General Operation; Maintenance - Cushman 623525-H Owner's Manual

Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
Refer to GENERAL SPECIFICATIONS for vehicle seating capacity.
With electric powered vehicles, be sure that all electrical accessories are grounded directly to the battery (-) post.
Never use the chassis or body as a ground connection.
Never modify the vehicle in any way that will alter the weight distribution of the vehicle, decrease its stability or increase
the speed beyond the factory specification. Such modifications can cause serious personal injury or death. Modifica-
tions that increase the speed and/or weight of the vehicle will extend the stopping distance and may reduce the stability
of the vehicle. Do not make any such modifications or changes. The manufacturer prohibits and disclaims responsibil-
ity for any such modifications or any other alteration which would adversely affect the safety of the vehicle.
Vehicles that are capable of higher speeds must limit their speed to no more than the speed of other vehicles when
used in a golf course environment. Additionally, speed should be further moderated by the environmental conditions,
terrain and common sense.
Operation of the vehicle is limited to persons above the height of 59 inches (150 cm).

GENERAL OPERATION

ALWAYS:
• use the vehicle in a responsible manner and maintain the vehicle in safe operating condition
• read and observe all warnings and operation instruction labels affixed to the vehicle
• follow all safety rules established in the area where the vehicle is being operated
• Leave the vehicle when there is a risk of lightning.
• reduce speed to compensate for poor terrain or conditions
• apply service brake to control speed on steep grades
• maintain adequate distance between vehicles
• reduce speed in wet areas
• use extreme caution when approaching sharp or blind turns
• use extreme caution when driving over loose terrain
• use extreme caution in areas where pedestrians are present

MAINTENANCE

ALWAYS:
• Maintain the vehicle in accordance with the manufacturer's periodic service schedule
• nsure that repairs are performed by trained and qualified personnel
• Follow the manufacturer's maintenance procedures for the vehicle. Be sure to disable the vehicle before perform-
ing any maintenance. Disabling includes removing the key from the key switch and removal of a battery wire.
• Insulate any tools used within the battery area in order to prevent sparks or battery explosion caused by shorting
thebattery terminals or associated wiring. Remove the battery or cover exposed terminals with an insulating
material.
• Check the polarity of each battery terminal and be sure to rewire the batteries correctly
• Use specified replacement parts, NEVER use replacement parts of lesser quality
• Use recommended tools
• Determine that tools and procedures not specifically recommended by the manufacturer will not compromise the
safety of personnel nor jeopardize the safe operation of the vehicle
SAFETY
1
1 - 5