Table of Contents
Advertisement
Quick Links
0
Fire Garden™
Voracious Fire™
Fire Pit Burner
10" Fire Pit Burner
13" Fire Pit Burner
18" Fire Pit Burner
22" Fire Pit Burner
32" Fire Pit Burner
Omni-Test Laboratories, Inc.
Report # 0028GM127S
ANSI Z21.97-2017 /CSA 2.41-2017, CSA 2.17-2017
Outdoor Decorative Gas Appliances
DANGER
This appliance can produce carbon
monoxide which has no odor.
Using it in an enclosed space can kill
you.
Never use this appliance in an
enclosed space such as a camper,
tent, car, or home.
French language manuals at outdoorfiregarden.com. Manuels de langue Française à outdoorfiregarden.com
Travis Industries, Inc.
$10.00
By Travis Industries, Inc.
Manual
Listed by
CARBON MONOXIDE HAZARD
12521 Harbour Reach Dr., Mukilteo, WA 98275
Copyright 2023, T.I.
FIRE OR EXPLOSION HAZARD
If you smell gas:
Shut off gas to the appliance.
•
Extinguish any open flame.
•
If odor continues, leave the area
•
immediately.
After leaving the area, call your gas
•
94900340
supplier or fire department.
94900341
Failure to follow these instructions
94900342
could result in fire or explosion, which
94900343
could cause property damage, personal
94900344
injury, or death.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
Installation and service must be
performed by a qualified installer,
service agency, or the gas supplier.
adjustment, alteration, service, or
maintenance can cause injury or
property damage. Read the installation,
operating, and maintenance
instructions thoroughly before
installing or servicing this equipment.
manual is not followed exactly, a fire or
explosion may result causing property
damage, personal injury, or loss of life.
INSTALLER: Leave this manual with the
appliance.
CONSUMER: Retain this manual for
future reference
DANGER
WARNING
WARNING: For outdoor use only.
WARNING: Improper installation,
WARNING: If the information in this
www.travisproducts.com
Part # 100-01589
Advertisement
Table of Contents
Related Manuals for Travis Industries Fire Garden 94900340
Summary of Contents for Travis Industries Fire Garden 94900340
- Page 1 By Travis Industries, Inc. DANGER Fire Garden™ FIRE OR EXPLOSION HAZARD If you smell gas: Voracious Fire™ Shut off gas to the appliance. • Fire Pit Burner Extinguish any open flame. • Manual If odor continues, leave the area •...
-
Page 2: Overview
Carbon Monoxide and Benzene, which are known to the State of California to cause cancer, birth defects, or other reproductive harm. For more information go to www.P65Warnings.ca.gov. © Travis Industries, Inc. 9/27/23 - 1589 VF Outdoor Fire Pit Burners... -
Page 3: Table Of Contents
LP Conversion ............23 Wiring Diagram ............40 LP Conversion Steps ..........23 Index ................44 LP Conversion Steps – Cont......... 24 Electrical Connection Requirements ......25 © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 4: Safety Precautions
Direct questions Travis Industries, Inc. grants no warranty, about the type of fuel used to your dealer. A label implied or stated, for the installation or... -
Page 5: Features
(2) – #19 (2) - #31 Input Rating 32" Fire Pit Input Rating (BTU/h) 350,000 350,000 Burner Orifice Size (DMS) (4) - #21 (4) - #36 © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 6: Vf Fire Pit Burner Dimensions
Features and Specifications VF Fire Pit Burner Dimensions: © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... - Page 7 Features and Specifications © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners...
- Page 8 Features and Specifications © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners...
-
Page 9: Installation Warnings
12. Finalize the installation. Install the crushed glass, crushed glass with an optional Bonfire log set (sold separately), or tumbled stone media. 13. Give the manual to the homeowner and explain the operation of the appliance. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 10: Packing List
94601221 94601222 37” 37” Contact dealer for details 22" Fire Pit Burner 94601225 94601226 94601227 47” 47” Contact dealer for details 32" Fire Pit Burner 94601230 94601231 94601232 © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... - Page 11 Travis Industries does not recommend or encourage the use of any media in this appliance except that which has been tested and is provided through an authorized Travis Industries dealer.
-
Page 12: Installation Overview
Below you will find a basic overview of the main components and how they are connected for a typical Voracious Fire Pit Burner installation. NOTE: Not everything shown is included with the VF fire pit (see “Additional Items Needed”). © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 13: Weatherproofing The Installation
In places where the controls beneath the appliance may be submerged underwater. Submerging any part of its controls may require the complete replacement of the controls. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 14: Clearances
Installation (qualified installers only) Clearances © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... - Page 15 Installation (qualified installers only) © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners...
- Page 16 Installation (qualified installers only) © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners...
-
Page 17: Minimum Framing Dimensions
Multiply that by 2 and add it to the width of the bottom plate. That calculation provides you with the minimum inside width of the enclosure. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 18: Landscaping Block Enclosures
(842mm x 842mm) (943mm x 943mm) (1197mm x 1197mm) Round 25-1/8” diameter 28-1/8” diameter 33-1/8” diameter 37-1/8” diameter 47-1/8” diameter Base Plate (639mm) (715mm) (842mm) (943mm) (1197mm) © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 19: Enclosure Ventilation Requirements
Facing may be applied over the flange of the grills but cannot protrude over the screened opening. The grills may be painted. The grills must be located within 24” of the appliance. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 20: Landscaping Block Enclosure Ventilation
The vents must be installed on opposite sides from each other. The vents must be installed in the first course of brick in the enclosure. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 21: Assembling The Base Plate
Secure the secondary base plates to the main base plate. Use a 7/16” ratchet or nut driver to tighten the nuts on the underside of the brackets to secure the plates. Repeat the same steps with the other secondary base plate panel. © Travis Industries, Inc. 11/22/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 22: Gas Line Requirements
Connect the incoming gas line to the key valve using either flex and an adapter or hard pipe (not included). © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 23: Lp Conversion
2. Unscrew the appliance adapter from the air mixing tube as shown to the right. 3. Remove the appliance adapter and the attached NG burner orifice from the mixing tube © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 24: Lp Conversion Steps - Cont
8. Reattach the gas flex to the appliance adapter. Make sure to check this connection to make sure there is no gas leak after installation. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 25: Electrical Connection Requirements
This appliance must be used with a 24VAC switched circuit. The transformer is sold separately. Travis Industries offers the following transformer: -- sku# 94800830 - 120v input only with 24v (white wire), 26v (yellow wire), and 28v (blue wire) output leads. -
Page 26: Wiring Installation
When the connections are secure, coil the wires and push them back into the electrical box. Replace the cover and screws removed in the first step. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 27: Using More Than One 24-Volt Appliance
(qualified installers only) Using More than One 24-volt Appliance Travis Industries, Inc. manufactures other 24-volt appliances that can add to the ambiance of your outdoor space (Tempest Torch™, Tempest Lantern™. Visit firegardenoutdoor.com for more details). If using more than one appliance, make sure to think about how the appliances will be used and if they need to be able to be controlled separately or if it would be more convenient to control them all using one switch. -
Page 28: Wiring Multiple Appliances To One Transformer
The manner in which you wire the appliances to the transformer affects the maximum length of wire and wire gauge. Make sure to determine the wire configuration before installation. NOTE: You may use both direct-run and daisy-chain configurations. Daisy-Chain Example Direct-Run Example © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 29: Daisy-Chain Wire Length Chart
Daisy-Chain Wire Length Chart This type of wire configuration allows for multiple Travis Industries 24-volt products to be wired in a series, reducing the amount of wire used. Use the charts below to determine the correct wire gauge and length. In the example below, the transformer has 2 Tempest Lanterns and a VF Fire Pit Burner on one branch. -
Page 30: Direct-Run Wire Length Chart
The wire will also be printed with a gauge number (e.g., AWG#14 = 14 gauge, 10AWG = 10 gauge, etc.). Do not use wires of dissimilar sizes (do not use 14-gauge & 10-gauge wire on the same transformer). © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 31: Steps For Finalizing The Installation
5. Test burn the appliance. Crushed Glass Installation Crushed glass may be placed over the burner and base plate. Use only 1/4” crushed glass from Travis Industries and/or other media specifically approved by Travis Industries. Placing Crushed Glass on the Burner and Fire Pit Base Plate... -
Page 32: Tumbled Stone Installation
Large stones may be placed anywhere on the media tray that is aesthetically pleasing but should not be placed directly over the burner. Don’t cover with Don’t cover with large stones. any stones. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 33: Before The First Fire
If the flame goes out the control module will shut the gas off, then try to relight the appliance. Your appliance can not be operated manually if a problem persists consult the troubleshooting guide (pg. 38) and call a qualified service technician if needed. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 34: Location Of Controls
If the wall switch will be located where it is not protected from precipitation, it must be installed in a weather resistant enclosure (not included). © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 35: Maintaining Your Appliance
Once maintenance or testing of components is complete, follow the above steps in reverse to return the appliance to its proper configuration. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 36: Winterizing The Appliance
Start the burner. After 15 minutes, the flames should be orange/yellow. If the appliance is not burning correctly, contact your dealer for service. If the igniter is not getting hot or lighting the appliance properly contact your dealer for service. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 37: Replacement Parts List
Maintenance Replacement Parts List CAUTION: Use only Travis Industries replacement parts. Do not use substitute materials. REPLACEMENT PARTS GAS CONTROL VALVE 250-05704 THERMOPILE 250-04550 IGNITER 250-04549 CONTROL MODULE 250-04553 BURNER ORIFICE - (#19) 250-06426 BURNER ORIFICE - (#21) 250-06131 BURNER ORIFICE - (#30) -
Page 38: Troubleshooting Table
(spider webs, etc.) from the burner and dirty or blocked orifice area. Glass is Sooting Wind will influence the flame quality and, if Windy Condition persistent, may lead to sooting on the glass. © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... -
Page 39: Warranty
Register your TRAVIS INDUSTRIES, INC. Limited 7 Year Warranty online at traviswarranty.com. TRAVIS INDUSTRIES, INC. warrants this gas appliance (appliance is defined as the equipment manufactured by Travis Industries, Inc.) to be defect-free in material and workmanship to the original purchaser from the date of purchase as follows: Check with your dealer in advance for any costs to you when arranging a warranty call. -
Page 40: Wiring Diagram
Notes Wiring Diagram © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners... - Page 41 Notes © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners...
- Page 42 Notes © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners...
- Page 43 Notes © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners...
-
Page 44: Index
Using More than One 24-volt Appliance ..27 Gas Specifications ..........5 Winterizing the Appliance ........ 36 Installation Warnings .......... 9 Yearly Service Procedure ........ 36 Landscaping Block Enclosures ......18 Index © Travis Industries, Inc. 9/27/2023 - 1589 VF Outdoor Fire Pit Burners...