Table of Contents
Advertisement
Quick Links
UV-AIRE™ AIR PURIFYING SYSTEM
UV-C light inhibits the growth and reproduction of germs and bacteria that circulate through a
homes' heating and air conditioning system. The treatment is a safe, silent, and proven way
to make your home a healthier place to live.
READ THESE INSTRUCTIONS CAREFULLY AND COMPLETELY BEFORE PROCEEDING WITH THE INSTALLATION
LEAVE THE INSTALLATION INSTRUCTIONS WITH THE OWNER/OPERATOR OF THE DEVICE
AFTER OPENING THE CARTON, UNPACK AND INSPECT THE UNIT AND LAMP FOR DAMAGE.
SAFETY CONSIDERATIONS
WARNING: Never expose eyes or skin to UVC light from any source.
• Looking directly at the UVC light may cause permanent eye damage or blindness.
• Never operate the UV-Aire™ Air Purifying System out of the plenum.
• Designed for a closed duct system. Do not mount near a return air opening
• All duct openings in direct line of site of the UV light must be sealed with duct tape or equivalent sealing
methods.
WARNING: UV light will break down plastic materials not rated for UV exposure:
(Examples: wire insulation, flex duct, drain pans and humidifiers)
• The unit must be mounted at least 30" from the above stated type of materials.
• If it is necessary to mount the unit in direct line of site of these types of materials, they must be shielded
with aluminum foil, aluminum foil tape, or sheet metal.
WARNING: DO NOT mount this unit outdoors.
• This product is designed for indoor installation only (i.e. attics, crawl spaces, basements, etc.).
Model: UV-18X
DO NOT INSTALL THIS UNIT IF ANY DAMAGE IS NOTICEABLE.
ITEMS INCLUDED IN KIT:
1-UV-Aire power unit
4-Sheet metal mounting screws
1-Angled mounting bracket
1-Flat mounting bracket
1-Duct board mounting bracket
2-Ultra Violet lamps
1-Instruction Sheet
1-Wing nut
Caution Labels
Gasket
Advertisement
Table of Contents
Related Manuals for Field Controls 46453300
Summary of Contents for Field Controls 46453300
- Page 1 UV-AIRE™ AIR PURIFYING SYSTEM Model: UV-18X ITEMS INCLUDED IN KIT: 1-UV-Aire power unit 4-Sheet metal mounting screws 1-Angled mounting bracket 1-Flat mounting bracket 1-Duct board mounting bracket 2-Ultra Violet lamps 1-Instruction Sheet 1-Wing nut Caution Labels Gasket UV-C light inhibits the growth and reproduction of germs and bacteria that circulate through a homes’...
-
Page 2: Indication For Use
INDICATION FOR USE This product is not sold as a medical device and is not for the purpose of diagnosis of any disease or condition nor for use in the mitigation, treatment, or prevention of any disease or condition. GENERAL INFORMATION There are different size units available, depending on the square footage of your home. - Page 3 2. Determine the type of duct you have. (For flex duct applications, refer to Figure 21 on page 8) F YOU HAVE METAL DUCT a. Apply supplied wet and stick mounting template to air duct in either a vertical or horizontal position as shown in Figure b.
- Page 4 Apply supplied “Duct Seal Kit” according to instructions included in kit. 4. Loosen the two side screws on the unit and slide cover off of unit exposing the internal components. (See Figure 13) Figure 13 5. Determine whether to use flat or angled bracket. (Refer to UV-Aire Configurations in Section III for aid in this decision) a.
- Page 5 8. Insert lamp through hole until lamp cannot be inserted any further. (See Figure 17) Figure 17 9. Swing swivel bracket over end of lamp and hand-tighten the wing nut on stud. (See Figure 18) Figure 18 10. Plug ballast plug into end of lamp. (See Figure 19) Figure 19 11.
- Page 6 BULB MOUNTING BRACKET SELECTION AND INSTALLATION The UV-AIRE units come with an angled mounting bracket and flat mounting bracket to position the bulb either straight or at an angle. Choose one or the other bracket method best suited for your needs. Refer to the configurations chart below when making your selection.
-
Page 7: Maintenance
(Field Controls Part Number) UV-18X 46365402 46365502 For replacement parts, contact your local heating service company. Any questions, please contact Field Controls at: !Phone: 252-522-3031 "Fax: 252-522-0214 #Email: sales@fieldcontrols.com WARNING: Never expose eyes or skin to UVC light from any source. Looking directly at the UVC light may cause permanent eye damage or blindness. -
Page 8: Warranty Information
FIVE YEAR LIMITED WARRANTY (excluding lamps, which have a 90 day warranty, from day of installation) The products of The Field Controls Co. are warranted to be free from defects in material and workmanship under normal use for five (5) years from date of manufacture.