1. Scope of Delivery – Basic equipment, depending on sub-class, with short trimmers and electromagnetic upper thread catcher – Yarn stand – Small parts in the accessories pack...
2. Installation ATTENTION ! The buttonhole machine may only be installed by trained personnel. Prior to installation the following work must be conducted: – Remove the transport fastening screw 3 ! The screw is marked red. – The needle bar is turned into its low position for transport. By turning the handwheel 1 in the direction of the arrow bring the needle bar into the high position ! –...
2.4 Yarn Unreeler for Yarn and Wool Cones Optional equipment Article no. 558 3001 The yarn unreeler 1 is fastened to the middle traverse. Additionally, the yarn unreeler can be equipped with a drawer. This could be necessary, for example, when a small table is used and there is thus no room available under the table.
3. Electrical Connection ATTENTION ! All work on the electrical equipment of the buttonhole machine may only be conducted by electricians or suitablly instructed personnel. The mains plug must be disconnected. 3.1 Nominal Voltage The nominal voltage listed on the motor rating plate and the mains voltage must be the same ! 3.2 Drive Package For conversion to a different mains voltage the appropriate drive package must be...
3.3 Checking the Direction of Motor Turn ATTENTION ! Before commissioning the buttonhole machine it is essential that the direction of motor turn be checked. Turning on the machine with an incorrect direction of motor turn can lead to damage of unit. With single phase, alternating current motors the direction of turn is set automatically if terminal connections are made according to the hook-up diagram.
3.4 V-belt Tension Setting V-belt tension left: – Loosen screw 2. – Turn the nuts 4 back so far that they do not lie onto the motor support plate. The motor’s own weight sets the correct tension for the left V-belt (at the right in the picture).
4. Installation of a Sewing Light The sewing light is available as optional equipment. Order no.: Article: App. 1062 Halogen sewing light App. 1541 Attachment kit 798 500088 Sewing light transformer ATTENTION ! Pull the mains plug ! The electrical connection may only be made by electricians or appropriately instructed personnel.
5. Filling the Oil Reservoir ATTENTION ! Before commissioning the machine the oil reservoirs 1 and 2 must be filled to the " max. " marking. The lubrication of the buttonhole machine occur out of 2 reservoirs via an oil wick system.