GSM TELEPHONE SGH-E360 CONTENTS GSM TELEPHONE Specification Circuit Description Exploded Views and Parts List Electrical Parts List Block Diagrams PCB Diagrams Flow Chart of Troubleshooting...
Page 2
ⓒ Samsung Electronics Co.,Ltd. December. 2005 This Service Manual is a property of Samsung Electronics Co.,Ltd. Any unauthorized use of Manual can be punished under applicable Printed in Korea. International and/or domestic law. Code No.: GH68-08968A BASIC.
5pcl ~ 19pcl 0pcl ~ 15pcl 0pcl ~ 15pcl Sensit ivit y - 102dBm -102dBm - 100dBm - 100dBm TDMA Mux Cell Radius 35Km 35Km SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...
8±4dBm 9±5 dBm 6±4 dBm 6±4 dBm 7±5 dBm 4±4 dBm 4±4 dBm 5±5 dBm 2±5 dBm 2±5 dBm 0±5 dBm 0±5 dBm SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...
Page 5
9±5 dBm 12±4 dBm 12±4 dBm 7±5 dBm 10±4 dBm 10±4 dBm 5±5 dBm 8±4dBm 8±4dBm 6±4 dBm 6±4 dBm 4±4 dBm 4±4 dBm SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...
Page 6
Specification SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...
LO suppression, quadrature phase error, quadrature amplitude balance and low noise floor specification. Output matching/balun components drive a standard 50 ohms single ended load. SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...
The Backlight Brightness Modulator (BBM) contains a programmable Pulse-width modulator (PWM) and FET to modulate the intensity of a series of LED’ s or to control a DC/DC converter that drives LCD backlight. This phone (SGH-E360) use PWM control to contrast the backlight brightness. - Clock Generator The Clock Generator (CG) generates all clocks for internal and external usage.
Page 9
There is Stereophonic analog output for Headphone. 2-2-9. Memory(UME301) This system uses Samsung's memory, KAP17SG00A. The KAP17SG00A is a Multi Chip Package Memory which combines 256Mbit Synchronous Burst Multi Bank NOR Flash Memory and two 512Mbit OneNAND Flash and 128Mbit Synchronous Burst UtRAM.
Page 10
90 MHz) to IF.Preset tuning to receive Japanese TV audio up to 108 MHz, raster 100 kHz. and is connected to PCF5213EL1 of I2C. SAMSUNG Proprietary-Contents may change without notice This Document can not be used with out Samsung' s authorization...
Page 11
QKP01 QME03 QCW02 QVK01 QMP01 QFU01 QME01 QMI01 QCR12 QAN05 QAN02 QCA01 QLC01 QRF03 QMO01 QSP01 QRE01 QRF01 QFL01 QIF01 QCR21 QCR11 QSC01 QMW02 QBA01 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
UNIT-VOLUME KEY GH59-02397A QVO01 MEC-VOLUME KEY GH75-07170A QRE01 MEC-REAR COVER GH75-08050A QRF03 PMO-EAR COVER V2 GH72-23676A QMI03 MEC-RUBBER MIC GH75-08856A SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 13
MPR-TAPE E KEYPAD GH74-19886A MPR-SPONGE MOTOR GH74-19887A MPR-TAPE E LCD L GH74-19888A MPR-SPONGE IF CONN GH74-19913A MPR-TAPE F/UPPER HOLE GH74-19914A MPR-BOHO VINYL SET GH74-19916A MEC-HAND STRAP GH75-03207A SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 14
3-3-2. RF Test Cable 3-3-3. Test Cable 3-3-4. Serial Cable (GH39-00283A) (GH39-00337A) (CSA LL64151-A) 3-3-5. Power Supply Cable 3-3-7. TA 3-3-6. DATA CABLE (GH44-00482A) (GH39-00331A] SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
2203-000812 C207 C-CER,CHIP 2203-005482 C208 C-CER,CHIP 2203-005482 C209 C-CER,CHIP 2203-005482 C210 C-CER,CHIP 2203-005482 C211 C-CER,CHIP 2203-005482 C212 C-CER,CHIP 2203-005482 C213 C-CER,CHIP 2203-005482 C214 C-CER,CHIP 2203-000812 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 16
2203-006208 C420 C-CER,CHIP 2203-005482 C422 C-CER,CHIP 2203-006208 C423 C-CER,CHIP 2203-006208 C424 C-CER,CHIP 2203-006257 C425 C-CER,CHIP 2203-006257 C501 C-CER,CHIP 2203-002443 C502 C-CER,CHIP 2203-006399 C503 C-CER,CHIP 2203-000812 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 17
3710-001994 L105 INDUCTOR-SMD 2703-002281 L106 INDUCTOR-SMD 2703-002314 L108 INDUCTOR-SMD 2703-002313 L109 INDUCTOR-SMD 2703-002309 L110 INDUCTOR-SMD 2703-002485 L111 INDUCTOR-SMD 2703-001752 L112 INDUCTOR-SMD 2703-002267 L114 BEAD-SMD 3301-001729 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 18
2007-000932 R115 R-CHIP 2007-000171 R116 R-CHIP 2007-000140 R117 R-CHIP 2007-001288 R118 R-CHIP 2007-001313 R119 R-CHIP 2007-001313 R120 R-CHIP 2007-000171 R121 R-CHIP 2007-000171 R122 R-CHIP 2007-000171 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 19
2007-000162 R507 R-CHIP 2007-000152 R508 R-CHIP 2007-000170 R509 R-CHIP 2007-000170 R510 R-CHIP 2007-007573 R511 R-CHIP 2007-000137 R512 R-CHIP 2007-007334 R513 R-CHIP 2007-000164 R514 R-CHIP 2007-000156 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 20
C-TA,CHIP 2404-001394 TA601 C-TA,CHIP 2404-001402 TAC701 SWITCH-TACT 3404-001152 U102 IC-TRANSCEIVER 1205-002817 U300 IC-MELODY 1204-002161 U301 IC-CMOS LOGIC 0801-003022 U302 IC-CMOS LOGIC 0801-003025 U305 FET-SILICON 0505-001923 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 21
0403-001547 ZD501 DIODE-ZENER 0403-001427 ZD502 DIODE-TVS 0406-001150 ZD600 DIODE-TVS 0406-001190 ZD601 DIODE-TVS 0406-001104 ZD602 DIODE-TVS 0406-001104 ZD701 DIODE-TVS 0406-001150 ZD702 DIODE-TVS 0406-001150 ZD703 DIODE-TVS 0406-001150 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 22
Electrical Parts List SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
PGMDIV SWON MATCHING BALUN 50/900 NETWORK FESW1 FRONT FESW2 SWITCHES FESW3 MATCHING BALUN PCS1900 NETWORK VDDL TXVCC CTRL POWER EN UAA3587E UAA3587G DATA CLK EN SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Block Diagrams 5-2. Base Band Solution Block Diagram SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
6. PCB Diagrams 6-1. PCB Top Diagram SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
PCB Diagrams 6-2. PCB Bottom Diagram SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Check the +VDD_GSM_CORE circuit = 1.8V? Check for the clock at C304 Check the clock generation circuit (related to U302) = 26MHz Check the initial operation SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 28
RSTON C304 C304 R302 R302 1 NC 1 NC VCC 5 VCC 5 IT_PMU SIMIO 26M_CLK 26M_CLK R303 R303 R304 R304 OUTY OUTY 26M_DIGIT 26M_DIGIT SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 29
U305 pin 4 (RSTON) ="H" Check the circuit related to reset Is UCP200 R206, R207 Check the UCP200 Check the 16bit data signal & memory CE SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 30
TP223 TP224 JTAG TP225 TRCSYNC TP226 TRCCLK TP227 RSTON TP229 +VDD_IO_LOW TP228 R214 R215 +VDD_IO_LOW +VDD_IMAGE +VDD_IO_HIGH +VDD_IO_LOW R309 U305 R310 LCD_RESET RSTON S_RST S_RST_IMAGE SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 31
Flow Chart of Troubleshooting SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Resolder or replace U502 Check the circuit related to U502 pin 3 = "L"? AUX_ON signal Check the U502 pin 10 Resolder or replace U502 ≒ 4.2V SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
C504 R512 CRDL 2 USB ICDL 9 +VBUS _PPR AUX_ON 4 _CHG USBON END_OF_CHG USB_CHG_ON 5 _EN IMIN 6 CHG_ON C507 R514 R515 BATTERY CHARGING SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Check SIMCLK Signal on Check the Clock pin3 of SIM400 in a few After SIM card insert, Replace PBA SIM400 pin 2 = "H(SIM_RST)"? Check the SIM Card SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 35
GND 49 +AVDD_HFA _REC2 GND 51 NC 53 C422 TP401 +VDD_IO_HIGH AUX_ON C423 C424 32KHz_DIGIT PON_TX +VDD_IO_LOW REF_ON SIMRST C425 SIMCLK R405 MIC_BIAS RSTON IT_PMU SIMIO SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
L601,L602 from UCP200 to MIC Check R609, R610 PIN 1 Check the JACK_EN signal = ' H' ? Check the MIC Replace the MIC 7-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 37
R603 C602 MIC_CP C603 L601 C604 MIC600 MIC_P R605 C605 C606 C607 MICROPHONE MIC_N L602 R606 JACK_EN C608 R609 C609 R610 C611 R607 ZD600 7-11 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 38
Resolder U300 (When U300 operate) Check the board to board Check LCD MODULE SPK+, SPK- Connector = Operate Is Speaker working? Change the Speaker 7-12 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 39
MELODY_SEL R_CONTROL SPOUT1 C305 VREF AMP_N AMP_P C308 C307 C306 COM2 SPK_N VBAT C312 C309 C310 R306 C311 R307 EARP_HF R308 C313 MELODY IC 7-13 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 40
Flow Chart of Troubleshooting 7-14 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Isn't it displayed on LCD? When one of the keys is pushed, Resolder ZD701,702,703 & Replace the PBA KEY_ROW(0,4), KEY_COL(0,4) signal is OK? 7-15 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 42
FLIP KEY_ROW(2)_M KEY_ROW(2) KEY_ROW(2)_K END_KEY VR714 VR713 V_UP KEY_ROW(3) V_DOWN KEY_ROW(4) TAC701 V_COMMEN KEY_COL(1) V_GND KEY_COL(0) KEY_ROW(3) ZD701 ZD702 ZD703 VR711 VR712 VOLUME_KEY CAMERA_KEY 7-16 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 43
Flow Chart of Troubleshooting 7-17 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Change the Board to Board Connector SPK +,- PAD = 1.5V? Check the soldering of the Modify the speaker wire soldering spaeaker wire Is Receiver working? Replace the Speaker 7-18 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 45
Flow Chart of Troubleshooting Typical 3.7V VBAT COM4 U604 HFR_P IN1/IN2 IN3/IN4 MELODY_SEL R_CONTROL AMP_N COM2 SPK_N 7-19 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 46
U2 pin 1 = H ? Connector Check the U2 & the related circuit U2 PIN 6 ≥ Vbat ? Replace the LCD Module 7-20 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 47
Flow Chart of Troubleshooting LED1 LED2 LED3 VBAT VDD_IO_HIGH LCD_BL_ON CTRL0 CTRL1 CTRL2 LED+ DIM_EN 7-21 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
R702 R703 R704 R705 R706 R707 R708 R709 2.2UF R710 R711 R712 LED710 LED711 LED712 LED709 LED705 LED703 LED704 LED707 LED708 LED701 LED702 LED706 7-22 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 49
Flow Chart of Troubleshooting 7-23 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Check the U400 ( or IC5) Check U302(pin2, pin4) related to C304 = 26MHz? 26Mhz and R303 Is there another problem? Replace the camera module 7-24 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 51
Flow Chart of Troubleshooting VDD_IO_HIGH LCD_RESET LCD_RS LCD_SUB_CS LCD_WR 7-25 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 52
Flow Chart of Troubleshooting 7-26 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 53
Insert the Earphone or Change the Check the Insert Earphone Earphone R733 = 2.8V Check the U725 U725 TP606 = 'H' Check UCP200 Replace the U725 7-27 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 54
FMIP LOUT 16 TP602 RFGND C630 U725 TP603 FMIN ROUT +VDD_IO_HIGH GND 14 R736 C731 6 GND VD 13 R732 BUSENABLE R730 C729 C730 7-28 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 55
Flow Chart of Troubleshooting 7-13. BLUETOOTH BLUETOOTH does not work Check the UCP200 C316 = 'H' Replace MOD301 Replace ANT300 7-29 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 56
6 PIO_4 PCM_CLK PCM_IN 18 PIO_5 8 SPI_MOSI PCM_SYNC SPI_CLK PCM_OUT 16 10 SPI_CSB BT_RST RESETB SPI_MISO 12 14 26 24 MOD301 BLUE TOOTH 7-30 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Check & Resolder Check U102 U102 pin7,8,9,10 U102, R108 R107 pin28,pin31>=2.7V >= 1V RF26MHz, RF PSU Part Resolder U102 C140, C141 >= 1V Check UCP200 7-31 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Check U102 Check & Resolder U102 pin7,8,9,10 pin28,pin31 >=2.7V U102, R108 R107 >= 1V RF26MHz, RF PSU Part Resolder U102 Check UCP200 7-32 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Check & Resolder Check U102 U102 pin7,8,9,10 U102, R108 R107 pin28,pin31 >=2.7V >= 1V RF26MHz, RF PSU Part Resolder U102 C140, C141 >= 1V Check UCP200 7-33 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Check U102 Check & Resolder U102 pin7,8,9,10 pin28,pin31 U102, R108 R107 >= 1V >=2.7V RF26MHz, RF PSU Part Resolder U102 Check UCP200 7-34 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Check & Resolder Check U102 U102 pin7,8,9,10 U102, R108 R107 pin28,pin31 >=2.7V >= 1V RF26MHz, RF PSU Part Resolder U102 C140, C141 >= 1V Check UCP200 7-35 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Check U102 U102 pin7,8,9,10 Check & Resolder pin28,pin31 >= 1V U102, R108 R107 >=2.7V RF26MHz, RF PSU Part Resolder U102 Check UCP200 7-36 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 63
Flow Chart of Troubleshooting 7-37 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 64
Flow Chart of Troubleshooting 7-38 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...