All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips 3141 785 31598 Version 1.8...
Page 2
1.0 TECHNICAL SPECIFICATION Playback disc type: DVD, Picture-CD, General SVCD, Video CD, MP3- CD, CD-R/CD-RW, WMA-CD, DVD-R, DVD- Dimensions (W x H x D): 293 x 170 x 33 mm RW, DVD+R, DVD+RW Weight: 0.85kg Power supply: DC 9V 1.8A Power consumption: Video Playback Format: DVD / VCD / JPEG...
Page 3
For the best performance of your DVD Portable. Check www.philips.com/support for latest software upgrades available. Download the latest software from the Philips support site Region code “0” can be used for all regions! Unzip the files and then burn it into a CD-ROM to...
Page 4
2.0 SAFTETY INSTRUCTIONS WAARSCHUWING WARNING Alle IC’s en vele andere halfgeleiders zijn All ICs and many other semi-conductors are gevoelig voor electrostatische ontladingen susceptible to electrostatic discharges (ESD). (ESD). Careless handling during repair can reduce life Onzorgvuldig behandelen tijdens reparatie kan drastically.
Page 5
2.1 ESD PROTECTION When the power supply is being turned on, you may not remove this laser cautions label. If it removes, radiation of laser may be received. PREPARATION OF SERVICING Pickup Head consists of a laser diode that is very susceptible to external static electrocity. Although it operates properly after replacement, if it was subject to electrostatic discharge during replacement, its life might be shortened.
Page 6
SAFTY NOTICE SAFTY PRECAUTIONS LEAKAGE CURRENT CHECK Plug the AC line cord directly into a 120V AC outlet (do Measure the AC voltage across the 1500 resistor. not use an isolation transformer for this check). Use an The test must be conducted with the AC switch on and AC voltmeter, having 5000 per volt or more sensitivity.
3.0 INSTRUCTIONS FOR USE DVD PLAYER LAYOUT OPEN POWER/IR/CHR Opens disc door to insert or Power /remote sensor /charging remove disc indicator. Confirms selection PHONES 1 & 2 POWER Headphones jack Switches the player on / off A/V OUT Audio/video output jack A/V IN Press once to stop playback Audio/video input jack...
Page 8
REMOTE CONTROL MENU SUBTITLE Display MENU page. Subtitle language selector. , , , RETURN Up / down / left / right For VCD menu page. navigation key. A - B To repeat or loop a sequence Confirm seletion. in a title. VOL +/- SETUP Volume control.
Page 9
4.0 MECHNICAL INSTRUCTIONS 1. Back side of the set as shown in Fig.1 5. Remove speaker grill and screw cushion on display frame Remove the screws on the base cover. as shown in Fig.5 Fig.1 Fig.5 2. Soldered short pattern for laser diode as shown in Fig.2 6.
5.0 TROUBLESHOOTING SYMPTOM: NO POWER, NO GREEN LED start Check if the power cable replace cable/ No defect, return set OK? adapter set to customer AC adapter Check if the replace connector power and play and switch unit button OK? replace MAIN go to other BOARD...
Page 11
5.0 TROUBLESHOOTING SYMPTOM: THE INITIAL SCREEN IS NOT DISPLAYED ON THE LCD Refer to the symptom NO start POWER, NO GREEN LED Replace broken Check if the Repair connector harness LED on the front lights up? Remove the LCD Open the top and Is the cover and plate of Check if the...
Page 12
5.0 TROUBLESHOOTING SYMPTOM: THE DVD DRIVE DOES NOT WORK Press the DISC cover switch at the center of the DVD player and turn on the power. Then check whether or not the optical pick- up lens of the DVD drive lights. CAUTION: start Visible laser radiation when open and interlock defeated.
Page 13
5.0 TROUBLESHOOTING SYMPTOM: THE DVD DRIVE DOES NOT OPERATE WITH BATTERY start Install a good battery does the LED lights up orange while the AC adapter is connected and does the DVD drive operate OK? NOTE: - For this check, use a battery which is not fully Replace battery charged (because the LED does not light when the battery is fully charged.)
Page 14
6.0 OVERALL BLOCK DIAGRAM (for PET730/732) FlashROM 64M SDRAM 27MHz TC7W53 74HCU04 KH29LU60CBTC-70G HY57V641620ETP-H 27MHz MX88V462UCG TFT MONITOR RF AMP & SERVO & DVD PROCESSOR DV23FB MPEG-2 DECODER & VIDEO ENCODER PU mechanism MT1389DE/H-L VIDEO IN +3.3V +1.8V DRIVER DRIVER +5V...
Page 15
6.0 OVERALL BLOCK DIAGRAM (for PET735) 16M FlashROM 128M SDRAM TC4W53 74HCU04 27MHz 27MHz MX29LV160CBTC-70G HY57V281620ETP-H-C VIDEO IN MX88V462UCG TFT MONITOR RF AMP & SERVO & DVD PROCESSOR DV23FB MPEG-2 DECODER & VIDEO ENCODER 32.768MHz PU mechanism MT1389DE/H-L 1.8V 3.3V DVB DEMO MT8606 DNOS504MM022A...
10.0 SERVICE PART LIST Electrical Part List: Service Service Description Photo Pos. 12NC PET730/00 996510001290 PET730M MAIN PCBA/00 PET732/00 PET730/05 996510001288 PET730M MAIN PCBA/05 PET730/44 996510001291 PET730M MAIN PCBA/44 PET730/58 996510001270 PET730M MAIN PCBA/58 PET730/98 996510004951 PET730M MAIN PCBA/98 PET735M MAIN PCB...
Page 43
10.0 SERVICE PART LIST Mechanical Part List: Service Service Description Photo Pos. 12NC PET730 LB070W02-TME1-SC PET732 996510001275 TFT LCD PET735 LB070W02-TME1-SC 996510001275 TFT LCD (S/N below LL3Cxxxxxxxxxx) PET738/93 LB070W02-TMC2-LED04 996510019988 TFT LCD (S/N from LL3Cxxxxxxxxxx) PET730 PET732 996510001276 DV23FB LOADING ASS’Y...
Page 44
10.0 SERVICE PART LIST Mechanical Part List: Service Service Description Photo Pos. 12NC PET730 996510001281 BASE COVER PET73X PET732 PET735 996510003008 BASE COVER PET735 PET738 PET730 PET732 996510001282 ADJUST HINGE PET73X PET735 PET738 PET730 DOOR DISCRETENESS PET735 996510001283 PET73X (BLACK)
Page 45
10.0 SERVICE PART LIST Accessories Part List: Service Service Photo Pos. No. 12NC Description PET730/00 PET730/44 PET730/58 AY4117 AC PET730/98 996510001286 POWER PET732/00 ADAPTOR/00 PET735/00 PET738/58 PET730/05 996510001289 AY4117 AC POWER ADAPTOR/05 ACADAPTOR PET730/37 994000004183 AY4117 AC POWER ADAPTOR/37 ADPV25A AC...
Version 1.3 (3141 785 31593) • Revise service part list. Replace 996510001550 to 996510001284 for PET732. Add 12NC of display frame plaque (display frame screw cushion) 996510002082 for PET730 & PET732. Version 1.4 (3141 785 31594) • Add service part list for PET735/00 Version 1.5 (3141 785 31595)