Charging The Battery; Battery Installation; Battery Storage - Club Car Carryall 295 2013 Maintenance And Service Manual

ELECTRICAL COMPONENTS: GASOLINE
VEHICLES

CHARGING THE BATTERY

See General Warnings on page 1-2.
1. Charge the battery with an automotive type 12-volt battery charger. Follow all warnings and procedures supplied
by the battery charger manufacturer.
2. Attach the charger, positive (+) cable to the positive (+) battery post and negative (–) cable to the negative (–)
battery post.
3. The battery may be charged with a slow charge (3 to 10 amps) or a fast charge (20 to 30 amps). Charge until the
specific gravity reaches 1.250. See following WARNING.
WARNING
• If the battery case feels hot (approximately 125 °F (52 °C) or more), emits gases, or fluid boils from
vents, stop charging immediately. Failure to stop charging battery when any of these conditions are
present could result in an explosion, personal injury and/or damage to the battery.
• Do not disconnect the charger DC leads from the battery when the charger is on. The resulting arcing
between the DC leads and battery post could cause an explosion.
• If the charger must be stopped, disconnect the AC supply cord from the wall outlet before
disconnecting the DC leads from the battery. Allow the battery to cool to room temperature and
resume charging battery at a lower amp rate.

BATTERY INSTALLATION

See General Warnings on page 1-2.
1. Place the battery into the vehicle with the battery posts facing the rear of the vehicle.
2. Secure the battery to the vehicle with the clamp at the bottom of the battery. Tighten the clamp retaining bolt to
9 ft-lb (12.2 N·m).
3. Connect battery and spark plug wire(s). See Connecting the Battery – Gasoline/Diesel Vehicles, Section
1, Page 1-4.

BATTERY STORAGE

See General Warnings on page 1-2.
1. Keep the battery clean and free of corrosion. See Preventive Maintenance on page 13-19.
2. Disconnect battery and spark plug wire(s). See Disconnecting the Battery – Gasoline/Diesel Vehicles on
page 1-3.
3. Fully charge the battery prior to storage.
4. Store in a cool, dry area. The colder the area in which the battery is stored, the less the battery will self-discharge.
A battery stored at 0 °F (-17.8 °C) will discharge very little over a four-month period. A battery stored at 80 °F
(27 °C) will have to be recharged every few weeks.
5. Check the state of charge periodically. A battery that is discharged and left in a cold environment can freeze and
crack. If the specific gravity drops below 1.220, the battery should be recharged. See following WARNING.
All manuals and user guides at all-guides.com
2013 Carryall 295/XRT 1550 Maintenance and Service Manual
13
Battery
Page 13-21