Related Manuals for Sears gamefisher 298.586131
Summary of Contents for Sears gamefisher 298.586131
- Page 1 )DE L NO. i8.586131 awner's responsibility maintenance _operation trouble shooting ireplacement iparts...
-
Page 2: Table Of Contents
: TABLE 10FCONTENTS Page No. . ."..• SPECIFICATIONS .., • . .k... , .._,... :,: 4 STEERING HANDLE INSTALLATION • : ..; ._. _,:. ;'. _ ... MAINTENANCE ..°..'o; ..;...°_.;. :':. _;. _;:_ .!._/"..';_"_:..:... - Page 3 IMPORTANT Owner's Responsibility and Operating Safety Check List BE SURE TO READ AND DO THE FOLLOWING BEFORE OPERATING YOUR OUTBOARD MOTOR SAFETY CHECK LIST 1. Learn Guard,state, observe the bolting lawl of the U,S. Coast, local author- ities. U.S. Coast Guard regulations require the following:...
- Page 4 MAJOR PARTS Filler Cap and Air VentScrew Power Starter Handk SparkPlug g Handle ChokeLaver FuelShut-oilValve Transom Bracke Till Pin Adjuslmenl ClampSlud Handles_ MuillerPipe OriveShall Pip Exhausl O utlet Cavitalion Plate CollarPin GearHousing Fill and DrainPlug Propeller GearHousing Cover Figure l Figure 3 Figure 2...
-
Page 5: Steering Handle Installation
IAINTENANCE 1, FEATURE INFORMATION This outboard motor special design When lubricant has completely drained, features as shown in Figure replace parts refill gear housing }. Your selection of our Marine Products will using filling procedure above. provide with many hours of enjoyable best results, lubricate... -
Page 6: Operations
OPERATION BOAT MOUNTING Mount the motor on the center of the boat transom (stern), (See Figure 4). ._L_I =_'°)=" 'vl,,, _." -'_. o"," CAUTION Hand tighten transom bracket and clamp stud handles simultaneously. Do not use a _RIGHT'V|ew2 EVEN KEeL wrench or any other... -
Page 7: 2-Cycle Engine Fuel, Mixture-_'_'_;::_ ,_
OPERATION 2-CYCLE ENGINE FUEL MIXTURE Use a good grade of regular gasoline. {See mix- ing table below.) CAUTION Always use BIA certified TC-W oil in the 50:1 ratio. Faiture to do so may result in excessive spark plug fouling, piston scoring, or bearing failure. -
Page 8: Flooding
OPERATION FLOODING To clear engine of excess fuel, move choke lever "Off" position throttle lever half CARBURETOR throttle position. recoil starter handle until engine starts and continues to run. CARBURETOR ADJUSTMENTS Your motor has a fixed high speed jet, Idle Adjustment been preset... -
Page 9: Ignition System
OPERATION FLYWHEEL MAGNETO IGNITION SYSTEM WiTH TRANSISTERIZED ELECTRONIC IGNITOR The magneto ignition system consists of the following component parts: Flywheel, Tran- sisterjzed Electronic ignitor and ignition Coil. Inspect the following if engine fails or hard to start: CENTER BOLT Spark plug as often as necessary. -
Page 10: Trouble Shooting Check List
TROUBLE SHOOTING CHECK LIST "Take your outboard motor Into any one of over 2000 Sears Service Unite, Fuel Tank Empty " Fue! Shut-Off Valve Ciosed Fuel Line Kinked or Pinched " Vent Screw on' Fuel Tank Filter Cap C'lo_d Carburetor Passages Clogged or Dirty Incorrect Fuel-Oil Mixture Carburetor Out of Adjustment Engine Flooded... -
Page 11: Replacementparts
REPLACEMENTPARTS MODEL No.298.586131... - Page 12 FIG.1 ENGINE 35__71 ° ,__1 2° i_--9S _----7o --18...
- Page 13 FIG.1 ENGINE REENo. P.P.No. PARTS NAME Q'ty 157-04000-900 SPARK PLUG CAP ASS'Y 1-002 1-003 018-00546-200 SPARK PLUG BHR6A 1-004 002-00500-804 CYLINDER COHP. 017-00501-202! CYLINDER GASKET 1-00S 041-00000-210 PISTOH 1-007 RIHG 1-008 039-00000-20! PISTON CIRCLIP 031-00500-200 PISTOH 1-009 037-00000-200 PIN 9X24 1-010 PISTOH 046-00557-801...
- Page 14 FI_.2 TANK, CLUTCH & MUFFLER SEE FIG. 2640...
- Page 15 FIG.2 ENGINE COVER & MUFFLER RERNo. -P.P.No. PARTS NAME [O'ty 595= 51oo- oo2 TAlK CAP*ASS' " 2-002 2-003 300-35108-200 EHGINE COVER 2-004 _600-35100-203 !TAH[ SUPPORT KIHG 2-005 401-35100-204 FUEL TAHK 2-012 5_2-00750-900 PET-COCK ASS'Y 2-015 700-07105-180 _PHEL PIPE 7XlO,5X180 2-017 680-00618-201 iCLIP 2-019...
-
Page 16: Starter ;R
FIG.3 RECOIL STARTER PARTS REENo. P.P.No. NAME O'ty ,,,,j 3-000 RECOIL STARTER ASS'Y 756-00537-900 3-001 RECOIL STARTER BODY !772-00537-200 STARTER ROPE REEL 3-002 774-04015-204 3-003 RECOIL SPRIHG !779-01006-201 3-004 776-01006-207 PULLEY SHAFT 3-005 STARTER ROPE 3.5X1300 '783-00517=200 ROPE GUIDE 780-00601-201 3-006 3-007 STARTER HAHDLE... - Page 17 FIG.4 CARBURETOR - 23 ----24 • RERNo. P.P.No. PARTS NAME iQ'ty+ 455-21602-901 CARBURETOR A'SS'Y 4-000 4-001 560-20445-200 RUBBER CAP 4-002 597-20110-200 CABLE ADJUSTER BODY CAP 4-004 595-21303-200 THROTTLE VALVE SPRING 4-005 594-20110-200 6!9-20110-200 THROTTLE SPRING RECEIVE 4-006 JET HEEDLE 4-007 592-2002T-930 ASS'Y NEEDLE...
- Page 18 FIG.5 HANDLE & BRACKET 1_ I1...
- Page 19 FIG.5 HANDLE & BRACKET RERNo. P.P.No. PARTS NAME O'ty 8SS-OOS_-SOO'TNR_TTLE VZRE_OHP. 5-001 5-002 870-00569-900 THROTTLE LgVER ASS'¥ 5-003 145-35118-200 JOINT PIPE HOLDER 5-004 990-11060-182 _SCREW OX18 5-005 992-10060-04_ S.WASHER 5-006 990-21060-302 BOLT 6X30 5-007 992-10060-042 !S.WASHER 5-008 160-35118-901 STEERING HAHDLE ASS'Y 5-009 163-35118-200 HANDLE...
- Page 20 FIG.6 DRIVE SHAFT PIPE & GEAR CASE 2°...
- Page 21 FIG.6 DRIVE SHAFT PIPE & GEAR CASE REENo. P.P.No. PARTS NAME Q't_ 6-001 090-35118-900 JOINT PIPE ASS'Y 6-002 075-35100-206 DRIVE SHAFT 6-003 076-35100-203 DRIVE 6-004 086-35100-200 BEARING HOLDER SPRING 6-005 081-35100-200 SHAFT BEARIHG DRIVE 6-006 039-35100-203 8EARIHG HOLDER 6-007 091-35100-202 JOINT PIPE GASKET...
- Page 22 FIG.7 TOOLS REENo. P.P.No. PARTS NAME O'ty TOOLKIT..985-35118-900 7-000 SP^RKPLUG BOXSPA.NEe 851-20000÷201 7-001 SPAHHER 8XIO 801-20000-200 7-002 PLUS DRIVEK 662-20000-200 7-003 948-39907-200 TOOL 7-004...
- Page 23 vlODE L NO. __98,586131 For quick service or "repair, take your Outboard Motor to any Sears Service Unit throughout FULLONE YEARWARRANTYON U_S. and Canada. Each Service Unit is staffed OUTBOARD MOTOR trained technicians, using Sears approved For one year from the hrst day of use of parts...