Advertisement
Match Lighting
A.
Do not lean over grill while
lighting,
I
Open lid, Turn on gas at gas
source
2
Hace lit match into match
J
t
/
i
!
._._j
Match lighting
4,
lighting hole from outside grill bottom
hole is in bottom
(as shown),
Push in and turn RIGHT knob to _
IGNITE Be sure
burner lights and stays lit,
Light left burner (if featured) by pushing LEFT knob in and
turning to _
IGNITE
After Light{ng: Turn Knob(s) to HIGH for warm-up
Burner
Flame
Check
• Light burner, rotate knobs
from HiGH to LOW. You
should see a smaller
flame in LOW position
_ _ _ _ _
e
than seen on HIGH.
Always check flame prior to each use if only low flame is
seen refer to "Sudden drop or low flame" in the
Troubleshooting Section
Turning Grill Off
• Turn all knobsto OFF position.Turn gas OFF at gas source.
Ignitor
Check
• Turn gas off at gas source. Press ignitor button rapidly
"Click" should be heard and spark seen each time between
collector box or burner and electrode See Troubleshooting
if no click or spark.
Valve
Check
• Important: Make sure gas is OFF at gas source before
checking valves. Knobs lock in OFF position To check
valves, first push in knobs and release, knobs should spring
back. If knobs do not spring back, replace valve assembly
before using grill Turn knobs to LOW position then turn back
to OFF position Vatves should turn smoothly.
General
Grill Cleaning
• Do not mistake brown or black accumulation of grease and
smoke for paint Interiors of gas grills are not painted at the
factory (and should never be painted) Apply a strong solution
of detergent and water or use a gd!l cleaner with scrub brush
to insides of grill lid and bottom. Rinse and allow to
completely air dry. Do not apply a caustic grill/oven
cleaner to painted surfaces,
• Plated wire grates: wash grates and Drip VapoRISER Bar
with concentrated grill cleaner or use soap and water
solution Dry thoroughly and store indoors between cookouts
Plastic side shelves: wash with warm soapy water and
wipe dry. A Do not use citrisol, abrasive cleaners,
degreasers or a concentrated grill cleaner on plastic side
shelves Damage to and failure of shelves can result
Porcelain grate: because of glass-like composition, most
residue can be wiped away with baking sodalwater solution
or specially formulated cleaner, Use nonabrasive scouring
powder for stubborn stains.
Briquet grate: will eventually decompose and weaken with
use. Remove grate from grill and tap to loosen any scaling.
Brush grate vigorously with a wire brush to remove any
additional scaling, rust or residue
Care
Of Wood
• Wood items can be sanded lightly with fine grit sandpaper_
Refinish with stain, paint or water sealant.
Post
Inspection
•
If the in-ground post mount option is used, inspect post
annually for corrosion (rust)
• Use only in-ground post mount with protection against
corrosion (paint or other coating) suitabJefor conditions in
your area, ChaFBroiP model #4989050 meets these
requirements
Repainting
Your
Grill
• After extended use and exposure to weather, paint on grill
may deteriorate or become spotted Although this detracts
from grill's appearance, it will not impair its performance.
To refinish your grill brush outside of gril; lid and bottom with
wire brush and lightly sand with fine grit sandpaper Sanding
aIIows new paint to adhere more easily. Wash griil lid and
bottom with soap and water to remove dust and grease. Do
not use a grill cleaner on outside of grill, Wipe with vinegar.
Refinish outside with heat-resistant paint, Do not paint
inside of grill,
16 •
4638003
Advertisement
