Fire Hazard - Traxxas SLEDGE Owner's Manual

WARNING! CAUTION! DANGER!

FIRE HAZARD!

This vehicle requires LiPo
batteries. Charging and discharging batteries has
the potential for fire, explosion, serious injury, and property
damage if not performed per the instructions. In addition, Lithium
Polymer (LiPo) batteries pose a SEVERE risk of fire if not properly
handled per the instructions and require special care and handling
procedures for long life and safe operation. LiPo batteries are
intended only for advanced users that are educated on the risks
associated with LiPo battery use. Traxxas does not recommend
that anyone under the age of 14 use or handle LiPo battery packs
without the supervision of a knowledgeable and responsible
adult. Dispose of used batteries according to the instructions.
• Your model requires the use of LiPo batteries. LiPo batteries have
a minimum safe discharge voltage threshold that should not be
exceeded. The electronic speed control is equipped with built-in
Low-Voltage Detection that alerts the driver when LiPo batteries
have reached their minimum voltage (discharge) threshold. It is the
driver's responsibility to stop immediately to prevent the battery
pack from being discharged below its safe minimum threshold.
• Low-Voltage Detection is just one part of a comprehensive plan
for safe LiPo battery use. It is critical to follow all instructions for
safe and proper charging, use, and storage of LiPo batteries. Make
sure you understand how to use your LiPo batteries. If you have
questions about LiPo battery usage, please consult with your local
hobby dealer or contact the battery manufacturer. As a reminder,
all batteries should be recycled at the end of their useful life.
• DO NOT use a charger designed for NiMH or NiCad batteries. The
use of a NiMH or NiCad charger or charge mode will damage the
batteries. Failure to use the correct charger may result in battery
damage, fire, personal injury, and/or property damage.
• ALWAYS inspect your LiPo batteries carefully before charging. Do
not use or charge battery packs that have been damaged in any way
(bent, dented, swollen, torn covering, or otherwise damaged).
• BEFORE you charge, ALWAYS confirm that the charger settings
exactly match the type (chemistry), specification, and configuration
of the battery to be charged. DO NOT exceed the maximum
manufacturer recommended charge rate. DO NOT attempt to charge
non-rechargeable batteries (explosion hazard), batteries that have
an internal charge circuit or a protection circuit, or batteries that
have been altered from original manufacturer configuration.
• While charging or discharging, ALWAYS place the
battery (all types of batteries) in a fire retardant/fire proof
container and on a non-flammable surface such as concrete.
• ALWAYS charge batteries in a well-ventilated area.
• Charge the battery in a safe area away from flammable materials.
Monitor the charging process and never leave batteries
unattended while charging. Do not allow small children to charge
or handle LiPo batteries.
• DO NOT disassemble, crush, short circuit, or expose the batteries to
flame or other source of ignition.
• DO NOT let any exposed battery contacts or wires touch each other.
This will cause the battery to short circuit and create the risk of fire.
• DO NOT leave the charger and battery unattended while charging,
discharging, or anytime the charger is ON with a battery connected.
If there are any signs of a malfunction, unplug the power source
and/or stop the charging process immediately.
• ALWAYS unplug the charger from the wall outlet and disconnect the
battery when not in use.
• Never charge LiPo battery packs in series or parallel. Charging packs
in series or parallel may result in improper charger cell recognition
and an improper charging rate that may lead to overcharging, cell
imbalance, cell damage and fire.
• If a battery gets hot to the touch during the charging process
(temperature greater than 110°F / 43°C), immediately disconnect the
battery from the charger and discontinue charging.
• DO NOT store or charge LiPo batteries with or around other batteries
or battery packs of any type, including other LiPos.
• Store and transport your LiPo batteries in a cool dry place. DO NOT
store in direct sunlight. DO NOT allow the storage temperature to
exceed 140°F or 60°C such as in the trunk of a car or the cells may be
damaged and risk of fire created. ALWAYS store battery packs safely
out of the reach of children and pets.
• Keep a Class D fire extinguisher nearby in case of fire.
• DO NOT disassemble LiPo batteries or cells. DO NOT disassemble the
charger.
• DO NOT attempt to build your own LiPo battery pack from loose
cells.
• REMOVE the battery from your model or device before charging.
• DO NOT expose the charger to water or moisture.
SAFETY PRECAUTIONS
SLEDGE • 5