PIONEER Service Manual. A subscription to, or additional copies of, Also test with plug reversed Earth PIONEER Service Manual may be obtained at a nominal (Using AC adapter ground charge from PIONEER. plug as required)
1.2 NOTES ON REPLACING ............................... 5 1.3 CAUTION..................................5 1.4 NOTES ON ASSEMBLING............................. 6 2. SPECIFICATIONS................................. 7 2.1 SC-63/SC-61 SPECIFICATIONS............................ 7 2.2 SC-1227-K/SC-1222-K SPECIFICATIONS........................9 3. BASIC ITEMS FOR SERVICE ............................11 3.1 CHECK POINTS AFTER SERVICING ......................... 11 3.2 PCB LOCATIONS ................................. 12 3.3 JIGS LIST ..................................
Page 4
11.21 FAN CONNECT_S, BT and MIC HP GUARD ASSYS ....................242 11.22 BIND DM CABLE ASSY and P WIRE GUARD ASSY ....................246 11.23 FFC GUARD, BIND FAN CABLE, VREG GUARD, TRANS VREG STYL and IR EDGE GUARD ASSYS....248 12. PCB PARTS LIST ................................250 SC-63...
Q4501,4502 ------------------- Land is under parts Q4601,4602 ASSY Q4701,4702 Q4801,4802 Q4901,4902 1.3 CAUTION • Discharging Before starting the diagnosis, wait for three minutes until the electricity of the unit is discharged. • Ground Points Please refer to “Ground Points”. SC-63...
Accessory of Panel Base D-AMP_S ASSY Rear Panel • Front View If a screw at any of these points needs to be removed for service, be sure to check that the swarf is not on the screw before refastening. SC-63...
2. SPECIFICATIONS 2.1 SC-63/SC-61 SPECIFICATIONS Amplifier section Continuous average power output of 125 watts* per channel, min., at 8 ohms, 1 kHz with no more than 0.08 %** total harmonic distortion. Multi channel simultaneous power output (1 kHz, 1 %, 8 Ω ) 7 ch total..............................
Page 8
Dimensions ....................435 mm (W) x 185 mm (H) x 441 mm (D) (17 1/8 in. (W) x 7 1/4 in. (H) x 17 3/8 in. (D)) Weight (without package) SC-63............................14.6 kg (32.2 lb) SC-61 ............................14.4 kg (31.7 lb) Number of Furnished Parts MCACC Setup microphone............................
HDMI output type ........................... 5 V, 55 mA USB terminal .................... USB2.0 High Speed (Type A) 5 V, 2.1 A iPod terminal ......................USB, and Video (Composite) ADAPTER PORT terminal ........................5 V, 100 mA WIRELESS LAN ADAPTER terminal ....................5 V, 600 mA SC-63...
Page 10
Apple, AirPlay, iPad, iPhone, iPod, iPod nano, iPod touch, iTunes and Mac are trademarks of Apple Inc., registered in the U.S. and other countries. The AirPlay logo is a trademark of Apple Inc. Windows and the Windows logo are trademarks of the Microsoft group of companies. SC-63...
Disturbed image (video jumpiness) Volume too high Too dark Volume fluctuating Mottled color Cleaning Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools. Name Cleaning paper Refer to “9.4 CHASSIS SECTION”. SC-63...
Diagnosis for DIGITAL MAIN ASSY, FILTER ASSY 28P + 14P board to board extension jig cable GGD1763 Diagnosis for FILTER ASSY [2] Lubricants and Glues List Name Lubricants and Glues No. Remarks Silicone Grease ZLB-PN397B Refer to “9.5 FRONT SECTION” SC-63...
Page 17
CUXJ SC-1227-K POWER SW ASSY SC-2022-K SYXJ8 ATS7452-A ADG7123-A ATS7453-A ADG7121-A SC-2022 (SC-63/SC-61 : AWX1135) (SC-1227-K/SC-1222-K : AWX1151) CN7400 mark found on some component parts should be replaced 1.S1-1 with same parts(safety regulation authorized) of identical 2.S1-C 3.S1-2 designation. 1.S3-1 2.S3-C...
Page 31
Check the circuits arround RY71 when press power key? or replace PRIMARY ASSY Check DIGITAL MAIN ASSY Check DVCPOW signal path DISPLAYA-REG CN601 13 pin (DVCPOW) DIGITAL MAIN ASSY LH when press power key? Diagnose or replace DIGITAL MAIN ASSY SC-63...
Page 33
SP system setting.) Zone3 Audio no output Digital inoutput Refer to speaker (front is OK) flow. Analog inoutput from Zone 3 line from Zone 3 line out? (MAIN is OK) Which channels correspond to zone, refer to instruction manual. SC-63...
Page 34
Diagnose FRONT HDMI USB ASSY (arround IC8003) or replace FRONT HDMI USB ASSY or HDMI Cable from FRONT HDMI USB Assy Diagnose DIGITAL MAIN ASSY MEDIA SERVER in (arround IC9204,IC9203) (Other Digital OK) or replace DIGITAL MAIN ASSY SC-63...
Page 35
"Pure Direct", Replace IC2501 Check the analog signal path Other results Dignose and repair NG point e.g. if selecting "CD", check INL11 58 pin / INR11 57 pin, outputs is FROUT 8 pin / FLOUT 7 pin SC-63...
Page 36
(arround IC8301) Component out or or replace COMPONENT ASSY zone 2 Component out? Diagnose or replace HDMI inHDMI out? DIGITAL MAIN ASSY Composite Diagnose or replace (Component) in DIGITAL MAIN ASSY HDMI out? Diagnose or replace GUI? DIGITAL MAIN ASSY SC-63...
Page 37
Diagnose INTERFACE ASSY Remote Control (IR,SR circuits) or replace INTERFACE ASSY Check the signal path of IR-IN,SR-IN,RMC Repair or replace INTERFACECONNECT NG point DIGITAL MAINV-REG DISPLAY ASSY No problem Diagnose DISPLAY ASSY (IR,SR,RMC signal path, arround U3201) or replace DISPLAY ASSY SC-63...
BERR port becomes "L". Refer to “How to Enter MCACC LED failure (IC3001 84pin) Release Mode” . detection [How to Enter Release Mode] During Standby mode, simultaneously press and hold the "TUNE [] " and "MULTI-ZONE ON/OFF" keys for 5 seconds. SC-63...
Page 43
4.1V or lower Power ON detection and XVDDERR port is set to "L" XVDDERR Circuit FRONT HDMI USB ASSY V+5_USB_DC DISPLAY ASSY V+5EV CN8002 CN3004 UCOM IC3001 Q8004 2SC4154-11(EF) GNDU GNDCH SC-63...
[ ↑ ] [↓] Display number of times D E R R Digital Power abnormality is detected. [ ↑ ] [↓] Display number of times B REG power supply B E R R failure is detected. [ ↑ ] [↓] SC-63...
Page 47
1 kHz square wave. If the square wave is output, ↓ 5 sec the CEC line is considered to be normal. Power OFF (All zone OFF) FAN TEST : The function for making the FAN to be forced to rotate. SC-63...
Before turning the unit ON, be sure to ground the marked points with the Chassis 65. Or, you may short-circuit the ground points on the solder surface, using pieces of wire. Screws for Rear Panel BBZ30P080FTB BMZ30P040FTB BPZ30P100FTC ABA7078 SC-63...
Page 49
Front (5) Cut the Binder. ADX7776 (6) Release the 15P FCC (ADD7765) from the ∗2 PCB binder. USB RECT ASSY Notes on assembling ∗2: PCB binder tilt in the direction of the blue arrow. 15P FCC Front V-REG ASSY SC-63...
Page 50
15P FCC MIC HP GUARD ASSY. (9) Remove the four screws. SC-63 only : BBZ30P060FCC Except SC-63: BBZ30P080FCC Note: 15P FCC (ADD7765) is affixed with the Double Side Tape (10 x 110mm). ∗4 Notes on assembling ∗3: Twist the PCB binder around the 5P Housing ASSY (ADX7789) so that it don’t contact the...
Page 51
(7) Disconnect the connector. (8) Disconnect the two connectors. (9) Remove the screw. (BBZ30P060FCC) CN7901 PF04PG-S10 V-REG ASSY Notes on assembling CN7554 VREG GUARD ASSY Front ∗2: PCB binder tilt in the direction of the blue arrow. Doesn't touch the other cables. SC-63...
Page 52
∗7: Don’t touch the FAN Cable to the other cables and screw. FAN CONNECT_S ASSY Cushion Circle 14B CN3652 ∗7 ∗6 ∗7 ∗7 FAN Cable Insulating Sheet 63 (18) Remove the Insulating Sheet 63 (with the Cushion Circle 14B). SC-63...
Page 53
(2) Insert the Insulation Sheet. (3) Connect the Rear Panel to the Chassis 65 Ground and GND point of the D-AMP_S AUDIO ASSY ASSY. (Refer to the “Ground Points” for the GND point of the D-AMP_S ASSY.) Insulation Sheet Chassis 65 D-AMP_S ASSY SC-63...
Page 54
CN7802 (8) Connect the two pair board to board CN7801 extension jig cables. (GGD1798) (DIGITAL MAIN CN602 <-> CONNECT CN7802) 20P + 14P board to board (DIGITAL MAIN CN603 <-> CONNECT CN7801) CONNECT ASSY extension jig cable (GGD1798) SC-63...
Page 55
(2) Release the cable (ADX7778) from hook of Front the BIND FAN CABLE ASSY. IR Cover IR Cover 4P Housing ASSY Front (3) Remove the Acetate Tape. (4) Remove the two screws. (BSZ30P060FCC) (5) Remove the PRIMARY ASSY PRIMARY ASSY Acetate Tape PRI Angle Front SC-63...
Page 56
IR INTERFACE ASSY may be loosened. Attach the connectors securely. IR INTERFACE ASSY D-AMP_S ASSY Front Rear Panel [3-2] Diagnosis (1) Temporarily attach the IR Cover to the Rear Panel , using the three screws. (BBZ30P080FTB) IR Cover SC-63...
Page 57
23P + 23P board to board extension jig cables. (GGD1804) extension jig cable (GGD1804) (IR BUFFER CN6803 <-> IR INTERFACE CN3802) (IR BUFFER CN6802 <-> IR INTERFACE CN3801) IR BUFFER ASSY CN6803 CN6802 IR INTERFACE ASSY CN3802 CN3801 Front SC-63...
Page 58
(2) Remove the IR INTERFACE ASSY. IR INTERFACE ASSY D-AMP_S ASSY Front (3) Disconnect the five connectors. CN4003 CN4004 CN4000 CN4001 CN4002 D-AMP_S ASSY (4) Remove the six screws. (BBZ30P060FCC) (5) Remove the five screws. (IBZ30P150FCC) (6) Remove the D-AMP_S ASSY. D-AMP_S ASSY SC-63...
Page 59
HDMI connector. Always connect the HDMI Cable because the iPod iPhone iPad LED blinks, which causes a shutdown, if the power is turned on without the cable connected. Notes on assembling ∗1: Don't touch the cables to the Fuse Holder. SC-63...
Page 60
(11) Remove the seven screws. (BMZ30P040FTB) (12) Remove the four screws. (BBZ30P080FTB) CONNECT ASSY (13) Disconnect the two connectors. (14) Unhook the hook. (15) Disconnect the connector and then remove the DIGITAL MAIN ASSY. COMPONENT ASSY DIGITAL MAIN ASSY SC-63...
Page 61
(DIGITAL MAIN CN603 <-> CONNECT CN7801) CN603 (7) Connect the 27P board to board extension CN602 jig cable. (GGD1799) (COMPONENT CN8301 <-> DIGITAL MAIN CN901) DIGITAL MAIN ASSY CN7802 27P board to board CN7801 extension jig cable (GGD1799) CN8301 CONNECT ASSY COMPONENT ASSY Front SC-63...
Page 62
(2) Remove the A-DAC BRIDGE ASSY. AUDIO ASSY FILTER ASSY A-DAC BRIDGE ASSY D-FILTER BRIDGE ASSY Front (3) Remove the three screws. (BBZ30P080FTB) (4) Remove the FILTER ASSY (with the BT DIGITAL MAIN ASSY ASSY). BT ASSY FILTER ASSY Front SC-63...
Page 63
D-AMP_S ASSY Note: Fix the DIGITAL MAIN ASSY to the Hook of the Right Angle 85. DIGITAL MAIN ASSY Hook Right Angle 85 Front (3) Temporarily attach the D-AMP_S ASSY to the Rear Panel, using the two screws. (BBZ30P080FTB) SC-63...
Page 64
(2) and (3). (BBZ30P080FTB) (6) Remove the Rear Panel (with other ASSY). D-AMP_S ASSY (7) Attach the five screws. (IBZ30P150FCC) (8) Attach the screw. (BBZ30P060FCC) D-AMP_S ASSY (9) Connect the five connectors. CN4003 CN4004 CN4000 CN4001 CN4002 D-AMP_S ASSY SC-63...
Page 65
(7) Remove the five screws temporarily fixed in accordance with step (3) and (4). (BBZ30P080FTB) (8) Remove the Rear Panel (with other ASSY). (9) Attach the two screws. (AMZ30P060FTC) Refer to the step (5) to (1) of “[3-1] Remove the IR Cover” of “Disassembly” henceforth. SC-63...
No setting file Mismatching between the setting file and the specification of the A/V RECEIVER type to be loaded back Error due to Checksum, Signature Check, and Size Check Ejecting of USB device (during reading of the setting file) SC-63...
S C - 6 3 / U X J C B Region Writing finished 5. Pull out the AC cord. [Cautions] Writing of destination is not completed until the BridgeCo software starts. It takes about 70 seconds before the BridgeCo software starts. SC-63...
3. Connect the USB Memory to the USB terminal (A type) of the front panel. [Procedures] 1. While holding down "TUNE↑" key on the front panel, press "STANDBY ON/OFF" key and moves to the UPDATE PANEL mode. 2. The updating process is as follows. SC-63...
Page 70
Update Confirmation U P D A T E [PRESET ← ] [←] [→] Update Confirmation U P D A T E Y E S [ENTER] File searching A c c e s s i n g UPDATE FILE searching completed SC-63...
Page 71
Time required for updating varies, because only the programs that require updating will be updated. [Confirmation] Enter UPDATE PANEL mode and check that the programs have been updated. [Cautions] You cannot perform an update until the BridgeCo software starts. It takes about 70 seconds before the BridgeCo software starts. SC-63...
Screws adjacent to b mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 9.1 PACKING SECTION SC-63...
Page 73
See Contrast table (2) 14 Remote Control Unit SLW AXD7666 NSP 15 Dry Cell Battery (R3) VEM1051 (2) CONTRAST TABLE SC-63/UXJCB, SC-61/UXJCB, SC-1227-K/CUXJ and SC-1222-K/UXJCB are constructed the same except for the following: SC-63/ SC-61/ SC-1227-K/ SC-1222-K/ Mark No. Symbol and Description...
ASSY CN8001 FRONT HDMI USB ASSY JA8003 AUDIO ASSY FRONT HDMI USB JP3001 ASSY JP8001 CONPONENT ASSY JP8402 MIC HP ASSY CN3472 Refer to “9.5 FRONT SECTION” Double side tape 10 x 110mm DISPLAY ASSY JP3001 DISPLAY ASSY CN3001 SC-63...
Page 75
18 Bonnet 65 AZN8052 NSP 19 Panel Stay 85 ANG7684 20 Screw See Contrast table (2) (2) CONTRAST TABLE SC-63/UXJCB, SC-61/UXJCB, SC-1227-K/CUXJ and SC-1222-K/UXJCB are constructed the same except for the following: SC-63/ SC-61/ SC-1227-K/ SC-1222-K/ Mark No. Symbol and Description...
9.3 REAR SECTION PRIMARY ASSY JP51 FRONT HDMI USB ASSY CN8001 A-REG ASSY CN7502 V-REG ASSY CN7554 Refer to “9.4 CHASSIS SECTION” SC-63...
Page 77
18 15P FFC (J0002) ADD7764 19 9P FFC (J0006) ADD7781 20 Rear Panel See Contrast table (2) (2) CONTRAST TABLE SC-63/UXJCB, SC-61/UXJCB, SC-1227-K/CUXJ and SC-1222-K/UXJCB are constructed the same except for the following: SC-63/ SC-61/ SC-1227-K/ SC-1222-K/ Mark No. Symbol and Description...
Power Transformer DIGITAL MAIN ASSY CN9501 Acetate Tape Tape Tape Cleaning paper GED-008 Accessory of Panel Base IR REG ASSY CN7241 IR REG ASSY CN7271 IR REG ASSY CN7251 Accessory of Panel Base IR REG ASSY CN7401 COMPONENT ASSY CN8401 SC-63...
Page 79
ANG7746 23 PCB Mold AMR2533 24 Insulator ICE AMR7523 25 PCB Mold AMR7536 (2) CONTRAST TABLE SC-63/UXJCB, SC-61/UXJCB, SC-1227-K/CUXJ and SC-1222-K/UXJCB are constructed the same except for the following: SC-63/ SC-61/ SC-1227-K/ SC-1222-K/ Mark No. Symbol and Description UXJCB UXJCB...
Note ∗2: Please tape up at four (4) places to protect Panel Base 55U as shown on the photograph when you remove the Panel. Left side Right side Note ∗3: Double Side Tape (10mm x 30mm) affixing position on the Panel. Center line +0mm -1.5mm Inside SC-63...
Page 81
18 Damper ASSY (240) LX AXA7156 19 VOL. Knob LX55 AAA7068 20 STDBY BTN LX85 ASSY AAD7804 (2) CONTRAST TABLE SC-63/UXJCB, SC-61/UXJCB, SC-1227-K/CUXJ and SC-1222-K/UXJCB are constructed the same except for the following: SC-63/ SC-61/ SC-1227-K/ SC-1222-K/ Mark No. Symbol and Description...
*R3955 *R3956 awx1117 *R3957 awx1118 R3991 awx1250 *R3958 DAC OUT<-> PRE OUT R3992 J2501 AKB7246-A pattern A J2502 AKB7247-A R3993 J2503 GNDA J2504 AKB7246-A R3995 HP<-> J2505 AKB7247-A : Audio Signal Route ZONE OUT R3996 pattern A GNDA GNDA SC-63...
Page 83
The > mark found on some component parts indicates the importance of the safety factor of the part. HP<-> ZONE OUT R3996 pattern A Therefore, when replacing, be sure to use parts of identical designation. : The power supply is shown with the marked box. GNDA GNDA SC-63...
Page 91
Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. 1000p or less : CCSRCH, Over 1000p : CKSRYB 3. NM: No Mount mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. SC-63...
GND3 unless otherwise noted. CH : CCSRCH , CFTLA : CFTLA NO MARKED : CKSRYB or CEAK 3. NM: No Mount GNDSH mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical designation. SC-63...
3. NM : NO MOUNT CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND RATINGS OF FUSE. mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. SC-63...
Page 97
USB RECT ASSY (AWX1259) V+UN_USB C3657 CN3652 V+UN_USB GNDUSB JP8001 C3656 B2B-EH NDUSB KN3651 AKF7002-A OF FIRE, SC-63...
Page 101
TUSDA IRMUTEFH R690 C732 R698 232POW/TURST RFPOW C743 XTURST TUIREQ RYFW(NC) R811 R640 GNDD AKN7071-A C125Z2-19(COSMOS) GNDD Rear Side CN7802 mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. 2/10 SC-63...
Page 103
DSCL2 HDSW_3R3OUT SDA_5 R9682 DSDA2 R9186 V+5_F C9184 R9657 (2125) DCH1201-A R9683 HPD_F C9156 330p/50 V+3R3_HHH R9631 R9637 mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. 4/10 HDMI_Rx 3/10 SC-63...
C1675 D1FDT R1637 R1649 R1659 R1641 R1651 D1BCK R1644 R1657 R1653 R1660 R1647 R1655 IC1601 TC74VHC08FK GNDD D1LRCK TXMCLKI 7/10 mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. 6/10 SC-63...
Page 111
R9815 *C9823 820p/50 0.01u/25 (1608) R9883 C9822 (1608) R9816 GNDDAC mark found on some component parts should be replaced R1515 (1608) GNDDACP with same parts (safety regulation authorized) of identical GNDDAC R1516 (1608) GNDD GNDDACZ designation. GNDDAC GNDD 7/10 SC-63...
CH : CCSRCH , CFTLA : CFTLA *JA7003 NO MARKED : CKSRYB or CEAK 3. NM: No Mount 12V TRG1 *Q7003 RT1N241M 12V TRG2 mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical AKN-209-A 12VTRG2 designation. GNDV SC-63...
Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. 10p/50 *C8619 *R8630 AK : CEAK *R8634 1000p or less : CCSRCH, Over 10u and 2125 : CKSQYB *C8616 NO MARKED : CKSRYB 3. NM: No Mount *R8631 GNDCH232 GNDD GNDV SC-63...
Page 121
C8393 : Video Signal Route with same parts(safety regulation authorized) of identical wise noted. *C8394 ) unless otherwise noted. : Video Signal Route designation. 47p/50 10u and 2125 : CKSQYB *R8629 : Video Signal Route GNDV GNDD SC-63...
R3019 3 GND S3005 JOGA JOG_A ASG7029-A C3346 JOGB JOG_B TUNER EDIT GNDD (HOME THX/STEREO) CHEMICON2 BOTTOM 51048-0300 SOUND GNDD GNDD CN3501 mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical designation. SC-63...
Page 151
3216 SIZE mark found on some component parts should be replaced RS1/16S*** RS1/10S*** RS1/8S*** 2125 3216 with same parts(safety regulation authorized) of identical RN1/16S*** RS1/8SQ*** RS1/4SA*** 2125 3216 1/8W 1/4W CCSR*** designation. CCSQ*** CCS*** 6/10 CKSR*** 2125 3216 CKSQ*** CKS*** SC-63...
CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND SAME RATING OF FUSE. JV71 JUMPER *S81 JV87 *CN81 JUMPER_JV 2VOL-SW *JV81 MAIN JUMPER TRANS INC2002AC1 *JV82 JUMPER B2P3-VH *JV83 JUMPER JV84 *CN82 JV85 JV86 MAIN TRANS G_CHASSIS1 G_CHASSIS1 SC-63...
Page 161
MUF : RD1/4MUF 2. CAPACITORS designation. Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CH : CCSRCH , CFTLA : CFTLA AK : CEAK NO MARKED : CKSRYB or CEAT 3. NM: No Mount SC-63...
JH7254 JH7255 AEF7008-A AEF7008-A AEF7008-A AEF7008-A FU13 H7252 H7251 D7251 1SR154-400 AKR1004-A-T D7252 1SR154-400 D7253 FU14 1SR154-400 D7254 H7254 H7253 AKR1004-A-T 1SR154-400 CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND RATINGS OF FUSE. SC-63...
CH : CCSRCH , CFTLA : CFTLA NP : CEANP , AK : CEAK NO MARKED : CKSRYB or CEAT 3. NM: No Mount mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical designation. SC-63...
(AWX1168) AEF7008-A AEF7008-A AEF7008-A JH5924 JH3551 JH5921 P WIRE GUARD ASSY FFC GUARD ASSY (AWX1229) (AWX1167) JH3560 AEF7008-A BIND FAN CABLE ASSY VREG GUARD ASSY (AWX1231) (AWX1153) AD AE AF AG AH AI AD AE AF AG AH AI SC-63...
10.54 TRANS VREG STYL, IR EDGE GUARD and PANEL GUARD ASSYS TRANS VREG STYL ASSY IR EDGE GUARD ASSY (AWX1256) (AWX1230) PANEL GUARD ASSY (AWX1154) AJ AK AL AJ AK AL SC-63...
Q8001 C8010 IC8002 IC8002 Q8005 C8004 Q8008 MHL_CTL C8002 [[ G ]] Q8006 R8001 2 3 4 A30C5/C7 Q8006 R8005 Q8009 Q8009 D8006 F-HDMI USB ASSY (ANP7827-A) SIDE B SIDE B FRONT HDMI USB ASSY (ANP7827-A) JA8003 JP8001 CN8001 SC-63...
PAR LE FUSIBLE PAR UN MODELE IDENTIQUE EN INTENSITE C3658 AWX1166 C3666 C3665 JV3651 R3651 1.V+UN_USB 2.GND_USB JH3651 [[ G ]] USB RECT ASSY KN3651 D3651 (ANP7832-A) SIDE B SIDE B USB RECT ASSY C3662 C3661 R3653 (ANP7832-A) CN3653 SC-63...
SIDE A SIDE A MIC HP ASSY 1148 AWX 1149 J3459 CN3472 HP R MICDET J3456 J3458 J3454 V+7_A AMUTE GNDA J3457 C3484 C3483 C3478 JA3476 KN3472 KN3471 MIC HP Ass'y [[ G ]] J3451 (ANP7828-A) GNDCH1 JA3471 C3474 SC-63...
11.11 VOL, POWER SW and ENCODER ASSYS SIDE A SIDE A VOL ASSY VOL Ass'y S3371 NO CLICK AWX1134 J3371 GNDD CN3371 (ANP7828-A) POWER SW ASSY 1.V+5_EV_1 2.POWLED 3.POWER_KEY 4.GNDD (ANP7828-A) ENCODER ASSY S3501 Click ENCODER Ass'y AWX1150 J3501 CN3501 (ANP7828-A) K L M SC-63...
Page 211
GNDD CN3371 (ANP7828-A) POWER SW ASSY ¡AWX1135 ¡AWX1151 ¡AWX POWER SW Ass'y 1.V+5_EV_1 2.POWLED 3.POWER_KEY 4.GNDD Q3401 CN3401 C3401 V+5_EV [[ G ]] (ANP7828-A) ENCODER ASSY C3501 C3502 [[ G ]] ENCODER Ass'y 1150 CN3501 (ANP7828-A) K L M SC-63...
C4601 L4100 L4600 L4200 L4700 L4500 C4200 C4100 C4700 C4600 RY4100 RY4700 RY5000 RY4500 DATA C5110 XOLERR XBERR BOND ICEMUTEA ICEMUTESB C4710 MUTEFH RY FW RY AF C4110 RY CR RY FH RY B AMPTEMP XTEMPERR5 XDCERR GNDHD GNDHD SC-63...
11.15 PRIMARY ASSY SIDE A PRIMARY ASSY PRIM SECONDARY PRIMARY SIDE SIDE KN50 The Parts must not enter this area. BOND SC-63...
Page 223
SIDE A AC CORD AC CORD MAIN TRANS JA71 JA71_1 CN81 PRIMARY Ass'y T2A H 250V CAUTION -REPLACE FUSE LINKS AS MARKED. FU4 215002. MFD.BY LITTELFUSE INC. (ANP7828-A) SC-63...
FAN_CONNECT_S ASSY A30C5/C7 ¡AWX ¡AWX1130- CN3651 JP7291 BT ASSY BT ADAPTOR ASSY [[ G ]] R8815 A30C5/C7 C8808 R8816 AWX1196 C8802 C8801 KN8801 C8807 JA8801 VIA‹ÖŽ~ MIC HP GUARD ASSY JH5921 DO NOT THROW! JANGAN BUANG AB AC AD SC-63...
Page 243
SIDE A (ANP7825-A) CN3652 C8810 R8816 C8811 C8802 C8801 C8809 VIA‹ÖŽ~ CN8801 (ANP7809-B) AWX1152 UANG MIC HP GUARD Ass'y JH5924 (ANP7828-A) SC-63...
Page 244
SIDE B FAN CONNECT_S ASSY 1.V+FAN 2.V-FAN 3.LOCK_DET CN3652 CN3652 BT ASSY MIC HP GUARD ASSY AWX1152 MIC HP GUARD?@Ass'y AB AC AD SC-63...
Page 245
SIDE B FAN_CONNECT_S ASSY ¡AWX1130- ¡AWX 1.V+FAN 2.V-FAN 3.LOCK_DET CN3651 (ANP7825-A) CN3651 (ANP7809-B) DO NOT THROW! [[ G ]] JANGAN BUANG (ANP7828-A) SC-63...
BIND DM CABLE ASSY [[ G ]] AWX1168 JH3551 BIND DM CABLE ASSY DO NOT THROW! JANGAN BUANG! (ANP7832-A) P WIRE GUARD ASSY [[ G ]] JH3560 RIVET BIND AWX1229 DON'T THROW! RIVET P_WIRE_GUARD ASSY JANGAN BUANG (ANP7832-A) AE AF SC-63...
Page 247
SIDE B SIDE B BIND DM CABLE ASSY [[ G ]] AWX1168 BIND DM CABLE ASSY DO NOT THROW! JANGAN BUANG! (ANP7832-A) P WIRE GUARD ASSY BIND AWX1229 DON'T THROW! P_WIRE_GUARD ASSY JANGAN BUANG (ANP7832-A) AE AF SC-63...
BUANG TRANS VREG STYL ASSY (ANP7832-A) BIND FAN CABLE ASSY DON'T THROW! (ANP7831-B) IR EDGE GUARD ASSY AWX1230 IR EDGE GUARD ASSY (ANP7832-A) [[ G ]] DO NOT THROW rivet A30C5/C7 JANGAN BANG (ANP7829-A) AG AH AI AJ AK SC-63...
Page 249
VREG GUARD ASSY NO USE AWX1153 DO NOT THROW! JANGAN BUANG (ANP7828-A) TRANS VREG STYL ASSY (ANP7832-A) AWX1256 DON'T THROW! BIND FAN CABLE ASSY JANGAN BUANG TRANS-VREG_STYL ASS'Y (ANP7831-B) IR EDGE GUARD ASSY (ANP7832-A) (ANP7829-A) AG AH AI AJ AK SC-63...
Page 251
CKSRYB104K50 Not used C7011 CKSRYB104K50 Not used C7012 CCSRCH102J50 Not used C7013 CKSRYB103K50 Not used C7015 CKSRYB104K50 Not used C7016 CKSRYB103K50 Not used C7026 CKSRYB153K50 Not used C7112 CEAK221M16 Not used C7113 CCSRCH331J50 Not used C7114 CKSRYB104K50 Not used SC-63...
Page 252
D7554 1SR154-400 Not used D7555 1SR154-400 Not used 7551 Screw BBZ30P080FCC Not used 7552 Heat Sink ANH7251 Not used C7551 CKSRYB103K50 Not used C7552 CKSRYB103K50 Not used C7554 CEAK471M35-F Not used C7555 CEAK100M50 Not used C7557 CEAK102M35-F Not used SC-63...
Page 253
PCB PARTS LIST FOR SC-63/UXJCB UNLESS OTHERWISE NOTED Mark No. Description Part No. Mark No. Description Part No. C 2683,2691,2692,2699 CKSRYB103K50 AUDIO ASSY C 2693,2694,2828,2836 ACH1479 C 2695,2696,2834,2835 CFHXSQ103J16 C 2700,2703,2704,2759 CCSRCH101J50 SEMICONDUCTORS C 2701,2702,2705,2706 CKSRYB103K50 IC 2501,3273 BD3473KS2 IC 2701...
Page 254
IC 903 SII9233ACTU R 8022 RS1/10SR0R0J IC 909 ADV7181CBSTZ R 8044 RS1/16SS1801F IC 1204 88DE2750 R 8045 RS1/16SS2200F IC 1212 H5PS5162GFR-S5C R 8046 RS1/16SS8201F > IC 1216 LP2996M R 8055 RS1/4SA105J IC 1504 TC7SET08FUS1 Other Resistors RS1/16SS###J IC 1602 SII9136CTU SC-63...
Page 255
RAB4CQ100J L 1605,1806,1808-1810 CHIP BEADS VTL1129 R 872,1115,1518,1520 RS1/10SR0R0J L 1609-1612 COIL ATH7064 R 907,909,956,1343 RAB4CQ473J L 1617 CHIP BEADS VTL1126 R 910,911,913,914 RAB4CQ330J L 1618 FERRITE BEAD CTF1528 R 917,919,920,923 RAB4CQ330J L 1804,1807,1812,1813 RESISTOR RS1/16SS1R0J R 924,1041,1047-1049 RAB4CQ330J SC-63...
Page 256
C 182,193,215,403 CCSSCH100D50 C 993,1529,1648,1870 CKSSYB472K50 C 185,202-205,223 CKSSYB104K16 C 995,1207,1208,1355 CEVW221M4 C 186,187,1095-1097 CCSSCH7R0D50 C 997,1062,1088,1361 CCSSCH100D50 C 199-201,612,614 CKSSYB103K25 C 401,426,430,613 CKSSYB104K16 C 1025,1031,1042,1064 CEVW101M4 C 1026,1032,1034,1038 CKSSYB104K16 C 1027,1033,1041,1081 CCSSCH101J50 C 1028,1036 CCSSCH270J50 C 1035,1037,1046,1070 CCSSCH331J50 SC-63...
Page 257
C 9276,9282,9283,9286 CKSSYB103K25 C 1701,1824,1830,1851 CCSSCH331J50 C 9280,9288,9294,9311 CKSSYB104K16 C 1801,1814,1822,1891 CEVW221M10 C 9285,9403,9405,9433 CCG1222 C 1806,1819,1938,9075 CKSRYB104K50 C 9287,9293,9295,9310 CCSSCH101J50 C 1807,1893,9011,9019 CCSSCH101J50 C 9290,9292,9333,9638 CKSSYB103K25 C 1815,1823,1827,1828 CKSSYB104K16 C 9297,9326,9429 CCSSCH102J50 C 1821,9004,9005,9029 CEVW101M4 C 9298-9300 ACG1150 SC-63...
Page 258
L 7001 CHIP SOLID INDUCTOR ATL7002 CN 8303 20P PLUG AKM7171 L 7005-7007 CHIP SOLID INDUCTOR QTL1013 CN 8401 PLUG(2P) KM200NA2L JA 7001,7004,7005 JACK VKB1243 JP 8402 CONNECTOR ASS'Y PF04PG-S10 JA 7002 MINI JACK QKN1013 JA 7003 JACK AKN-209 SC-63...
Page 259
JA 3605 1P PIN JACK AKB7231 D 3003,3006 1SS302 CN 3601 20P SOCKET AKP7249 D 3004 1SS301 D 3005 1SS300 RESISTORS R 3606,3609,3627 RS1/10SR68R0F D 3204,3206,3208,3210 SLR343BC4T(JKLM) R 3629-3632 RS1/10SR75R0F D 3212 SLR343BC4T(JKLM) Other Resistors RS1/10SR###J D 3214 1SS355 SC-63...
Page 260
R 6861,6862,6867,6868 RS1/10SR5601F R 6869,6889 RS1/10SR1000F MISCELLANEOUS R 6881,6882,6887,6888 RS1/10SR5601F S 3371 ROTARY ENCODER ASX7053 CN 3371 3P JUMPER CONNECTOR 52147-0310 R 6886,7456,7476 RS1/10SR22R0F R 6896,7465,7466,7485 RS1/8SQ225J CAPACITORS R 6915,6916,6935,6936 RS1/8SQ0R0J C 3371,3372 CKSRYB103K50 R 7451,7452,7457,7458 RS1/10SR5601F R 7471,7472,7477,7478 RS1/10SR5601F SC-63...
Page 262
R 4342,4343,4442,4443 ACN7189 R 4788,5003,5004,5026 ACN7180 R 4352,4357,4452,4457 RS1/10SR6802F R 4795-4798 RS1/8SQR47J R 4355,4368,4455,4468 RS1/10SR4702F R 4807,4822,4887,4888 RS1/4SA0R0J R 4367,4419,4420,4467 RS1/10SR1001F R 4388,4407,4487,4488 ACN7180 R 4907,4922,4987,4988 RS1/4SA0R0J R 5006-5009 RS1/4SA105J R 5011,5017,5025 RS1/8SQ473J R 5012,5013,5016,5020 RS1/8SQ104J R 5014,5022 RS1/8SQ683J SC-63...
Page 263
CFHXSQ102J50 > R 1,12 RS2LMF683J C 4467,4566,4567,4666 ACH1479 > R 9-11 ACN7173 C 4480,4482,4580,4582 ACE7090 R 14 RS1/10SR1001F R 53 RS1/10SR1202F C 4500,4600,4700 CFTLA104J2A R 54 RS1/10SR7500F C 4501,4601,4701 CFTLA474J2A C 4508,4509,4608,4609 ACH7320 C 4510,4710,5110 CEAK100M50 C 4519,4619,4719 ACG7110 SC-63...
Page 264
IR REG ASSY C 7255,7256 CEAK221M35 C 7271,7272 CEAK222M16 SEMICONDUCTORS C 7275,7276 CEAK221M16 > IC 7241 NJM78M15FA C 7400,7401 ACH7258 > IC 7251 NJM78M12FA C 7402,7403 CFTLA104J2A IC 7252 NJM79M12FA > IC 7271 NJM78M08FA > > IC 7272 NJM79M08FA SC-63...
Page 265
CN 7182,7184 B TO B 13PIN PLUG AKM7102 C 7901,7903,7909,7915 CCSRCH100D50 C 7916,7936 CCSRCH100D50 C 7923 CKSRYB105K16 PRE BRIDGE ASSY MISCELLANEOUS CN 6953,6954 B TO B 19PIN PLUG AKM7105 VREG CHILD ASSY SEMICONDUCTORS IC 8701 NJM78M05FA > IC 8702 NJM79M05FA > D 8702,8703 1SS355 SC-63...
Page 266
P WIRE GUARD ASSY MISCELLANEOUS JH 3560 PCB BINDER AEF7008 FFC GUARD ASSY FFC GUARD ASSY has no service parts. BIND FAN CABLE ASSY BIND FAN CABLE ASSY has no service parts. VREG GUARD ASSY VREG GUARD ASSY has no service parts. SC-63...