Page 1
OPERATOR'S MANUAL MANUEL D'UTILISATION BEDIENUNGSANLEITUNG MANUALE ISTRUZIONI PAS Trimmer Attachment ENGLISH MODEL 99944200840 FRANCAIS DEUTSCH ITALIANO WARNING, SEE OPERATOR'S MANUAL LÌRE SOÌGNEUSEMENT CE MANUEL AVANT TOUTE UTÌLÌSATÌON ACHTUNG! BEDIENUNGSANLEITUNG LESEN ATTENZIONE, LEGGERE IL MANUALE ISTRUZIONI X770000151 X7702271902 07/04...
NTRODUCTION Welcome to the ECHO family. This ECHO product was designed and manufactured to provide long life and on-the-job- dependability. Read and understand this manual and the SAFETY MANUAL you found in the same package. You will find both easy to use and full of helpful operating tips and SAFETY messages.
"DESCRIPTION" section, will help you locate them. Make sure the decals are legible and that you understand and follow the instructions on them. If a decal cannot be read, a new one can be ordered from your ECHO Dealer. P/N 89018623760 Shaft Decal...
Proper clothing and safety gear must be worn when operating a trimmer/brush cutter. Physical Condition Hearing Protection Your judgment and physical dexterity may not be good: ECHO recommends wearing hearing protection whenever • if you are tired or sick, unit is used. • if you are taking medication, Proper Clothing •...
Use only ECHO approved attachments. Serious injury may result from the use of a non-approved attachment combination. ECHO, INC. will not be responsible for the failure of cutting devices, attachments or accessories which have not been tested and approved by ECHO. Read and comply with all safety instructions listed in this manual and safety manual.
• Keep exhaust area clear of flammable debris. Avoid contact during and immediately after operation. ESCRIPTION After opening the carton, check for damage. Immediately notify your retailer or ECHO Dealer of damaged or missing parts. Use the contents list to check for missing parts. CONTENTS...
PAS T RIMMER TTACHMENT PERATOR ANUAL 1. LOWER DRIVE SHAFT ASSEMBLY - Includes the Debris Shield Assembly, Gear Housing assembly, Flexible Drive Cable, Nylon Cutter Head and Safety Decals. 2. PLASTIC DEBRIS SHIELD ASSEMBLY - Included in plastic bag (co-pack). MUST be installed on unit before use, see Assembly Instructions.
SSEMBLY POWER HEAD SHAFT LOWER SHAFT ASSEMBLY Tools Required: None Parts Required: PAS or SRM-SB Power Head w/Shaft & Coupling. 1. Set Power Head/Shaft Assembly on a level surface. 2. Pull locator pin (A) out, and turn counter-clockwise 1/4 turn to lock- out position.
PAS T RIMMER TTACHMENT PERATOR ANUAL PLASTIC SHIELD INSTALLATION (For Nylon Line Operation) Tools Required: Screwdriver. Parts Required: Plastic Shield, Shield Plate, three (3) 5 mm x 15 mm screws. NOTE The plastic shield is for use with the Nylon Line Head only. 1.
ECHO Service Dealer for maintenance. To help you decide whether you want to DO-IT-YOURSELF or have the ECHO Dealer do it, each maintenance task has been graded. If a task is not listed, see your ECHO Dealer for repairs.
PAS T RIMMER TTACHMENT PERATOR ANUAL LUBRICATION Level 1. Tools Required: 8 mm Open End Wrench, Screwdriver, Clean Rag Parts Required: Lithium Base Grease. Gear Housing Clean all loose debris from gear box. Remove plug (A) and check level of grease. Add grease if necessary, DO NOT over fill.
NYLON LINE REPLACEMENT Level 1. Parts Required: ECHO 0.095 in. Nylon Trimmer Line 6 m (20 ft.) long. 1. Shut engine off. Lay unit on the ground with head assembly up. 2. Hold drum (A) and turn spool (B) CW (clockwise) until it stops.
Page 13
PAS T RIMMER TTACHMENT PERATOR ANUAL 5. Stop when approximately 15-20 cm (6-8 in.) line (C) remains and place ends of line in notches (F) in spool (B). 6. Feed ends of line through housing eyelets (G) and place spool (B) over drive (H).
KIORITZ CORPORATION 7-2 SUEHIROCHO 1-CHOME OHME ; TOKYO 198-8711 JAPAN declares that the hereunder specified new unit: PRO ATTACHMENT SERIES Brand : ECHO Type : PAS-2400 assembled by: ECHO, INCORPORATED 400 Oakwood Road Lake Zurich, Ilinois 60047-1564 U.S.A. complies with:...
Page 15
PAS T RIMMER TTACHMENT PERATOR ANUAL NOTES...
Page 16
K I O R I T Z C O R P O R A T I O N 7-2 SUEHIROCHO 1-CHOME, OHME, TOKYO, 198-8711, JAPAN PHONE: 81-428-32-6118 FAX: 81-428-32-6145 ECHO, INCORPORATED 400 O AKWOOD , IL 60047 URICH X770-000 151...