Table of Contents
Advertisement
Installation/Operator Manual
WARNING: For your safety the information
in this manual must be followed to
minimize the risk of fire or explosion and
to prevent property damage, personal
injury or death.
— Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
G
Do not touch any electrical switch;
G
do not use any phone in your
building.
Clear the room, building or area of
G
all occupants.
Immediately call your gas supplier
G
from a neighbor's phone. Follow
the gas supplier's instructions.
If you cannot reach your gas
G
supplier, call the fire department.
— Installation and service must be
performed by a qualified installer,
service agency or the gas supplier.
MLG33
AVERTISSEMENT: Assurez-vous de bien
suivre les instructions données dans cette
notice pour réduire au minimum le risque
d'incendie ou d'explosion ou pour éviter
tout dommage matériel, toute blessure ou
la mort.
—Ne pas entreposer ni utiliser d'essence
ni d'autres vapeurs ou liquides
inflammables à proximité de cet
appareil ou de tout autre appareil.
—QUE FAIRE SI VOUS SENTEZ UNE
ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareils.
G
Ne touchez à aucun interrupteur. Ne
G
pas vous servir des téléphones se
trouvant dans le bâtiment.
Évacuez la pièce, le bâtiment ou la
G
zone.
Appelez immédiatement votre
G
fournisseur de gaz depuis un voisin.
Suivez les instructions du fournisseur.
Si vous ne pouvez rejoindre le
G
fournisseur de gaz, appelez le service
des incendies.
—L'installation et l'entretien doivent être
assurés par un installateur ou un
service d'entretien qualifié ou par le
fournisseur de gaz.
INSTRUCTIONS IN A
FUTURE REFERENCE
RETAIN THESE
SAFE PLACE FOR
Part No. 113413 - 11
Advertisement
Table of Contents
Related Manuals for Maytag MLG33
Summary of Contents for Maytag MLG33
- Page 1 — Installation and service must be performed by a qualified installer, service agency or the gas supplier. MLG33 AVERTISSEMENT: Assurez-vous de bien suivre les instructions données dans cette notice pour réduire au minimum le risque d’incendie ou d’explosion ou pour éviter...
- Page 2 POUR VOTRE SÉCURITÉ Ne pas entreposer ni utiliser d’essence ni d’autres vapeurs ou liquides inflammables à proximité de cet appareil ou de tout autre appareil. IMPORTANT For your convenience, log the following information: Maytag Co. Benton Harbor, MI 1-800-662-3587 MLG33...
-
Page 3: Table Of Contents
State of California Proposition 65 Warnings: WARNING: This product contains a chemical known to the State of California to cause cancer. WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive harm. IMPORTANT You must disconnect and lockout the electric supply and the gas supply before any covers or guards are... -
Page 4: Safety Precautions
Safety Precautions ____________________ Warning For your safety, the information in this manual must be followed to minimize the risk of fire or explosion and to prevent property damage, personal injury, or loss of life. The dryer must never be operated with any of the back guards, outer tops, or service panels removed. - Page 5 Warning To reduce the risk of personal injury, install lockable doors to prevent public access to the rear of the dryers. Exhaust duct outlet should be checked periodically for blockages, and if any found, removed. Important A means of restraint must be used to prevent straining of the gas supply when the appliance is moved.
-
Page 6: Specifications
Specifications _______________________________________________________________________ MAXIMUM CAPACITY (DRY WEIGHT) PER POCKET TUMBLER DIAMETER TUMBLER DEPTH TUMBLER VOLUME PER POCKET TUMBLER/DRIVE MOTOR PER POCKET BLOWER/FAN MOTOR PER POCKET DOOR OPENING (DIAMETER) DOOR SILL HEIGHT TOP POCKET / BOTTOM POCKET WATER CONNECTION DRYERS PER 20’/40’ CONTAINER DRYERS PER 48’/53’... - Page 7 Specifications _______________________________________________________________________ 113413 - 11 Maytag Co.
-
Page 8: Installation Procedures
Installation Procedures _______________ Installation should be performed by competent professional in accordance with local, state, and country codes. In the absence of these codes, the installation must conform to applicable American National Standards: ANSI Z223.1-LATEST EDITION (National Fuel Gas Code) or ANSI/NFPA NO. 70- LATEST EDITION (National Electrical Code) or in Canada, the installation must conform to applicable Canadian Standards: CAN/CGA-B149.1-M91 (Natural Gas) or CAN/... -
Page 9: Fresh Air Supply Requirements
Fresh Air Supply Requirements _______ When the dryer is operating, it draws in room air, heats it, passes this air through the tumbler, and exhausts it out of the building. Therefore, the room air must be continually replenished from the outdoors. If the make-up air is inadequate, drying time and drying efficiency will be adversely affected. - Page 10 Outside Ductwork Protection To protect the outside end of the horizontal ductwork from the weather, a 90° elbow bent downward should be installed where the exhaust exits the building. If the ductwork travels vertically up through the roof, it should be protected from the weather by using a 180°...
-
Page 11: Electrical Information
Important No more than 4 dryers should be connected to 1 main common duct. The illustration below shows the minimum cross-sectional area for multiple dryer round or square venting. These figures must be increased if the main duct run from the last dryer to where it exhausts to the outdoors is longer than 12 feet (3.656 meters) or has more than 1 elbow in it. -
Page 12: Gas Information
Electrical Service Specifications Gas Models Only ELECTRICAL SERVICE SPECIFICATIONS (PER POCKET) NOTES: When fuses are used they must be dual element, time delay, current limiting, class RK1 or RK5 ONLY . Calculate/determine correct fuse value, by applying either local and/or National Electrical Codes to listed appliance amp draw data. -
Page 13: Gas Connections
Warning Fire or explosion could result due to failure of isolating or disconnecting the gas supply as noted. Note Undersized gas piping will result in ignition problems, slow drying, increased use of energy, and can create a safety hazard. The dryer must be connected to the type of heat/gas indicated on the data label and pressure must be confirmed. - Page 14 Heat Input/Gas Consumption/Orifice (Injector) Data (For Non-CE [European] Models Only) Gas Specifications for Non-CE Approved Gas Type and Nominal Heating Value B tu /ft Natural 1,000 *Liquid Propane 2,500 Shaded areas are stated in metric equivalents Gas valve’s internal regulator disabled. ** Information is per pocket/tumbler.
-
Page 15: Converting From One Family Of Gas To Another
Piping/Connections The dryer is provided with two 1/2” N.P.T. (3/8” B.S.P.T. for CE dryers) inlet pipe connections (1 for each tumbler) at the rear of the dryer. If a separate feed is provided for each tumbler from the main supply line (header), then a 1/2” (12.7 mm) line connection is sufficient. - Page 16 Remove 2 burner tube mounting screws and remove burner tube in order to gain access to the orifice. Using a 3/8” wrench or socket, remove the existing orifice and replace it with an orifice from the kit. Important Use extreme care when removing and replacing orifice (injector).
-
Page 17: Gas Pressure Testing
Reinstall the burner tube onto the burner base. If converting from unregulated gas, use a flat screwdriver, remove the cap with blocking pin and install the regulator vent cap from the kit. Install the gas train back into the dryer gas train enclosure. Be sure the tab at the rear of the gas train engages into the mounting slot. -
Page 18: Preoperational Test
Preoperational Test ___________________ All dryers are thoroughly tested and inspected before leaving the factory. However, a preoperational test should be performed before the dryer is publicly used. It is possible that adjustments have changed in transit or due to marginal location (installation) conditions. -
Page 19: Warranty Information
Note When ordering replacement parts from the Maytag distributor or the Maytag Co. be sure to give them the correct model number and serial number so that your parts order can be processed in an expeditious manner. Warranty Information _________________ Warranty For a copy of the manufacturer’s commercial warranty covering your particular dryer(s), contact the Maytag distributor... -
Page 20: Data Label Information
Data Label Information _____________________________________________________________ Standard Label CE Label When contacting Maytag, the information on the data label is required to ensure proper service/parts assistance. The data label is located at the upper left rear of the dryer behind the back guard. 1. - Page 21 NOTES _____________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ ____________________________________________________________________________________________ 113413 - 11 Maytag Co.
- Page 22 Part No. 113413 11 - 01/15/09 - 10...