Rules For Safe Operation.5; Assembly.6 - MTD 140-840-000 Owner's Manual

I
Rules for Salfe Operation (continued)
32. When using the vehicle with mower, proceed as fol ows:
(1) Mow only in daylight or in good artificial light.
(2) Never make a cutting height adjustment while engin
i
is running
if operator must dismount to do so.
(3) Shut the engine off and wait until the blade comes to
i
complete
stop before removing the grass catcher.
(4) Check blade mounting bolts for proper tightness at f equent in¬
tervals.
33. Check grass catcher bags frequently for wear or deterir ration. For
safety protection, replace only with new bag meeting orii jinal equip¬
ment specifications.
34. Look behind to make sure the area is clear before placing the
transmission in reverse and continue looking behind while back¬
ing up. Disengage blades before shifting into reverse and backing
UP;
35. This unit should not be driven up a ramp onto a trailer or truck
under power, because the unit could tip over, causing serious per¬
sonal injury. The unit must be pushed manually to load properly.
36. Check brake operation frequently. Adjust and service according
to brake adjustment instructions in this manual.
ASSEMBLY
This owner's manual covers various models of tractors. The units illustrated may vary slightly from your
unit. Follow the instructions which pertain to your unit.
IMPORTANT: This unit is shipped W THOUT GASOLINE or OIL; however, a small amount of oil may
be present from the factory. Do not overfill. After assembly, service engine with gasoline
and oil as instructed ii the separate engine manual packed with your unit,
■1^ NOTE: Reference to right or l(!ft hand side of the unit is observed from the driver's seat, fac¬
ing forward. Refer to the separate deck manual for all information concerning the deck.
UNPACKING
1. Remove the carton from the tractor as folio ws. Cut
and remove the bands around the carter. Open
the top flaps and remove all carton inserts. Lift the
carton off the tractor. Remove the deck from
beneath the tractor. Roll the tractor off tf e skid.
Make certain all parts and literature have been
removed from the carton before the certon is
discarded.
2. Remove page four from this manual and lay the
contents of the hardware pack on the illuiitration
for identification.
BATTERY INFORMATION
A
WARNING
A. Battery acid must be handled with great c are as
contact with it can burn and blister the skin. Ii is also
advisable to wear protective clothing (goggkss, rub¬
ber gloves and apron) when working with t.*
B. Should battery acid accidentally splatter into the
eyes or onto the face, rinse the affected area im¬
mediately with clean, cold water. If there is any
further discomfort, seek prompt medical attention.
C. If acid spills on clothing, first dilute it with clean
water, then neutralize with a solution of ammonia/
water or baking soda/water.
D. Since battery acid is corrosive, do not pour it into
any sink or drain. Before discarding empty elec¬
trolyte containers, rinse them with a neutralizing
solution.
E. NEVER connect or disconnect charger clips to bat¬
tery while charger is turned on as it can cause
sparks.
F. Keep all lighted materials (cigarettes, matches,
lighters) away from the battery as the hydrogen gas
generated during charging can be combustible.
G. As a further precaution, only charge the battery in
a well-ventilated area.
*Always shield eyes, protect skin and clothing
when working near batteries.
6