-637-3284 MAYCO PARTS 800-306-2926 FAX: 800-672-7877...