Related Manuals for DAELIM ET-300 - SERVICE MANUAL BIS
Summary of Contents for DAELIM ET-300 - SERVICE MANUAL BIS
-
Page 1: Table Of Contents
THROTTLE LEVER BRAKE CONTROLS Parking Brake Adjustmemt FUEL SYSTEM Fuel Tank Fuel Valve Inline Fuel Filter TIRES AND WHEELS Tire & Wheel inspection Tire Pressu re FUEL INDICATOR METER REVERSE INDICATOR LAMP SPEEDOMETER & ODOMETER SPECIFICATIONS BREAK-IN YOUR NEW DAELIM ATV... - Page 2 TABLE OF CONTENTS THROTTLE LEVER Adjusting The Throttle Cable SPARK PLUG BRAKING SYSTEMS The Brake Cables Inspection The Brake Cables Adjustment The Brake Hoses Inspection To Fill The Reservoir Purging Brake Lines DRIVE CHAIN Chain Slack Adjustment AIR FILTER Air Filter Maintenance To Clean The Filter ENGINE WARTER COOLER Checking C...
-
Page 3: Your Responsibilities
DAELIM DAELIM ET250 DAELIM YOUR RESPONSIBILITIES DAELIM... - Page 4 (9) Reverse indicator lamp Rear cargo rack...
-
Page 5: Control Features
CONTROL FEATURES The travel of the throttle lever is controlled by the throttle stop bolt. DAELIM As your operator gains more experience, you can increase the throttle travel to allow for additional speed to be obtained. Throttle Stop Adjustment Boit... -
Page 6: Parking Brake Adjustmemt
CONTROL FEATURES pressure to your front brakes so that the wheels lock up, stop turning, and causing a The rear brake is controlled by the long brake loss of steering control. if the front wheels lock lever on the left-handle bar. up, and stop turning, lightly reduce the pressure on the front brake lever until they unlock and start to turn. -
Page 7: Fuel System
CONTROL FEATURES 3. Also,as you found out the parking brake cause damage to the cap or seal. ability which is a bit insufficient, you can The fuel tank capacity is 12 liters, 3.17 gal, screw the adjustable nut of parking brake. including a reserve of 2.5 liters, 0.66 gal. -
Page 8: Inline Fuel Filter
CONTROL FEATURES atically shut off when the engine is stopped. Remove the filter from the fuel line by holding the line and pulling the filter. Install the new The fuel will automatically begin to flow when filter by inserting the filter into the fuel line and the engine is turned over. -
Page 9: Fuel Indicator Meter
FUEL INDICATOR METER REVERSE INDICATOR LAMP Your ATV is equipped with a fully automatic C.V.T. transmission and has forward and reverse gearing. A transmission shifting shaft is located on the right hand side of your vehicle. The shifter has three positions "F" Forward, "N" Neutral and "R"... -
Page 10: Speedometer & Odometer
SPEEDOMETER & ODOMETER... -
Page 11: Specifications
SPECIFICATIONS ET250 ET300 Engine Type 4 Stroke Single Cylinder Liquid cooled 4 Stroke Single Cylinder Liquid cooled Displacement 249 cc 287.2 cc 71mm * 63mm 75mm * 65mm Bore / Stroke Compression 10.8:1 10.0:1 19ps @ 6500rpm 20ps @ 6500rpm Power Transmission Type... - Page 12 When first starting the engine,(cold start), place the lever in the full left position, (Choke closed or on) As the engine warms return the lever to the full right position. (Choke open or off).] BREAK-IN YOUR NEW DAELIM ATV DAELIM...
- Page 14 DAELIM...
-
Page 15: Throttle Lever
THROTTLE LEVER Throttle Stop Adjustment Boit Throttle and turn the throttle stop screw clockwise to reduce the throttle travel thus reducing the The throttle lever is located beside the right- maximum speed of the unit. Turning the stop handlebar grip and is operated by using the right- screw counter clockwise will increase the throttle hand thumb. -
Page 16: Braking Systems
BRAKING SYSTEMS Your ATV unit is equipped with dual front hydraulic disc brakes and a rear hydraulic disc brake. The front brakes (right) and rear brake (left) are applied by squeezing the brake lever on the right & left handle-bar , while the four wheel simultaneous brakes are applied by pressing the brake pedal on the right-footrest. -
Page 17: To Fill The Reservoir
your fluid level and brake pads. If the brake lever Purging Brake Lines feels spongy or does not stop when squeezed, you may have air in the lines. All air must be purged from the brake lines for the disc brake to operate properly. -
Page 18: Drive Chain
DRIVE CHAIN AIR FILTER Air Filter Maintenance Air Filter Box 10-20mm 0.39"-0.79" The drive chain will stretch with use and will require periodic adjustments. To check the chain tension, remove the chain guard and measure the slack. The amount of slack in the chain should not exceed 10-20mm or 0.39"-0.79". -
Page 19: Engine Warter Cooler
PLEASE PAY SPECIAL ATTENTION that using ENGINE WARTER COOLER poor quality coolant may shorten the service life The engine coolant is cooled by an external of the radiator. radiator located at the front of the unit. It is Concentration:50%.(Use distilled water when important that the radiator fins be kept free of mixing coolant) dirt build up to prevent the engine from over... -
Page 20: Engiee Oil
ENGINE OIL Engine Oil Drain Checking Engine Oil Level Engine Oil Dip Stick & And F ill Tube •• ••• •• ••• • ••• • •• • •• • •••• ••• 2. Remove the crankcase drain plug located on the bottom of the crankcase on the underside of the unit. -
Page 21: Electrical Battery
Transmission Oil Drain Battery GTX12-BS •• ••• • ••• • •• • •• • •••• ••• When reinstalling the battery, be sure to connect the red cable to the positive (+) terminal and the 2.Remove the tr ansmission b ox d rain p lug black cable to the negative (-) terminal. - Page 22 I, L...
- Page 24 NOTATION...