Power vented gas models with hot surface ignition, for potable water heating only, not suitable for space heating, not for use in mobile homes, 40/50 gallon natural (36 pages)
Page 1
>, Owners Manual FOR POTABLE WATER HEATING ONLY NOT SUITABLE FOR SPACEHEATING. FOR USE ONLY ECONOMIZER MOBILE HOMES Model No, MOBILE HOME MODEL NUMBERS: WATER HEATER 153.333831 30 Gal. 153.333931 40 Gal. • Care and Maintenance • Safety Instructions • Installation •...
Safety Precautions AWARNING AWARNING Improper installation, adjustment, alteration, service or At the time of manufacture this water heater was provided maintenance can cause DEATH, SERIOUS BODILY with a combination temperature-pressures relief valve certified by a nationally recognized testing laboratory that maintains INJURY, OR PROPERTY DAMAGE.
Page 3
Safety Precautions A, WARNING &WARNING A gas water heater cannot operate properly without the cor- This water heater must not be installed directly on carpeting. rect amount of air for combustion. Do not instaJIin a confined Carpeting must be protected by a metal or wood panel area such a closet, unlessyou provide air as shown in the "Facts beneath the appliance extending beyond the full width and...
Safety Precautions _,CAUTION A, WARNING WATER HEATERS EVENTUALLY LEAK: Installationof the The water heater with draft hood installedmust be properly water heater must be accomplished in sucha manner that if vented to a chimneywhichterminatesoutdoors.Never oper- ate the water heater unless it isventedto the outdoors and has the tank or any connections shouldleak,the flow of water will adequateair supply to avoidrisksof improperoperation,explo- not causedamageto the structure.When suchlocations can-...
Table of Contents Safety Precautions ....................Table of Contents ....................Customer Responsibilities ..................Product Specincations ..................Materials and Basic Tools Needed ............... Materials Needed ..................................Basic Tools ....................................Installation Instructions ....................8-,8 Removing the Old Water Heater ............................... Facts to Consider About the Location ..........................9-10 Securing Water Heater to Floor and Wall ..........................
Customer Responsibilities This manual contains instructions for the installation, opera- Thank for purchasing water heater. a Sears tion, and maintenance of the gas-fired water heater. It also Properly installed and maintained, it should give you years of contains warnings through out the manual that you must trouble free service.
Materials and Basic Tools Needed Materials Needed To simplify the installation Sears has available the installation parts shown below. You may or may not need all of these materi- als, depending on your type of installation. WATER HEATER STAND 24"x24"x 18" FOR USE WITH WATER HEATERS INSTALLED...
Installation Instructions Removing the Old Water Heater Turn "OFF" the gas supply to the water heater. Disconnect the vent pipe from the draft hood where they connect to the water heater. In most installations the vent pipe can be lifted off after any screw or other _,WARNING attached devices...
Page 9
Installation Instructions (cont'd) Facts to Consider About the Location Whether replacing an old water heater or putting the water INSTALLATION METHOD B: An optional enclosure heater in a new location, the following critical points must be incorporating a solid exterior access door, when a 5" or 8" diame- observed.
Installation Instructions (cont'd) Facts to Consider About the Location (cont'd) AWARNING AWARNING Minimum clearances between the water heater and com- Toxic chemicals such as used for treatment of boilers or non- ] bustible construction are I" at the sides and roar, 4" at the potable water heating appliancesshallnever be introduced into front, and 6"...
Installation Instructions (cont'd) Securing Water Heater Water Piping Floor and Wall AWARNING The water heater must be secured to the floor and to the wall HOTTER WATER CAN SCALD:Water heatersare intended to of the enclosure with the three mounting brackets and screws _roducehot water.
Installation Instructions (cont'd) Water Piping (cont'd) WATER PIPING PRESSURE TEST • Look at the top cover of the water heater. The water outlet is marked hot. Put two or three turns of teflon tape around the This section is only for the mobile home matnufacturer installing threaded end of the I:hreaded-to-sweat coupling and around the water heater when the installation is to comply with H.U.D.
Installation Instructions (cont'd) Temperature-Pressure Relief Valve &WARNING AWARNING At the time of manufacture this water heater was provided The temperature-pressure relief valve must be manually with a combination temperature-pressures relief valve certified operated at least once a year. Caution should be taken to by a nationally recognized testing laboratory that maintains ensure that (I) no one is in front of or around the outlet of _riodic inspection of production of listed equipment or mate-...
Installation Instructions (cont'd) Filling the Water Heater A WARNING A CAUTION To insure proper venting of this gas-fired water heater, the Never use this water heater unless it is completely filled with correct vent pipe diameter must be utilized. Any additions or water.
Installation Instructions (cont'd) Venting (cont'd) _WARNING A, WARNIN Chemical vapor corrosion of the flue and vent system The appliance and its.,_.n must be leak tested may occur if air for combustion contains certain chemical before placing the apphance in operation. vapors.
Page 16
Installation Instructions (cont'd) "Fuel" Conversion Instruc- Step 9. Set the thermostat to lowest setting tions From Natural Gas To by turning the water temperature dial clockwise, (/_-'_) to its lowest Propane (L.P.) Gas temperature setting (with arrow on dial) as shown. DO NOT FORCE.
Installation Instructions (cont'd) "A" GAS ( Step 20. At arm's length away, set the thermostat to desired set- KNOB ting. The mark (V) HOT indicative of approx. 120°F is preferred starting point. If hotter water is desired see the "Temperature Regulation"...
Installation Instructions (cont'd) Installation Checklist BEFORE LIGHTING THE PILOT: • Check the gas lines for leaks. a. Use a soapy water solution. DO NOT test for gas leaks VENT PIPE TO UL usinga match or open flame. _ LISTED ROOF JACK b.
Operating Instructions Lighting AWARNING BEFORE LIGHTING [PROPANE (L.P,) GAS WATER HEATERS]:Propane(I-R) gasisheavierthan air. Shouldthere be a leak in the system,the gaswill settle near the ground. Basements,crawl spaces, s kirted areas under mobile homes (evenwhenventilated), c losets and areasbelowgroundlevelwill serve as pockets for the accumulation of this gas. Before attemptingto light or relight the water heater's pilot or turning on a nearbyelectricallightswitch,be absolutely surethere isno accumulated gasin the area.Searchfor odorof gasbysniffing at...
Page 20
Operating Instructions (cont'cl) Lighting label on the water heater as it appears above the thermostat FOR YOUR SAFETY READ BEFORE LIGHTING WARNING If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life, A.
Operating Instructions (cont'd) Temperature Regulation Due to the nature of the typical gas water heater, the water tem- Turn the water temperature dial clockwise_"x,) to decrease the temperature, or counterclockwise (€"- ",,) to increase the _oerature in certain situations may vary up to 30°F higher or wet at the point of use such as, bathtubs, showers, sink, etc.
Service and Adjustment Tank (Sediment) Cleaning Sediment build-up on the tank bottom may create varying At least once a year a visual inspection should be made of the amounts of noise, and if left in the tank will cause premature main burner and pilot burner.
Service and Adjustment (cont'd) Drain Valve Washer Temperature-Pressure Relief Replacement Valve Operation NOTE: For replacement, use a _7_" x 'Y_"x V," thick washer The temperature-pressure relief valve must be manually operated available at your nearest hardware store. For ordering replace- at least once a year.
Troubleshooting Guide Start Up Conditions THERMAL EXPANSION WATERHEATER COLD COLDWATER INLETFITTING PRESSURE Water sup3plly system_, may, because of such events as high line REDUCING pressure, frequent cut-offs, the effects of water hammer among VALVE WITH others, have installed devices such as pressure reducing valves, BY-PASS check valves, back flowpreventers, etc...to control these types of...
Troubleshooting Guide (cont'd) Start Up Conditions (cont'd) SMOKE/ODOR CONDENSATION Whenever the water heater is filled with cold water, a certain It is not uncommon to experience a small amount of smoke and amount of condensation will form while the burner is on.
Troubleshooting Guide (cont'd) HIGH TEMPERATURE SHUT SYSTEM WATER IS TOO This water heater is equipped with an automatic gas shut offsys- • The temperature adjustment dial may be set too high. See the tern. The high temperature shut off is built into the gas control "Temperature Adjustment"...
Troubleshooting Guide (cont'd) Leakage Checkpoints Use this guide to check a "Leaking" water heater. Many suspect- A CAUTION ed "Leakers" are not leaking tanks. Often the source of the water can be found and corrected. Read this manual first. Then before checking the water heater make sure the gas supply...
Parts Order List THE ECONOMIZER_6MOBILEHOME GAS WATERHEATERS MODEL NUMBERS: 153.333831 30GM. 153.333931 40GM.
Page 29
Parts Order List (cont'd) THE ECONOMIZER 6 MOBILE HOME GAS WATER HEATERS MODEL NUMBERS: 153.333831 30 Gal. 153.333931 40 Gal. Model Numbers 153.333831 153.333931 PART DESCRIPTION PART NUMBERS Temperature-Pressure Relief Valve* 9000071 9000071 Primary Anode Rod 9000279 9000279 Model Rating Platey 0270118 0270118 Drain Valve...
Page 32
3. A gas or water leak is due to loose pipe or connections. FULL ONE YEARWARRANTY ON WATER HEATER For one year from the date of purchase, when your Sears Kenmore water heater is installed and operated in a single-family residence in accordance with the instructions in this manual, Sears will: 1.