Travis Industries Fire Garden 94900432 Manual
Outdoor linear complete fire pit
Hide thumbs
Also See for Fire Garden 94900432:
Table of Contents
Advertisement
Quick Links
F0
Fire Garden™
Outdoor Linear Complete Fire Pit
48x24 Complete Fire Pit
72x24 Complete Fire Pit
84x24 Complete Fire Pit
108x24 Complete Fire Pit
132x24 Complete Fire Pit
Omni-Test Laboratories, Inc.
Report # 0028GM127S
ANSI Z21.97-2017 /CSA 2.41-2017, CSA 2.17-2017
Outdoor Decorative Gas Appliances
DANGER
This appliance can produce carbon
monoxide which has no odor.
Using it in an enclosed space can kill
you.
Never use this appliance in an
enclosed space such as a camper,
tent, car, or home.
French language manuals at outdoorfiregarden.com. Manuels de langue Française à outdoorfiregarden.com
Travis Industries, Inc.
$10.00
By Travis Industries, Inc.
Manual
94900432
94900449
94900453
94900461
94900467
Listed by
CARBON MONOXIDE HAZARD
12521 Harbour Reach Dr., Mukilteo, WA 98275
Copyright 2022, T.I.
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
Shut off gas to the appliance.
•
Extinguish any open flame.
•
If odor continues, leave the area
•
immediately.
After leaving the area, call your gas
•
supplier or fire department.
Failure to follow these instructions
could result in fire or explosion, which
could cause property damage, personal
injury, or death.
WARNING
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
WARNING: For outdoor use only.
Installation and service must be
performed by a qualified installer,
service agency, or the gas supplier.
WARNING: Improper installation,
adjustment, alteration, service or
maintenance can cause injury or
property damage. Read the installation,
operating, and maintenance
instructions thoroughly before
installing or servicing this equipment.
WARNING: If the information in this
manual is not followed exactly, a fire or
explosion may result causing property
damage, personal injury, or loss of life.
INSTALLER: Leave this manual with the
appliance.
CONSUMER: Retain this manual for
future reference
www.travisproducts.com
Part # 100-01579
Advertisement
Table of Contents
Related Manuals for Travis Industries Fire Garden 94900432
Summary of Contents for Travis Industries Fire Garden 94900432
- Page 1 By Travis Industries, Inc. Fire Garden™ DANGER FIRE OR EXPLOSION HAZARD Outdoor Linear Complete Fire Pit If you smell gas: Shut off gas to the appliance. Manual • Extinguish any open flame. • If odor continues, leave the area •...
-
Page 2: Overview
Carbon Monoxide and Benzene, which are known to the State of California to cause cancer, birth defects, or other reproductive harm. For more information go to www.P65Warnings.ca.gov. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 3: Table Of Contents
Wiring Multiple Transformers to One Switch ....22 Wiring Diagram ..............41 Wiring Multiple Appliances to One Transformer ....23 Index ................44 Daisy-Chain Example ..........23 Direct-Run Example ............ 23 © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 4: Safety Precautions
The instructions in this manual must be strictly Travis Industries, Inc. grants no warranty, adhered to. Do not use makeshift methods or implied or stated, for the installation or compromise in the installation. Improper maintenance of your appliance, and assumes installation will void the warranty and safety listing. -
Page 5: Features
(2) - #43 (1) - #41 (1) - #41 Input Rating 132x24 Input Rating (BTU/h) 240,000 240,000 Fire Pit Orifice Size (DMS) (4) - #30 (4) - #43 © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 6: Linear Fire Pit Dimensions
Features and Specifications Linear Fire Pit Dimensions: © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... - Page 7 Features and Specifications © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits...
-
Page 8: Installation Warnings
The requirements listed below are divided into sections. All requirements must be met simultaneously. The order of installation is not rigid – the qualified installer should follow the procedure best suited for the installation. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 9: Recommended Order Of Installation
84”, 108”, & 132” Pit – (2) ends, (2) sides with logos, and (2) sides without logos LP Conversion Kit - see “LP Conversion” on page 15 for details. Wall Switch and wall switch cover. 3” gas shutoff key. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 10: Additional Items Required
Travis Industries does not recommend or encourage the use of any media in this appliance except that which has been tested and is provided through an authorized Travis Industries dealer. -
Page 11: Weatherproofing The Installation
In places where the controls beneath the appliance may be submerged underwater. Submerging any part of its controls may require the complete replacement of the controls. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 12: Clearances
Installation (qualified installers only) Clearances © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 13: Enclosure Ventilation Requirements
Failure to maintain the gap will create a severe fire risk and will void the appliance warranty. The height of the leveling legs can be adjusted by turning the leveling leg foot. The legs will adjust from 1/2" to 1" © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 14: Gas Line Requirements
The appliance comes with a 34” flex to make the connection from the gas stub-in to the key valve installed on the end of the enclosure. The flex accepts 3/4” MPT. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 15: Lp Conversion
(if already installed). Remove the media trays (see “Removing the Media Trays” section on page Convert the appliance using the instructions to the right. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 16: Electrical Connection Requirements
120VAC at approximately 0.9 amps - make sure the circuit and wiring is appropriately sized. The power supply must be routed through a switch to turn the appliance on and off (see pg. 41). Multiple Travis Industries, Inc. 24-volt appliances may be placed on a single circuit. Each appliance uses 24VAC at approximately 1.6 amps - Make sure the circuit and wiring is appropriately sized (see diagrams starting on pg. -
Page 17: Installation Details
Lift the media tray end and set it aside for reinstallation Repeat the previous (2) steps with the other end media tray. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... - Page 18 Cut the zip ties that secure the coiled up gas flex line on the burner tray assembly and the coiled up flex line attached to the key valve on the firepit enclosure. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits...
- Page 19 Use wire nuts to connect the low voltage wires to the white and yellow/white striped wires from the control module. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits...
- Page 20 Set the burner assembly into the enclosure. Take care not to scratch the powder coat on the enclosure. Reinstall the screws that secure the burner assembly into the enclosure. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits...
- Page 21 The appliance uses approximately 40 watts during startup (1.6 amps at 24 VAC). Make sure the circuit and wires are sized appropriately. The appliance requires a minimum of 22 VAC to operate (if the voltage drops below this, the appliance may not start). © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits...
-
Page 22: Using More Than One 24-Volt Appliance
(qualified installers only) Using More than One 24-volt Appliance Travis Industries, Inc. manufactures additional 24-volt appliances that can add to the ambiance of your outdoor space (Tempest Torch™, Tempest Lantern™. Visit tempesttorch.com for more details). If using more than one appliance, make sure to think about how the appliances will be used and if they need to be able to be controlled separately or if it would be more convenient to control them all using one switch. -
Page 23: Wiring Multiple Appliances To One Transformer
The manner in which you wire the appliances to the transformer affects the maximum length of wire and wire gauge. Make sure to determine the wire configuration before installation. NOTE: You may use both direct-run and daisy-chain configurations. Daisy-Chain Example Direct-Run Example © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 24: Daisy-Chain Wire Length Chart
Daisy-Chain Wire Length Chart This type of wire configuration allows for multiple Travis Industries 24-volt products to be wired in a series, reducing the amount of wire used. Use the charts below to determine the correct wire gauge and length. In the example below, the transformer has 2 Linear Fire Pits and a lantern on one branch. -
Page 25: Direct-Run Wire Length Chart
The wire will also be printed with a gauge number (e.g., AWG#14 = 14 gauge, 10AWG = 10 gauge, etc.). Do not use wires of dissimilar gauges (do not use 14 gauge & 10 gauge wire on the same transformer). © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 26: Steps For Finalizing The Installation
Crushed Glass Installation Crushed glass is placed over the burners and center media trays. Use only ¼” crushed glass from Travis Industries and/or other media specifically approved by Travis Industries. Placing Crushed Glass on the Burner and Center Media Trays 48x24 Fire Pit 15 lbs. -
Page 27: Tumbled Stone Installation
Tumbled Stone may be placed over the burners and media trays. Only use the Tumbled Stone media kit from Travis Industries. The amount of stone indicated on the chart below refers to the small stones used to cover the burner and media tray. Large stones may be placed anywhere over the media tray but should not be installed over the burner and are not included in the recommended weights in the chart below. -
Page 28: Assembling The Glass Wind Guard
Measure the distance from the edges of the fire pit enclosure to the edges of the glass to ensure that it is centered. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 29: Assembling The Glass Wind Guard (108" Units)
When installing the brackets on the glass panel with the logo, make sure that the brackets are on the opposite end from the logo (see illustration to the right). © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... - Page 30 6. Put the (2) halves of the wind guard together and secure them by tightening the set screws on the center brackets. Make sure not to overtighten the screws. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits...
- Page 31 Measure the distance from the edges of the fire pit enclosure to the edges of the glass to ensure that it is centered. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits...
-
Page 32: Before The First Fire
Inspect the appliance, burner, and supply lines for any damage prior to operation. The burner must be replaced prior to the appliance being put into operation if it is evident that the burner is damaged. Use only Travis Industries replacement burners. It may be difficult to see the burner operating in direct sunlight. -
Page 33: Location Of Controls
If the wall switch will be located where it is not protected from precipitation, it must be installed in a weather resistant enclosure (not included). © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 34: Maintaining Your Appliance
The glass may be cleaned with a non- abrasive cleaner. To clean the inside of the glass, remove the glass place it on a non- scratching surface, and clean the inside surface. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 35: Accessing Components
Remove all the screws from the media tray(both sides) and remove the trays. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 36: Accessing The Pressure Tap
appliance. Once maintenance or testing of components is complete, follow the above steps in reverse to return the appliance to its proper configuration. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 37: Winterizing The Appliance
Start the main burner. After 15 minutes, the flames should be orange/yellow. If the appliance is not burning correctly, contact your dealer for service. If the igniter is not getting hot or lighting the appliance properly contact your dealer for service. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... -
Page 38: Replacement Parts List
Maintenance Replacement Parts List Caution: Use only Travis Industries replacement parts. Do not use substitute materials. Warning: Do not operate the appliance with the glass wind guard removed, cracked, or broken. Replacement of the glass should be done by a licensed or qualified service person. -
Page 39: Troubleshooting Table
(spider webs, etc.) from the burner and dirty or blocked orifice area. Glass is Sooting Wind will influence the flame quality and, if Windy Condition persistent, may lead to sooting on the glass. © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... - Page 40 Register your TRAVIS INDUSTRIES, INC. Limited 7 Year Warranty online at traviswarranty.com. TRAVIS INDUSTRIES, INC. warrants this gas appliance (appliance is defined as the equipment manufactured by Travis Industries, Inc.) to be defect-free in material and workmanship to the original purchaser from the date of purchase as follows: Check with your dealer in advance for any costs to you when arranging a warranty call.
-
Page 41: Wiring Diagram
Wiring Diagram Wiring Diagram © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits... - Page 42 Notes © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits...
- Page 43 Notes © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits...
-
Page 44: Index
Glass Cleaning ..........32 Yearly Service Procedure ........ 35 Installation Warnings .......... 7 Index © Travis Industries, Inc. 10/26/23 - 1579 Outdoor Complete Linear Fire Pits...