INDICE INDEX Generalità 3 Overview ........................3 Avvertenze per l’installatore ................3 Advice for the installer ..................3 Marcatura CE ......................3 CE labelling .......................3 Norme di sicurezza ....................4 Safety regulations ....................4 Descrizione del prodotto .................5 Product description ....................5 Pannello comandi ....................5 Control Panel......................5 Dispaly ........................6 Display ........................6...
generalità overview Avvertenze per l’installatore Advice for the installer The installation and fi rst ignition of the boiler must be performed L’installazione e la prima accensione della caldaia devono essere by qualifi ed personnel in compliance with current national eff ettuate da personale qualifi cato in conformità alle normative nazionali di installazione in vigore e ad eventuali prescrizioni regulations regarding installation, and in conformity with any requirements established by local authorities and public health...
generalità overview Norme di sicurezza Safety regulations Legenda simboli: Key to symbols: Il mancato rispetto dell’avvertenza comporta rischio di lesioni, in Failure to comply with this warning implies the risk of personal determinate circostanze anche mortali, per le persone injury, in some circumstances even fatal Il mancato rispetto dell’avvertenza comporta rischio di Failure to comply with this warning implies the risk of damage, in danneggiamenti, in determinate circostanze anche gravi, per...
descrizione del prodotto product description Display Display Legenda Legend Cifre per indicazione: Digits indicating: - stato caldaia e indicazione - boiler status and temperature °C °C temperaure ( indication ( - Segnalazione codici d’errore (Err) - error code signals (Err) - Settaggio MENU - menu settings Richiesto intervento assistenza...
descrizione del prodotto product description Vista complessiva Overall view Legenda Legend Collettore scarico fumi Flue connector Valvola sfogo aria Air relief valve Main heat exchanger Scambiatore primario Detection Electrode Elettrodo di rilevazione fi amma C.H. Return temperature probe Sonda ritorno riscaldamento C.H.
descrizione del prodotto product description Dimensioni caldaia Overall Dimensions A. Central Heating Flow B. Domestic Hot Water Outlet A. Mandata impianto C. Gas Inlet B. Uscita acqua calda D. Domestic Cold Water Inlet C. Ingresso Gas E. Central Heating Return D.
descrizione del prodotto product description Dati tecnici Modello: CLAS PREMIUM EVO L Certifi cazione CE (pin) 0085CL0440 C13(X)-C23-C33(X)-C43(X)- Tipo caldaia C53(X)-C63(X)C83(X)- C93(X)-B23-B23P-B33 Portata termica nominale in riscaldamento max/min (Hi) 28.0/6.5 Portata termica nominale in riscaldamento max/min (Hs) 31.1/7.2 Portata termica nominale in sanitario max/min (Hi) 30.0/6.5 Portata termica nominale in sanitario max/min (Hs) 33.3/7.2...
descrizione del prodotto product description Technical Data Model: CLAS PREMIUM EVO L CE Certifi cation (pin) 0085CL0440 C13(X)-C23-C33(X)-C43(X)- Boiler type C53(X)-C63(X)C83(X)- C93(X)-B23-B23P-B33 Max/min nominal calorifi c fl ow rate (Pci) 28.0/6.5 Max/min nominal calorifi c fl ow rate (Pcs) 31.1/7.2 Domestic hot water max/min nominal calorifi c fl ow rate (Pci) 30.0/6.5 Domestic hot water max/min nominal calorifi c fl ow rate (Pcs)
installazione installation Before installing the appliance Avvertenze prima dell’installazione The boiler heats water to a temperature below boiling. La caldaia serve a riscaldare l’acqua ad una temperatura inferiore a quella di ebollizione. It should be connected to a heating system and to a domestic water mains supply, both of which must correspond in size to the Essa deve essere allacciata ad un impianto di riscaldamento e ad una rete di acqua sanitaria entrambi dimensionati in base alle sue...
installazione installation Gas connection Collegamento gas The boiler was designed to use gases belonging to the categories as La caldaia è stata progettata per utilizzare gas appartenenti alle shown in the following table. categorie come riportato sulla seguente tabella COUNTRY MODEL CATEGORIES NAZIONE...
installazione installation Per il dimensionamento delle tubazioni e dei corpi radianti For the measuring of the pipes and of the heating bodies in the dell’impianto di riscaldamento si valuti il valore di prevalenza residua heating system, the residual head value should be calculated as a in funzione della portata richiesta, secondo i valori riportati sul function of the requested fl ow rate, in accordance with the values grafi co del circolatore.
installazione installation Impianti a pavimento Underfl oor heating Negli impianti di riscaldamento a pavimento, installare un termostato For appliances with underfl oor heating, fi t a safety thermostat onto di sicurezza sulla mandata della caldaia (vedere Schema Elettrico). the underfl oor heating outlet. For the electrical connection of the Tale termostato deve essere collocato ad una distanza dalla caldaia thermostat see the section on “Electrical connections”.
installazione installation Collegamento condotti aspirazione e scarico fumi Connecting the Flue La caldaia è idonea a funzionare in modalità B prelevando aria The boiler is designed to operate in B mode (by drawing air from the dall’ambiente e in modalità C prelevando aria dall’esterno. room) and in C mode (by drawing air from outside).
installazione installation La caldaia è predisposta per l’allacciamento ad un sistema di The boiler is set up for connection to a 60/100 coaxial air intake and aspirazione e scarico fumi coassiale 60/100. fl ue gas exhaust ducting system. Per l’utilizzo di tipologie di aspirazione e scarico sdoppiato è To use split types of suction and exhaust, one of the two air intakes necessario utlizzare una delle due prese aria.
installazione installation Type of air suction/fl ue gas exhaust ducting Tipologie di aspirazione/scarico fumi Aria di combustione proveniente dall’ambiente Combustion air drawn from the room Scarico fumi all’esterno Air drawn from the room Aspirazione aria dall’ambiente External fl ue gas exhaust Scarico fumi in canna fumaria Individual or shared fl ue gas exhaust ducting singola o collettiva integrata nell’edifi cio...
installazione installation Attenzione! WARNING Prima qualunque intervento nella caldaia togliere Before performing any work on the boiler, fi rst disconnect it from l’alimentazione elettrica tramite l’interruttore bipolare esterno. the electrical power supply using the external bipolar switch. Collegamenti elettrici Electrical connections Per una maggiore sicurezza far eff ettuare da personale qualifi cato un For increased safety, ask a qualifi ed technician to perform a thorough controllo accurato dell’impianto elettrico.
installazione installation Collegamento Periferiche Peripheral unit connection Per accedere alle connessioni delle periferiche procedere come segue: To access peripheral unit connections carry out the following steps: - scollegare elettricamente la caldaia - Disconnect the boiler from the power supply - rimuovere il carter sganciandolo dal portastrumenti - Remove the casing by unhooking it from the instrument panel - rimuovere il mantello frontale - Rotate the control panel while pulling it forwards...
installazione installation Schema elettrico caldaia Electrical diagram Per una maggiore sicurezza far eff ettuare da personale qualifi cato un For increased safety, ask a qualifi ed technician to perform a thorough controllo accurato dell’impianto elettrico. check of the electrical system. Il costruttore non è...
messa in funzione commissioning Procedura di accensione Ignition procedure Premere il tasto ON/OFF sul pannello Press the ON/OFF button on the control panel to switch on the boiler. comandi per accendere la caldaia il The display shows: display visualizza: ● the operating mode: ●...
messa in funzione commissioning Prima accensione First ignition 1. Assicurarsi che: 1. Make sure that: il rubinetto gas sia chiuso; - The gas valve is closed; il collegamento elettrico sia stato eff ettuato in modo corretto. - The electrical connection has been properly carried out. Make Assicurarsi in ogni caso che il fi lo di terra verde/giallo sia sure that, in any case, the green/yellow earthing wire is connected collegato ad un effi ciente impianto di terra;...
messa in funzione commissioning Analisi della combustione Combustion checking procedure Nota: E’ indispensabile rispettare l’ordine delle operazioni da The order of operations for this procedure must always be respected. svolgere. Operazione 1 - Verifi ca della pressione di Operazione 1 - Supply pressure check alimentazione Loosen the screw 1 and insert the pressure gauge Allentare la vite 1 ed inserire il tubo di raccordo...
messa in funzione commissioning If the CO2 value (%) read diff ers from the values given in the table, Se il valore del C02 (%) è diverso da quanto indicato in tabella, then adjust the gas valve following the instructions below, otherwise procedere alla regolazione della valvola gas come sotto indicato, move directly onto operation 4.
messa in funzione commissioning Controllo della potenza di lenta accensione Checking slow ignition power menu 2/sottomenu 2/parametro 0 The soft light can be adjusted between the maximum power and the Con tale parametro si limita la potenza utile della caldaia in fase di minimum power.
Per attivare la funzione premere il tasto A To activate the function, press the A button. Per maggiori informazioni consultare il Manuale For further information please refer to the di Termoregolazione di ARISTON. ARISTON temperature adjustment manual. Esempio 1: Example 1: MPIANTO SINGOLA ZONA...
sistemi di protezione caldaia boiler protection devices Condizioni di arresto dell’apparecchio Appliance shut-off conditions The boiler is protected from malfunctions by means of internal La caldaia è protetta da malfunzionameto tramite controlli interni da checks performed by the electronic P.C.B., which stops the boiler parte della scheda elettronica, che opera se necessario un blocco di from operating if necessary.
sistemi di protezione caldaia boiler protection devices Sicurezza antigelo Anti-frost Device. La caldaia è dotata di una protezione antigelo che provvede The anti-frost function acts on the central heating fl ow temperature probe, al controllo della temperatura di mandata della caldaia: se tale independently from other settings, when the electrical supply is turned on.
menù impostazione - regolazione - diagnostica settings - adjustment - problem identifi cation menus Accesso ai Menu di Accessing the settings - adjustment - problem identifi cation impostazione - regolazione - diagnostica menus La caldaia permette di gestire in maniera completa il sistema di The boiler can be used to manage the heating and domestic hot riscaldamento e produzione di acqua calda ad uso sanitario.
Page 31
menù impostazione - regolazione - diagnostica settings - adjustment - problem identifi cation menus I parametri relativi ad ogni singolo menu sono riportati nelle pagine The parameters relating to each individual menu are listed in the following pages. seguenti. The various parameters can be accessed and modifi ed using the O L’accesso e la modifi ca dei vari parametri viene eff ettuata attraverso il button and the encoder (see fi g.
Page 32
menù impostazione - regolazione - diagnostica descrizione range description value note notes INSERIMENTO CODICE D’ACCESSO SERVICE CODE Rotate encoder clockwise to select code 234 and press OK ruotare l’encoder per selezionare 234 e premere il tasto OK 0 NETWORK 0 NETWORK 0 4 DISPLAY SETTING 0 4 IMPOSTAZIONE DISPLAY 0 4 0 Zone to be set by display...
Page 33
settings - adjustment - problem identifi cation menus descrizione range description value note notes 2 3 4 Percentuale Pot Max da 0 a 100 2 3 4 Heating maximum from 0 to 100 Riscaldamento percentage - NON MODIFICARE CANNOT BE MODIFIED RESERVED FOR TECHNICAL ASSISTANCE Only if the gas or PCB RISERVATO AL SAT Solo in caso di sostituzione della is changed see “gas setting”...
Page 34
menù impostazione - regolazione - diagnostica descrizione range description value note notes 2 5 2 Ritardo partenza in da 5 a 200 2 5 2 Hot water fl ow delay from 5 to 200 sanitario (da 0,5 a 20 secondi) (0.5 to 20 seconds) Anti-colpo d’ariete Anti "water hammering"...
Page 35
settings - adjustment - problem identifi cation menus descrizione range description value note notes 4 PARAMETRI ZONA 1 4 ZONE 1 PARAMETER 4 0 IMPOSTAZIONE TEMPERATURE ZONA 1 4 0 ZONE 1 TEMPERATURE SETTING 4 0 2 Impostazione da 35 a 82 (°C) 4 0 2 Fix temperature central from 35 to 82 (°C) Temperatura Fissa...
Page 36
menù impostazione - regolazione - diagnostica descrizione range description value note notes 4 2 3 Spostamento da - 14 a + 14 (°C) 4 2 3 Parallel curve shift Zone from - 14 to + 14 (°C) parallelo della curva di (imp.
Page 37
settings - adjustment - problem identifi cation menus descrizione range description value note notes 5 PARAMETRI ZONA 2 5 ZONE 2 PARAMETER 5 0 IMPOSTAZIONE TEMPERATURE ZONA 2 5 0 ZONE 2 TEMPERATURE SETTING 5 0 2 Impostazione da 35 a 82 (°C) 5 0 2 Fix temperature central from 35 to 82 (°C) Temperatura Fissa...
Page 38
menù impostazione - regolazione - diagnostica descrizione range description value note notes 5 2 4 Impostazione infl uenza da 0 a 20 5 2 4 Room sensor Infl uence from 0 to 20 del sensore ambiente to calculate the set- per il calcolo della point temperature temperatura di set-point...
Page 39
menù impostazione - regolazione - diagnostica settings - adjustment - problem identifi cation menus descrizione range description value note notes 6 PARAMETRI ZONA 3 6 ZONE 3 PARAMETER 6 0 IMPOSTAZIONE TEMPERATURE ZONA 3 6 0 ZONE 3 TEMPERATURE SETTING 6 0 2 Impostazione da 35 a 82 (°C) 6 0 2 Fix temperature central...
menù impostazione - regolazione - diagnostica settings - adjustment - problem identifi cation menus descrizione range description value note notes 6 2 4 Impostazione infl uenza da 0 a 20 6 2 4 Room sensor Infl uence from 0 to 20 del sensore ambiente to calculate the set- per il calcolo della...
menù impostazione - regolazione - diagnostica settings - adjustment - problem identifi cation menus descrizione range description value note notes 8 5 SERVICE - ASSISTENZA TECNICA 8 5 SERVICE 8 5 0 Impostazione tempo da 0 a 60 (mesi) 8 5 0 Months to next from 0 to 60 (month) mancante alla prossima maintenance...
manutenzione maintenance Istruzioni per l’apertura della mantellatura ed ispezione Instructions for opening the casing and performing an dell’interno internal inspection Prima di qualunque intervento nella caldaia togliere l’alimentazione Before performing any work on the boiler, fi rst disconnect it from the elettrica tramite l’interruttore bipolare esterno e chiudere il rubinetto electrical power supply using the external bipolar switch and shut off del gas.
manutenzione maintenance La manutenzione è essenziale per la sicurezza, il buon funzionamento Maintenance is an essential part of the safe and effi cient operation of e la durata della caldaia. Va eff ettuata in base a quanto previsto dalle the boiler and ensures its durability. It should be performed according norme vigenti.
manutenzione maintenance Operazioni di svuotamento Draining procedures Lo svuotamento dell’impianto di riscaldamento deve essere eseguito The heating system must be drained using the following procedure: nel seguente modo: - Switch off the boiler, make sure the external bipolar switch is in the - spegnere la caldaia e portare l’interruttore bipolare esterno in OFF position and shut off the gas valve;...
Page 45
manutenzione maintenance Targhetta caratteristicheì Symbols used on the data plate 60/80°C Legend : Legenda: 1. Brand Marchio 2. Manufacturer Produttore 3. Boiler model - Serial number Modello - Nr. di serie 4. Commercial reference Codice commerciale 5. certifi cation number Nr.
Page 46
199 111 222 Servizio clienti Costo della chiamata al telefono fisso: 0,143 Euro al minuto in fascia oraria intera e 0,056 Euro in fascia oraraia ridotta (IVA inclusa) Ariston Thermo SpA Viale A. Merloni, 45 60044 Fabriano (AN) www.aristonthermo.it info.it@aristonthermo.com...