20.0 hp electric start 42" mower automatic (61 pages)
Summary of Contents for Craftsman EZ 917.270731
Page 1
Read and follow all Safety about this product, Call: 1-800-659-5917 Rules and Instructions before operating this equipment. Sears Craftsman Help Line 5 am - 5 pm, Mon- Sat Sears, Roebuck and Co,, Hoffman Estates, II 60179 Visit our Craftsman website:www.sears.comJcraffsman...
Page 2
Sears will replace the battery at no charge. Warranty service is available free of charge by taking your Craftsman riding equipment to your nearest Sears Service Center.
SLOPE OPERATION IMPORTANT: This cutting machine capable of amputating hands and feet Slopes are a major factor related to loss- and throwing objects. Failure to observe of-control and tipover accidents, which the following safety instructions could can result in severe injury or death. All result in serious injury or death.
Page 4
Never run a machine inside a closed • Keep children out of the mowing area • area. and under the watchful care of another Keep nuts and bolts, especially blade responsible adult. • attachment bolts, tight and keep • Be alert and turn machine off if children enter the area.
_Look for this symbol to point out jmpor- • I,CAUTION: Tow only. the attachments saTely precautions. It means CAu- that are recommendea by and comply TION!!! BECOME AWARE!!! YOUR with specifications of the manufacturer SAFETY IS INVOLVED. your tractor. Use common sense when towing.
Page 6
Steering Wheel Steering Wheel Insert (1) Large Flat Washer (1) Hex Bolt (1) Hex Bolt (1) Lock washer 5/16-18 x 1-1/4 3/8-16 x 1 (1) Locknut 5/16-18 Extension Steering Shaft Boot teering Steering Wheel Adapter Seat (£Washer 17/32 x 1-3/16 x 12 _) Shoulder olt 5/16-18 Gauge...
Page 7
Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness.
TO ROLLTRACTOR OFF SKID (Seq Operation section for location and Label function of controls) • Press lift lever plunger and raise Terminal attachment lift lever to its highest Ba_e_ Door position. • Release parking brake by depressing clutch/brake pedal. • Place gearshift lever in neutral (N) position.
Page 9
INSTALL MULCHER PLATE CHECK FOR PROPER POSITION OF ALL BELTS (If previously removed) • Raise and hold deflector shield in See the figures that are shown for upright position. replacing mot=on and mower blade drive • Place front of mulcher plate over front belts in the Service and Adjustments of mower deck opening and slide into...
Page 10
These symbols may appear on your tractor or m literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR REVERSE FORWARD FAST SLOW WARNING ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON OVER TEMP LIGHT FUEL CHOKE MOWER HEIGHT PARKING BRAKE UNLOCKED...
Page 11
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the Iocattons of various controls and adjustments. Save this manual for future reference. Light Switch IgnJtton Switch Attachment Clutch Lift...
Page 12
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses.
Page 13
healthier and better looking lawns, Attachment Clutch Attachemnt mow often and after moderate growth. Lever Lift Lever • For best cutting performance, grass "Engaged" High Position over 6 inches in height should be Position mowed twice. Make the first cut Position relatively high;...
BEFORE STARTING THE ENGINE To avoid engine problems, the fuel system should be emptied before CHECK ENGINE OIL LEVEL storage of 30 days or longer. Drain the • The engine in your tractor has been gas tank, start the engine and let it run shipped, from the factory, already filled until the fuel lines and carburetor...
COLD WEATHER STARTING ( 50 ° F and • When operating attachments, select a below) ground speed that will suit the terrain and give best performance of the • When engine starts, allow engine to attachment being used. run with the throttle control in the choke position until the engine runs roughly, then move throttle control to...
AS YOU COMPLETE ATES REGULAR SERVICE Check Brake Operation Check 33re Pressure Check Operator Presence and Interlock Sy§tems IJ# # ; R Che__or L ooee Faete,e,e ' I/'_ I,I, LubricationChart Check Battery Level CA Sharpen/Replace Mower Blades Clean Battery and Terminals Check Transaxle Cooling Adjust Blade Belt(s) Tension I1_,...
Page 17
TRACTOR IMPORTANT: To ensure proper assem- bly, center hole in blade must align with Always observe safety rules when star on mandrel assembly. performing any maintenance. • Reassemble hex bolt, lock washer an_ BRAKE OPERATION flat washer in exact order as shown. If tractor requires more than six (6) feet •...
Page 18
BATTERY NOTE; Although multi-viscosity oils (5W30, 10W30 etc.) improve starting in Your tractor has a battery charging cold weather, these multi-viscosity oils system which is sufficient for normal use. will result in increased oil consumption However, periodic charging of the battery when used above 32°E Check your with an automotive...
ENGINE COOLING FINS • Clean cartridge by tapping gently on Remove any dust, dirt or oil from engine flat surface. If very dirty or damaged, cooling fins to prevent engine damage replace cartridge. from overheating. • Reinstall cartridge, nut, precleaner, •...
Page 20
CLEANING We do not recommend using a garden hose to clean your tractor unless the • Clean engine, battery, seat, finish, etc. electrical system, muffler, air filter and of all foreign matter. carburetor are covered to keep water out • Keep finished surfaces and wheels Water in engine can result in a short-...
Page 21
TO LEVEL MOWER HOUSING • Before making any necessary adjust- Adjust the mower while tractor is parked ments, check that both front links are on level ground or driveway. Make sure equal in length. Both links should be approximately 10-3/8". tires areproperly inflated (See "PROD- UCT SPECIFICATIONS...
Page 22
TO REPLACE MOWER BLADE With Parking Brake "Engaged" DRIVE BELT The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL- Nut "A" • Remove mower from tractor (See "TO Jam Nut REMOVE MOWER"...
Page 23
NOTE: When the tractor roar wheels Washers move freely, the transaxle is in neutral. • Loosen adjustment bolt in front of the Retaining f_%'_ right rear wheel. Axle Ring __ _"(_=_ • Position the gear shift lever in the neutral (N) position. Cover._.J_ __JJ •...
INTERLOCKS AND RELAYS REPLACING BATTERY Loose or damaged wiring may cause _CAUTION: Do not short battery terminals by allowing a wrench or any your tractor to run poorly, stop running, or other object to contact both terminals at prevent it from starting. the same time.
Page 25
FINAL SETTING • Check that holes "A" in governor control lever and hole in governor • Start engine and allow to warm for five plate line-up. If holes "A" are not minutes. Make final adjustments with aligned, loosen clamp screw and engine running and shift/motion move throttle cable until...
ethanol or methanol) can attract moistur_ Immediately prepare your tractor for storage at the end of the season or if the which leads to separation and formation tractor will not be used for 30 days or of acids during storage. Acidic gas can more.
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION Will not start • Outoffuel. • Fill fuel tank. • Engine not "CHOKED" • See"TO START ENGINE" properly. in Operation section. • Engine flooded. • Wait several minutes before attempting to start. • Bad spark plug. •...
Page 28
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION Engine clicks but • Weak or dead battery. • Recharge or replace battery. will not start • Corroded battery terminals. • Clean battery terminals. • Loose or damaged wiring. • Check all wiring. • Faulty solenoid or starter. •...
Page 29
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION Poor cut - uneven •Worn, bentorlooseblade. • Replace blade. Tighten blade bolt. • Mower deck not level. • Level mower deck. • Clean underside of mower • Buildup of grass, leaves, and trash under mower. housing.
Page 30
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION Battery will not • Bad battery cell(s). • Replace battery. charge • Poor cable connections. • Check/clean all connections. • Faulty regulator • Replace regulator. (if so equipped). • Faulty alternator. • Replace alternator. Engine"backfires" •...
Page 31
TRACTOR - - MODEL NUMBER 917.270731 SCHEMATIC BATTERY FUSE BLACK ..SOLENOID STARTER L ..CLUTCH / BRAKE .--( (PEDAL SEAT SWITCH IGNITION ..(NOT OCCUPIED) SWITCH IWHITE ..BL_CK BIJ_ K BLAC K BLACK 'CLU' HNOH ATPMENT CLUTCH ..BLACK _ _rrl CONNECTOR...
Page 32
TRACTOR - - MODEL NUMBER 917.270731 ELECTRICAL...
Page 33
TRACTOR -- MODEL NUMBER 917.270731 ELECTRICAL KEY PART DESCRIPTION 144925 Battery 74760412 Bolt Hex Hd 1/4-20unc x 3/4 156417 Case Battery 153664 Switch, Interrock 166182 Harness Asm Ught W/4152j 4152J Bulb Light #1156 4799J Cable Battery 6 Ga ;i1" red 146147 Cable Battery 6 Ga w/16 wire red 166180...
TRACTOR - - MODEL NUMBER 917.270731 MOWER DECK _147 >21 113 111 114...
Page 47
TRACTOR - - MODEL NUMBER 917.270731 MOWER DECK KEY PART KEY PART DESCRIPTION DESCRIPTION Knob Custom Oval 165892 Mower Deck Assembly, 42" 149846 STD533107 Bolt 144959 V-Belt 138017 Bracket Assembly,Sway Bar, STD541437 Front 136420 Mulcher Cover 165460 Screw Bracket Sway Bar 38/42" Deck 71161010 Washer STD624008...
Page 48
TRACTOR - - MODEL NUMBER 917.270731 PEERLESS TRANSAXLE - - MODEL NUMBER 206-545C 706A...
Page 49
TRACTOR -- MODEL NUMBER 917.270731 PEERLESS TRANSAXLE - - MODEL NUMBER 206-545C KEY PART KEY PART DESCRIPTION DESCRIPTION Brake Lever 772147 Transaxle Cover 790079 Screw 1/4 - 20 x 1-1/4" 780086A Needle Bearing 5/8" 792073A Screw 1/4 - 20 x 2 1/4" 770128 Transaxle Case 792085A...
Page 50
TRACTOR -- MODEL NUMBER 917.270731 BRIGGS ENGINE-MODEL NUMBER 311707, TYPE NUMBER 0132-E3 1022 1023 15_b 1033 VALVE OVERHAUL KIT REQUIRES SPECIAL TOOLS TO INSTALL, SEE REPAIR INSTRUCTIONMANUAL, 1022 [ 1019 LABEL KIT 868 (_ [ 1058 OWNER'S MANUAL...
Page 51
TRACTOR - - MODEL NUMBER 917.270731 BRIGGS ENGINE-MODEL NUMBER 311707, TYPE NUMBER 0132-E3 136 {_ 127, 51A_ PART NUMBER LOCATIONS THIS CARBURETOR SERVICES BOTH CHOKE-A-MATIC AND MANUAL CHOKE SYSTEMS 121 CARBURETOR 104// 127 0 267Q 9679 634A _.._ 634c. _ 117_ 231_ 105[_...
Page 52
TRACTOR - - MODEL NUMBER 917.270731 BRIGGS ENGINE-MODEL NUMBER 311707, TYPE NUMBER 0132-E3 510A_ 513 ! 493A 1051...
Page 53
TRACTOR - - MODEL NUMBER 917.270731 BRIGGS ENGINE-MODEL NUMBER 311707, TYPE NUMBER 0132-E3 NIKKI 130A 633A 133A(_ 127A 0 117A _ 137A 276A 947A 105A 121A CARBURETOR OVERHAUL 276A 95A _ 117A 104A _ 127A0 105A J_-_ 231A _P 137A 977A CARBURETOR GASKET...
Page 54
TRACTOR - - MODEL NUMBEI 917.270731 BRIGGS ENGINE-MODEL NUMBER 311707, TYPE NUMBER 0132-E3 KEY PART KEY PART DESCRIPTION DESCRIPTION 690156 Cylinder Assembly 690464 Valve-Choke (Manual Choke) 399265 Bushing/Seal 108A 692344 Valve-Choke (Choke A Matic) 391086 Seal-Oil 108B 695419 Choke Valve 494238 Sump-Engine 692408...
Page 55
TRACTOR - - MODEL NUMBER 917.270731 BRIGGS ENGINE-MODEL NUMBER 311707, TYPE NUMBER 0132-E3 KEY PART KEY PART DESCRIPTION DESCRIPTION 783B 693058 Gear-Pinion (For Plastic Ring 693551 Motor-Starter (For Steel Ring Gear Only) Gear Only) 497595 Motor-Starter (For Plastic Ring 695050 Harness- Wiring Nut (Brush Retainer) Gear Only)
Page 59
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHTING GUIDE 15 ° MAX. greater than 15°), never across the face. Make turns gradu- Operate your Tractor up and down the face of slopes (not ally to prevent tipping or loss of control.
Page 60
Get it fixed, at your home or ours! For repair of major brand appliances in your own home... no matter who made it, no matter who sold it! 1-800-4-MY-HOME SM Anyt,me, day or night (1-800-460-4663) www.sears.com To bring in products such as vacuums, lawn equipment and electronics for repair, call for...