Alternator And Regulator - Ford NEWHOLLAND 2000 Series Service Manual

Part 3
ELECTRICAL SYSTEM
Chapter 7
ALTERNATOR AND REGULATOR
Section
1.
Introduction
FORD 7000
Page
1
2. In-Vehicle Tests and Service Procedures. • • • • . . • • . . • • • • • 6
3. Alternator Overhaul and Bench Check . . • • • . • • • . • • • • • . • 16
4. Trouble Shooting . . . . . . . . . . . . • . . . • • • • • • . . • • • . • • • 30
5. Specifications . . . • . . . . . . . . . . . . . . . . . . . • • . • . • . • . • 32
6. Special Tools . . . . . . . . . . . . . . . . . . . . • _. • • • . . . . • . . 33
I. INTRODUCTION
ALTERNATOR
the terminal arrangement at the rear of the alternator.
Flgll'e 3 shows the side view.
The alternator system consists of an alternator and
,olid state voltage regulator, Figure 1. Figure 2 shows
1.
A Item at or
figure 1
Alternator and Regulator
2.
Voltage Regulator
Figure 2
Alternator Terminal Identification
1. Brush (Field) Terminal 4. Isolation Diode AHembly
2. Dust Shield
5. Output Terminal (Positive)
3. Auxlllary Terminal
6. Ground Terminal (Negative)
9/71
©
FORD MOTOR CO. 1971
PAGE 1