Frigidaire 240389636 Service Data Sheet

pERFORMANCE dATA
NO LOAd ANd NO dOOR OpENiNGs AT Mid-pOiNT CONTROL sETTiNG
Type A with Run/Start Capacitor 65ºF (18ºC) Ambient
Operating Time 32 to 40%
Freezer Temperature 0º to 4ºF
-18º to -16ºC
Refrigerator Temperature 34º to 39ºF
1º to 4ºC
Low Side Pressure (cut-in) 5 to 12 psig
34 to 83 kPa
Low Side Pressure (cut-out) -2 to 2 psig
-14 to 14 kPa
High Side Pressure 90 to 115 psig
(Last 1/3 of cycle) 621 to 793 kPa
Wattage (Last 1/3 of cycle) 120 to 150
Amps (Running) 1.2 to 1.5
Base Voltage 115 vac (127 vac max)
dEFROsT spECiFiCATiONs
Thermostat
Cabinet Size
Cut-In Cut-Out
23' & 26' 25ºF 47ºF
-4ºC 8ºC
Electronic Timer - (ADC) Defrost 24 minutes every 6 to 72 hours of compressor run time
CONdENsER FAN MOTOR
Watts RPM
3.1 (Energy Star - Some models) 1100 CW Opposite Shaft
8.0 2550 CW Opposite Shaft
iCE MAKER spECiFiCATiONs
Electrical 115 vac (127 vac max)
Thermostat Opens at 48ºF (9ºC)
Heater Wattage 165
iCE MAKER pLuG CONNECTiONs
Wire Number Wire Color
1 Green/Yellow
2 Yellow
3 Black
4 Lt. Blue
sERViCE dATA shEET - 240389636
90ºF (32ºC) Ambient
ICE & WATER - AUTOMATIC DEFROST
55 to 65%
SIDE BY SIDE MODELS
-1º to 3ºF
-18º to -16ºC
iMpORTANT sAFETy NOTiCE
34º to 39ºF
1º to 4ºC
The information provided herein is designed to assist qualified
5 to 12 psig
repair personnel only. Untrained persons should not attempt to
34 to 83 kPa
make repairs due to the possibility of electrical shock. Disconnect
-2 to 2 psig
power cord before servicing.
-14 to 14 kPa
130 to 155 psig
iMpORTANT
896 to 1069 kPa
If any green grounding wires are moved during servicing, they
130 to 160
must be returned to their original position and properly se-
1.2 to 1.5
cured.
115 vac (127 vac max)
CAuTiON:
Heater
shielded from torch flame. do not allow torch to contact
Watts Ohms
insulation; it will char at 200°F and flash ignite (burn) at
450 30
500°F. Excessive heat will distort the plastic liner.
NOTE:
This product comes equipped with an Electronic
Amps
Defrost Control. To initiate defrost, depress the fresh food light
.03 Running
switch 5 times in 6 seconds (light bulb must be working). To
.07 Running
terminate defrost, depress the fresh food light switch 5 times
in 6 seconds.
60 Hertz
Closes at 15ºF (-9ºC)
Connect to:
Ground
Water Valve
Line
Neutral
R134a
All electrical parts and wiring must be
iCE MAKER iNFORMATiON
Test Cycling
Remove cover by inserting screwdriver in notch at bottom and
prying cover from housing. Use screwdriver to rotate motor gear
counterclockwise until holding switch circuit is completed. All
components of ice maker should function to complete the cycle.
Water Fill
Adjustment
Motor
Gear
Mounting
Plate
Screws
Mounting
Plate
Screw
Timing
Gear
LINE POWER
ICE MA KER
B LK BRN
P-3
THER MAL
CUT-OUT
MOTOR
HO LD
SW ITCH
RED
T HERMOSTAT
BLK
MOLD HEATER
GRN / yEL
P-1
WATER FILL
MOL D
MOUN TING
S WITCH
PLATE
MAKER ICE
Water Fill Volume
The water fill adjustment
screw will change the
fill time. One full turn is
equal to 20cc (.68 oz.).
The correct fill is 102 to
130cc (3.4 to 4.3 oz.).
When a water valve is
replaced, the fill volume
must be checked.
NEUT RAL
YEL
P-4
BLU
SHUT-OF F
SWITCH
LT. BLU
P-2