Table of Contents
Advertisement
MAINTENANCE CHART
Operation to
be performed
Before
each use
10 hours
or once
a month
30 hours
three times
a season
50 hours
or twice
a season
100 hours
or
yearly
Before
storage
Retorque rear
wheel lug nuts
After first
10
hours
X
Lubricate brake
shaft
X
Check transmission
oil level
X
Clean cooling fins &
external surfaces
X
Service air cleaner
paper cartridge
More often
under dirty
conditions
Check spark plugs
X
X
Lubricate speed
control linkage
cam plates
X
Check and regrease
front wheel bearings
X
X
Drain fuel
X
Pivot bar adjust¬
ment bolt
X
TROUBLE SHOOTING
Possible Cause
Possible Remedy
HARD TO START
No 'gasoline in fuel tank or carburetor.
Fill the tank with gasoline; open the fuel shut-off valve.
Check the fuel line, and carburetor.
Fuel line or carburetor clogged.
Clean the fuel line and carburetor with commercial car¬
buretor cleaner.
Gas filter plugged.
Replace.
Water In gasoline.
Drain the fuel tank and carburetor. Use new fuel and dry
the spark plug.
Choked improperly. Flooded engine .
Follow the starting instructions.
Defective ignition or loose wiring.
Check the wiring, spark plug, or fuse.
Defective battery .
Check and service. Refer to "BATTERY."
Spark plug dirty or improper gap.
Clean, adjust the gap to .025-inch or replace the plug.
*See your authorized dealer.
24
Advertisement
Table of Contents
