Table of Contents
Advertisement
Problem
Problem
Vehicle runs sluggishly (cont.)
Sometimes the vehicle doesn't
run, but other times it does
When the foot pedal is pressed,
the vehicle won't run without
a push
Battery's thermal fuse constantly
"trips", but the vehicle is not
overloaded nor the driving
conditions too severe
Loud clacking or grinding
noise from a motor-gearbox
Charger gets warm during use
Battery makes a sizzling or
gurgling noise when charging
If, after reviewing the Problems and Solutions Guide, the vehicle still fails to operate, please contact your nearest authorized
service center (see page 27) or contact Power Wheels
Problems and Solutions Guide
Possible Cause
Possible Cause
Battery needs charging
Battery is old and will not accept
accept full charge
Vehicle is overloaded
Driving conditions are too stressful
Loose wire or connector
Motor or electrical switch damage
Loose wire or connector
"Dead Spot" on motor
Damaged battery
Child is switching between
FORWARD and REVERSE
without stopping
Broken gears
It is normal for some chargers to get
warm during use and is not reason
for concern. Some chargers do not
get warm during use.
It is normal for some batteries to
make noise and swell slightly while
charging and is not reason for concern.
®
Consumer Relations toll-free at 1-800-348-0751.
Be sure to charge the battery after each use.
Even with proper care, a rechargeable battery does not
last forever. Average battery life is 1 to 3 years depending
on vehicle use and use conditions. Replace only with a
Power Wheels
®
6 Volt battery with A-style connector and built-in
thermal fuse. Do not substitute parts.
Make sure you do not overload the vehicle by allowing
more than one rider at one time, exceeding the 65 lb.
maximum weight capacity, or by towing objects behind the
vehicle. If the vehicle is overloaded, the built-in thermal fuse in
the battery may "trip", and automatically shut down operation of
the for approximately 25 seconds. Adjust the driving conditions
to prevent repeated automatic shutdowns.
Use only on generally level ground.
Check all wires around the motors and all connectors to
make sure they are tight.
Contact your local Power Wheels
center for diagnosis and repair.
Check all wires around the motors and all connectors
to make sure they are tight.
Contact your local Power Wheels
center for diagnosis and repair.
Contact your local Power Wheels
center for diagnosis and repair.
Teach your child to stop the vehicle before switching
direction.
Contact your local Power Wheels
center for diagnosis and repair.
No action required.
If your charger does not get warm during
use, it does not mean that it is not working properly.
No action required.
If your battery does not make noise or swell slightly
during charging, it does not mean that it is
not accepting the charge.
26
Solution
Solution
®
authorized service
®
authorized service
®
authorized service
®
authorized service
Advertisement
Table of Contents
