Table of Contents
Advertisement
Quick Links
INSTALLATION
AND
OPERATING
INSTRUCTIONS
TM
FASTRAC HORIZONTAL CONVEYOR TOASTER
UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES
WARNING: Improper installation, adjustment, alteration, service or maintenance can
!
cause property damage, injury or death. Read the Installation, Operating and
Maintenance Instructions thoroughly before installing or servicing this equipment.
This equipment has been engineered to provide you with year-round dependable service when used
according to the instructions in this manual and standard commercial kitchen practices.
Phone:
+1 (214) 421-7366
Fax:
+1 (214) 565-0976
Toll Free: +1 (800) 527-2100
Website: www.apwwyott.com
E-mail:
info@apwwyott.com
R
Model:
INTENDED FOR OTHER THAN HOUSEHOLD USE
RETAIN THIS MANUAL FOR FUTURE REFERENCE
TABLE OF CONTENTS
FT 800
1
2
3
4
4
5
5
6
6
8
10
11
!
P/N 67190 9/06
APW WYOTT
729 Third Avenue
Dallas, TX 75226
Advertisement
Table of Contents
Related Manuals for APW Wyott FASTRAC FT 800
Summary of Contents for APW Wyott FASTRAC FT 800
-
Page 1: Table Of Contents
P/N 67190 9/06 Phone: +1 (214) 421-7366 Fax: +1 (214) 565-0976 APW WYOTT Toll Free: +1 (800) 527-2100 Website: www.apwwyott.com 729 Third Avenue E-mail: info@apwwyott.com Dallas, TX 75226... -
Page 2: Safety Precautions
NOTICE: This symbol refers to information that needs special attention or must be fully understood even though not dangerous. APW Wyott takes pride in the design and quality of our products. When used as intended and with proper care and maintenance, you will experience years of reliable operation from this equipment. To ensure best results, it is important that you read and follow the instructions in this manual carefully. -
Page 3: Important Safety Instructions
WARNING: To avoid electrical shock or personal injury, do not steam clean or use excessive water on the unit. WARNING: If service is required on this unit, contact your authorized APW Wyott Service Agent, or contact the APW Wyott Service Department directly at (214) 421-7366 or (800) 527-2100; fax (214) 565-0976. -
Page 4: General Information
Some aftermarket or generic replacement parts do not have the characteristics that will allow them to operate safely in APW Wyott equipment. It is essential to use APW Wyott Replacement Parts when repairing APW Wyott equipment. Failure to use APW Wyott Replacement Parts may subject operators of the equipment to hazardous electrical voltage, resulting in electrical shock or burn. -
Page 5: Operation Instructions
III. Toaster Placement Locate the toaster near a grounded receptacle of the proper configuration (see below). Plug the cordset directly into receptacle (DO NOT USE AN EXTENSION CORD). 1. In the United States, NEMA 6-20R. 2. In Canada, NEMA 6-20R. Place the toaster on a flat surface providing the following minimum clearances: 1. -
Page 6: Warranty Procedure
Is power cord damaged? If YES, replace ONLY with an IDENTICAL power cord. If problems exist after checking the above, check the chart below. III. If any service is needed (italicized items), call an APW Wyott authorized service agency. All service should be performed by an APW Wyott authorized service agency. - Page 7 TROUBLESHOOTING CHART: THE PROBLEM THE CAUSE THE SOLUTION Won't toast... a. Toaster cold. a. Allow five (5) minutes for warm up. b. Wrong power switch position. b. Position power switch to full power. c. Wrong conveyor speed setting. c. Reduce conveyor speed. Toasts unevenly...
-
Page 8: Replacement Parts List
REPLACEMENT PARTS LIST - FT 800 ITEM DESCRIPTION 34236 TERMINAL BLOCK END MTG 34237 TERMINAL BLOCK (6) .250 MALE 38254 IDLER SHAFT ASSY 83956 DRIVE SHAFT ASSY 38244 CRUMB TRAY/REFLECTOR ASSY 38129 TOAST DRAWER 38131 WIRE FEEDER 54093 ELEMENT 208V 1400W 54094 ELEMENT 240V 1400W 58188... - Page 9 EXPLODED VIEW - FT 800 26 6...
-
Page 10: Wiring Diagram
IMPORTANT NOTICE: The information contained in this section of the manual is intended for individuals possessing backgrounds of electrical and mechanical experience, such as an authorized APW Wyott service technician. APW or the seller cannot be responsible for the interpretation of this information, nor can it assume any... -
Page 11: Warranty
APW Wyott's option or its Authorized Service Agency, it will be serviced on site or replaced. From day two through the conclusion of this warranty period, portable units must be taken to or sent prepaid to the APW Wyott Authorized Service Agency for in-warranty repairs. - Page 12 Phone: +1 (214) 421-7366 Fax: +1 (214) 565-0976 APW WYOTT Toll Free: +1 (800) 527-2100 729 Third Avenue Website: www.apwwyott.com Dallas, TX 75226 E-mail: info@apwwyott.com...