13.49
AIR SEPARATOR FJLTER ELEMENT
13.49 AIR SEPARATOR FILTER ELEMENT
The closed breather system consists of an air separator assembly mounted to the inlet side of
each turbocharger. See Figure 13-21.
1
31771
1. Tulbine Housing
3. Vacuum Limiter
2. Compressor Housing
4. Air Separator Assembly
Figure 13-21
Typical Air Separator System
To operate efficiently, air separator filters and vacuum limiters must
be
properly maintained.
□
Clean and oil the vacuum limiter and filter element every 250 hours of engine operation or
once a year, whichever comes first. Refer to section 13.49.1, refer to section 13.49.2, and
Refer to section 13.49.4.
NOTE:
Filter elements and vacuum limiters must also be cleaned and oiled any time the
restriction gage shows red.
□
Filter elements must be replaced after three cleanings.
□
Replace vacuum regulatornimiters every 1000 hours of engine operation or every two
years, whichever comes
first.
13-108
Nf
if'llormalion
subject
to
change
without notics..
6SE379 9909 Copyright
Q
!999 DETROIT DIESEL CORPORATION
•
•