Potential hazards associated with this vibratory roller operation injury. will be referenced with Hazard Symbols which appear throughout this manual, and will be referenced in conjunction with Safety Message Alert Symbols. PAGE 8 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Page 9
ALWAYS wear approved eye and hearing protection. This vibratory roller, other NOTE property, or the surrounding environment could damaged if you do not follow instructions. MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 9...
. Rotating parts can cause injury if contacted. ■ DO NOT leave vibratory roller with engine running. Use chock blocks if parking vibratory roller on a grade. PAGE 10 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Page 11
■ DO NOT use food or plastic containers to dispose of hazardous waste. ■ DO NOT pour waste, oil or fuel directly onto the ground, down a drain or into any water source. MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 11...
Figure 1 displays the operation and safety decals as they appear on the vibratory roller. Should any of these decals become damaged or unreadable, contact the Multiquip Parts Department for a replacement set. Figure 1. Operation and Safety Decals PAGE 12 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Page 13
NOTE PAGE MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 13...
Convenient tie-downs, front and rear. Scraper Bar. Drum sprinkler system. Handle folds to 90 degrees for storage and transport.. Figure 3. Lifting The Roller PAGE 14 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Page 15
NEVER! operate the roller on side NOTE slopes . The roller may tip over causing injury to personnel and Figure 4. Recommended Slope severe damage to the equipment MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 15...
If the V-belt cover is not installed, the possibility exist that your hand may get caught between the V-belt and clutch, thus causing serious injury and bodily harm. PAGE 16 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
10. Fuel Tank – Holds unleaded gasoline. For additional Fuel Valve Lever – OPEN to let fuel flow, CLOSE to stop information refer to engine owner's manual. the flow of fuel. MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 17...
Page 18
. If fuel spillage occurs, wipe up the spilled fuel completely to prevent fire hazards. NEVER! smoke around or near the roller. Figure 8. Oil Dipstick PAGE 18 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
CHECKING BOLTS, NUTS, AND SCREWS Check bolts, nuts, and screws on various parts of the machine, including the engine, for proper tightness. Figure 16. Engine Fuel Valve Lever PAGE 20 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Page 21
10 seconds before operating the starter again. The engine speed has been set at the factory. Changing the governor speed could damage the vibratory roller. MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 21...
Page 22
If any trouble is found, correct the problem before attempting to operate the roller again. Figure 24. Water Valves PAGE 22 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Doing so will damage the hydraulic system. NEVER perform unloading procedure on a slope. This may cause roller to roll down if parking brake or blocking is deficient. MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 23...
Page 24
Check the levers, cables and linkage. intervals based on the number hours vibratory Check engine oil. roller is in use, and particular working conditions. PAGE 24 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Page 25
DO NOT overfill. 5. Install drain bolt with sealing washer and tighten se- curely. Figure 28. Engine Air Filter Figure 27. Engine Oil (Draining) MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 25...
Page 26
4. Make sure that the shifting lever is not too stiff. Lever should engage with moderate pressure. 5. After adjustment, return the stop key to the locked position. Figure 30. Chain Tightener PAGE 26 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Page 27
Do not use objects do not enter tank. It is recommended automobile-type oil filters. to filter the oil through a cloth. MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 27...
Page 28
1. Stop the engine and set the travel lever in the neutral position. Figure 38. Adjusting the Turn-Buckle 2. Unscrew the two lock nuts on the sides of the cable (Figures 36 and 37). PAGE 28 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Page 29
When installing cable connect the ground side (normally may explode. negative) last. Replace the battery with the same or similar capacity battery or battery may explode. MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 29...
, #, +, %, or <, belong to the same assembly or kit The contents of this NOTE parts catalog are subject to change without notice. PAGE 34 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Page 89
NUT, SPECIAL 16MM (1) ......1 ..USE FROM ENGINE SN 2536523 90201ZE3790 NUT, SPECIAL 16MM ........1 ..USE UP TO ENGINE SN 2536522 90741ZE2000 KEY, SPECIAL WOODRUFF 25X18 MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 89...
Page 90
HONDA GX340K1QAE2 — FUEL TANK ASSY. FUEL TANK ASSY. PAGE 90 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Multiquip’s designated receiving point. at the time of any price change. PAGE 104 — MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03)
Page 105
NOTE PAGE MQ-MIKASA MDR-9GH VIBRATORY ROLLER — OPERATION AND PARTS MANUAL — REV. #0 (12/17/03) — PAGE 105...
OPERATION AND PARTS MANUAL HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING MULTIQUIP’S MAIN PHONE NUMBERS 800-421-1244 FAX: 310-537-3927 310-537-3700 PARTS DEPARTMENT 800-427-1244 FAX: 800-672-7877 310-537-3700 FAX: 310-637-3284 MAYCO PARTS 800-306-2926 FAX: 800-672-7877...